MATERIAL SAFETY DATA SHEET
Carwell Products, Inc. Phone number: (716) 896-1677
2745 Broadway 鈥? Suite 22 Fax No: (716) 896-1686
Cheektowaga, NY 14227 Emergency No: (800) 856-6798
1. PRODUCT IDENTIFICATION
HMIS Symbol
Tradename: Carwell Rust Inhibitor T-32 (CP90) Health [1]
Flammability [1]
Rust Cop
Reactivity [0]
Family/
Personal
Chemical Name: Mixture of petroleum hydro carbons.
Protection [B]
Product Type: Corrosion Inhibitor
Chemical Formula: Proprietary
2. HAZARDOUS INGREDIENTS per 29 CFR 1910.1200
None
3. TYPICAL PHYSICAL AND CHEMICAL CHARACTERISTICS
Appearance and Odor: Light, red, liquid Specific Gravity: 0.9
Slight perfumy odor
Boiling Point: 480掳 F %Volatile (by volume): 0
Freezing Point: -20掳 F Vapor Density (Air = 1): 6
Solubility in Water: Insoluble pH N/A
4. FIRE AND EXPLOSION HAZARD DATA
Flash Point (COC): 365掳 F
Extinguishing Media: Carbon Dioxide, Foam, Dry Chemical or Water Spray
Copyright 铮?1998 Carwell Products, Inc. All rights reserved.
Special Fire-Fighting Procedures: Cool containers with water if exposed to fire.
5. REACTIVITY
Unusual Fire Hazards: Treat like petroleum fire.
Stability: Stable
Incompatibilities: Strong oxidizing agents
Hazardous Decomposition Thermal decomposition and burning may yield carbon dioxide,
Products: sulfur oxides.
6A. HEALTH HAZARD DATA
Effects of Acute Exposure to Product: Skin - No effects expected
Eyes - Misting or splashing into eyes may cause irritation and redness.
Inhalation - High concentrations of vapor or mist may be irritating to the respiratory tract.
Effects of Chronic Exposure to Product: Long term exposure may lead to skin irritation and dermatitis.
Prolonged or repeated inhalation of oil mist may cause oil pneumonia, inflammation with or without
pneumontis, fibrosis and paraffinoma.
LD50 of Product (Specify Species and Route): N.D. LC50 of Product: N.D.
Exposure limits of Product: 5 mg/m3 (mist) TWA
Carcinogenicity, Reproductive effects, Tertogenicity, Mutagenicity: None known.
6B. EMERGENCY AND FIRST AID PROCEDURES
Skin: Remove contaminated clothing and launder. Wash thoroughly with soap and water.
Eye: Flush immediately with large amounts of water until irritation subsides. If irritation
persists - consult a physician.
Inhalation: Remove to fresh air.
Ingestion: Do Not Induce Vomiting. Call a Physician.
General Advice: Treat With The Caution and Respect Due Any Industrial Chemical.
7A. SPILL OR LEAK PROCEDURES
Leak and Spill Procedure:
In the event of accidental spills or leaks prevent additional discharge of material. Dike and recover spilled
Copyright 铮?1998 Carwell Products, Inc. All rights reserved.
MSDS - Carwell Rust Inhibitor T32 - Page 3
product with absorbing material and place in closed containers for disposal.
Copyright 铮?1998 Carwell Products, Inc. All rights reserved.
MSDS - Carwell Rust Inhibitor T32 - Page 4
7B. DISPOSAL METHODS
Waste Disposal: Dispose of in accordance with local, State and Federal Regulations.
Eye Protection: None
8. SPECIAL PROTECTION INFORMATION
Protective Gloves: Not required for safety. Cleanliness use Neoprene or Isoprene gloves.
Respiratory: When misting the product use NIOSH/MSHA approved Dust/Mist respirator mask
(R95 or better) for oil mist.
9. SPECIAL PRECAUTIONS
Handling Procedures and Equipment: No special handling procedures or equipment required.
Storage Requirements: Store away from open flame.
10. REGULATORY PRECAUTIONS
DOT Class: Not regulated
DOT Number: None
TGL Classification: Not regulated.
NTP, IARC, and OSHA: Not listed as a carcinogen.
SARA Title III Section 313 Supplier Notification: This product does not contain toxic chemicals subject
to the reporting requirements of Section 313 of the Emergency Planning and Community Right-to-
Know Act of 1986 and of 40 CFR 372.
11. PREPARATION INFORMATION
Prepared by: Product MSDS Coordinator
Original Issue Date: March 23, 1989 Revised: October 7, 2002 Supersedes: Original
User assumes all risks incident to the use of this product. To the best of our knowledge, the information contained herein is accurate. However,
Carwell Product assumes no liability whatsoever for the accuracy or completeness of the information contained herein. No representations or
Copyright 铮?1998 Carwell Products, Inc. All rights reserved.
MSDS - Carwell Rust Inhibitor T32 - Page 5
warranties, either expressed or implied, or merchantability, fitness for a particular purpose or of any other nature are made hereunder with respect to
information or the product to which information refers. The data contained on this sheet apply to the material as supplied to the user.
Carwell Rust Inhibitor T32 (CP90)
This information applies to:
55 Gallon Drums, 5 Gallon Pails, Bottles 16 oz., CP90 Bottles (16 oz.), Rust Cop Aerosol Cans (16 oz.)
Carwell Rust Inhibitor T32 is a unique blend of rust inhibitors to control corrosion on all metals. It eliminates moisture
containing salt, dirt, and air pollutants from the surface of metal to give long lasting protection. It also lubricates moving
parts and is an excellent penetrant even through existing rust.
Directions:
Apply liberally to areas prone to corrosion, rusty areas, or seized parts. Allow time to penetrate on seized parts. Reapply
as needed to maintain the level of protection and lubrication desired. The product will not harm rubber, painted surfaces,
plastics, or glass.
Do not allow product to puddle or buildup on weather striping, rubber gaskets, or liners. Protect with silicone spray. Do
not apply to recently painted area for at least 48 hours after paint has properly dried and cured. Do not apply to parts that
are glued together like side moldings as the product may break down the glue.
Applications:
Ideal for:
Seams, welds, folds, and crevices Seized parts, nuts and bolts
蟻
Riveted pieces, chains Rollers, castors, hinges, brackets, release cables
蟻
Door & lock mechanisms Window regulators & wiper mechanism
蟻
Gas tanks & straps Coil & leaf springs, U bolts
蟻
Brake cables Electrical wiring, lights, electrical connectors, battery posts & cables
蟻
Wheel hub nuts Any area where dissimilar metals are fastened (aluminum & steel)
蟻
Oil pan, transmission nuts & bolts Radiator brackets, shrouds & casing
蟻
Mirror Mounts Headlight Adjusters
蟻
Use on:
Trucks, cars, vans, buses, trailers, tractors Lawn mowers, snow blowers
蟻
Salt spreaders, seeders, fertilizer spreaders Tools, shovels, rakes, metal boxes
蟻
particularly prior to or during periods of storage or as part of regular maintenance.
Caution
If product is misted it may be irritating to eyes
Avoid inhaling mist, as it may be irritating to breathing
Contains:
No hazardous Materials *
No Silicones, no solvents, no CFC鈥檚
*As defined by OSHA Regulation 29CFR-19-10.1200 Please refer to MSDS for further information.
**** For Commercial use only ****
Copyright 铮?1998 Carwell Products, Inc. All rights reserved.
|