MSDS Bulletin 87100e
Material Safety Data Sheet Date of Issue 02/21/2006
Supercedes n/a
UlTrEX EXTrEmE DUTY SYNTHETIC Page 1 of 5
BlEND GrEaSE NlGI #1
TESCO
SECTION 1 GENEral INfOrmaTION
Chemical Name & Synonyms: Trade Name & Synonyms:
N/A ULTREX EXTREME DUTY SYNTHETIC BLEND GREASE NLGI #1
Chemical Family: Formula Mixture:
CALCIUM SULFONATE/HYDROCARBON BLEND X
Manufacturer鈥檚 Name: TESCO CORPORATION
Address: 6204 6A STREET, S.E.
CALGARY, ALBERTA, CANADA
T2H 2B7
Prepared By: M McDowell/Chemist
Product Code Number: 731142
800-424-9300
Emergency Phone Number:
SECTION 2 HaZarDOUS INGrEDIENTS
THE HAZARDS PRESENTED BELOW ARE THOSE OF THE INDIVIDUAL COMPONENTS:
Chemical Name (Ingredients): CALCIUM STEARATE SOAP
Chemical Name (Ingredients): HEXYLENE GLYCOL
Percent: 15-20
Percent: 1-5
Hazard: IRRITANT
Hazard: IRRITANT
TLV: N/E 1
TLV: N/E 1
PEL: N/E 2
PEL: N/E 2
STEL: N/E
STEL: 25 PPM CEILING LIMIT 1
CAS#: 68608-31-1
CAS#: 107-41-5
Chemical Name (Ingredients): POLY ALPHA OLEFIN
Chemical Name (Ingredients): CALCIUM PHOSPHATE
Percent: 1-5
Percent: 10-15
Hazard: IRRITANT
Hazard: IRRITANT
TLV: 5 MG/M3 $1
TLV: N/E 1
PEL: 5 MG/M3 $2
PEL: N/E 2
STEL: 10 MG/M3$1
STEL: N/E
CAS#: 68649-12-7
CAS#: 7757-93-9
Chemical Name (Ingredients): CALCIUM ACETATE CARBONATE HYDROGENATED CASTROL FATTY ACID
Percent: 25-30
Hazard: IRRITANT
TLV: N/E 1
PEL: N/E 2
STEL: N/E
CAS#: 68307-88-0
Chemical Name (Ingredients): HYDROGENATED HEAVY PARAFFINIC PETROLEUM DISTILLATE
Percent: 35-40
Hazard: IRRITANT
TLV: 5 MG/M3 $1
PEL: 5 MG/M3 $2
STEL: 10 MG/M3$1
CAS#: 64741-88-4
$ OIL MIST VALUES
SECTION 3 PHYSICal DaTa
Boiling Point (f): 610掳
Specific Gravity (H20=1): 1.01
Vapor Pressure (MM HG): <0.01
Color: BLUE-GREEN
Vapor Density (Air=1): 15.7
Odor: ODORLESS
pH @ 100%: N/A
Clarity: OPAQUE
Material Safety Data Sheet Page 2 of 5
UlTrEX EXTrEmE DUTY SYNTHETIC
BlEND GrEaSE NlGI #1
Volatile by Volume: 2.0
Evaporation Rate (BU A/C=1): <0.01
H20 Solubility: NEGLIGIBLE
Viscosity: VISCOUS
SECTION 4 fIrE aND EXPlOSION HaZarD
Flash Point: 495掳F / C.O.C.
Flammable Limits: HEXYLENE GLYCOL LEL: 1.2% UEL:8.1%
Extinguishing Media: Foam: X Alcohol Foam: X CO2: X
Dry Chemical: X Water Spray: X Other:
Special Fire Fighting Procedures:
FIREFIGHTERS SHOULD WEAR A SELF-CONTAINED BREATHING APPARATUS AND FULL
PROTECTIVE GEAR. EXTINGUISHING MEDIA SHOULD BE CHOSEN BASED ON THE NATURE OF THE
SURROUNDING FIRE. COOL FIRE-EXPOSED CONTAINERS WITH WATER SPRAY TO PREVENT
BURSTING.
Unusual Fire and Explosion Hazards:
THE USE OF WATER SPRAY (F0G) WHILE EFFECTIVE, MAY CAUSE FROTHING AND FOAMING.
NEVER USE A WATER JET AS THIS WILL JUST SPREAD THE FIRE. USE CARE AS SPILLS MAY BE
SLIPPERY.
Aerosol Level (NFPA 30B): N/A
NFPA 704 Hazard Rating: (0=Insignificant 1=Slight 2=Moderate 3=High 4=Extreme)
Health: 2 Flammability: 1 Instability: 0 Special:
SECTION 5 HEalTH HaZarD DaTa
Threshold Limit Value: 5 MG/M3 AS OIL MIST 1.
Effects of Overexposure: -Acute(Short Term Exposure)
EYE CONTACT: CAUSES SEVERE IRRITATION SEEN AS STINGING, TEARING, REDNESS, SWELLING,
EXCESSIVE BLINKING, BLURRED VISION, AND A BURNING SENSATION. CAUSES CORNEAL
DAMAGE. SKIN CONTACT: MAY CAUSE IRRITATION SEEN AS ITCHING, REDNESS, SWELLING, AND
A BURNING SENSATION. PROLONGED OR REPEATED CONTACT AS FROM CLOTHING WET WITH
MATERIAL MAY CAUSE DRYING, DEFATTING, AND CRACKING OF THE SKIN. MAY CAUSE ALLERGIC
SKIN REACTION SEEN AS DELAYED SKIN RASH WHICH MAY BE FOLLOWED BY BLISTERING,
SCALING, AND OTHER SKIN EFFECTS. INHALATION: MAY CAUSE CHEST PAIN AND RESPIRATORY
IRRITATION SEEN AS COUGHING AND SNEEZING. INGESTION: MAY CAUSE IRRITATION WITH
POSSIBLE NAUSEA, VOMITING, AND DIARRHEA. MAY CAUSE CENTRAL NERVOUS SYSTEM
EFFECTS SUCH AS HEADACHE, DIZZINESS, DROWSINESS, WEAKNESS, UNCONCIOUSNESS,
POSSIBLE ANESTHETIC EFFECTS FROM CENTRAL NERVOUS SYSTEM DEPRESSION, AND MAY BE
FATAL.
-Chronic (Long Term Exposure)
MAY CAUSE SKIN SENSITIZATION IN SOME INDIVIDUALS. ON RARE OCCASIONS, PROLONGED
AND REPEATED EXPOSURE TO HYDROCARBON MIST POSES A RISK OF CHRONIC LUNG
INFLAMMATION. THIS CONDITION IS USUALLY ASYMPTOMATIC AS A RESULT OF REPEATED SMALL
ASPIRATIONS. SHORTNESS OF BREATH AND COUGHING ARE THE MOST COMMON SYMPTOMS.
ASPIRATION MAY LEAD TO PULMONARY EDEMA AND HEMORRHAGE AND MAY BE FATAL. SIGNS OF
LUNG INVOLVEMENT INCLUDE INCREASED RESPIRATION AND HEART RATES AS WELL AS A
BLUISH DISCOLORATION OF THE SKIN. CHRONIC SKIN CONTACT MAY PROMOTE DERMATITIS AND
OIL ACNE. IN RARER CASES, AN INCREASED SENSTIVITY TO SUNLIGHT (PHOTOSENSITIVITY) MAY
OCCUR. MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE ARE PRE-EXISTING RESPIRATORY
AND SKIN CONDITIONS SUCH AS ASTHMA, EMPHYSEMA, AND DERMATITIS. TARGET ORGANS:
CENTRAL NERVOUS SYSTEM AND BLOOD-FORMING ORGANS. THE PRIMARY ROUTES OF
EXPOSURE ARE SKIN AND EYE CONTACT.
Primary Routes of Entry: Inhalation: Ingestion: Absorption: X
Emergency and First Aid Procedures: -Inhalation:
REMOVE FROM THE AREA TO FRESH AIR. SEEK MEDICAL ATTENTION IF RESPIRATORY IRRITATION
DEVELOPS OR IF BREATHING BECOMES DIFFICULT.
-Eye Contact:
IMMEDIATELY RINSE THE EYES WITH WATER. REMOVE ANY CONTACT LENSES AND CONTINUE
FLUSHING FOR AT LEAST 15 MINUTES. HOLD THE EYELIDS APART TO ENSURE RINSING OF THE
ENTIRE SURFACE OF THE EYES AND LIDS WITH WATER. GET IMMEDIATE MEDICAL ATTENTION.
Material Safety Data Sheet Page 3 of 5
UlTrEX EXTrEmE DUTY SYNTHETIC
BlEND GrEaSE NlGI #1
-Skin Contact:
WIPE AWAY MATERIAL WITH A CLOTH WHILE REMOVING CONTAMINATED CLOTHING AND SHOES.
WASH WITH SOAP AND WATER. SEEK MEDICAL ATTENTION IF IRRITATION DEVELOPS. CLEAN
CLOTHING AND SHOES.
-Ingestion:
GIVE 3 TO 4 GLASSES OF WATER, BUT DO NOT INDUCE VOMITING. IF VOMITING OCCURS, GIVE
FLUIDS AGAIN. SEEK MEDICAL ATTENTION IF DISCOMFORT OCCURS.
-Notes to Physician:
THERE IS NO SPECIFIC ANTIDOTE. TREAT THE PATIENT SYMPTOMATICALLY.
SECTION 6 TOXICITY INfOrmaTION
Product Contains Chemicals Listed as Carcinogen or Potential Carcinogen By:
IARC: No NTP: No OSHA: No
ACGIH: No OTHER: No
VOC CONTENT: 1.9% BY WEIGHT, 2.0% BY VOLUME, 19 G/L
HEXYLENE GLYCOL ORL-RAT LD50: 3700 MG/KG 3.
ORL-RAT LDL0: 33600 MG/KG/28D-I CHANGES IN LIVER, BLADDER, KIDNEY 4.
IHL-RAT LC50: NO DEATHS: 66 PPM/8H 4.
SKN-RBT LD50: 8560 UL/KG 3.
SKN-RBT SDT: 465 MG/24H 3.
EYE-RBT SDT: 93 MG/24H SEVERE 3.
IN A REPEATED PATCH TEST STUDY OF ECZEMA PATIENTS, HEXYLENE GLYCOL ELICITED EDEMA
AND ERYTHEMA IN 2.8% OF THE SUBJECTS TESTED (CONTACT DERMATITIS 21:154, 1989) 4.
HEXYLENE GLYCOL HAS PRODUCED EVIDENCE OF SLIGHT FETAL TOXICITY AT A MATERNALLY
TOXIC DOSE (1000 MG/KG/DAY) 4.
CALCIUM STEARATE SOAP NO TOXICITY DATA AVAILABLE
CALCIUM PHOSPHATE (SIMILAR COMPOUND) ORL-RAT LD50: 3986 MG/KG 3.
SKN-RBT LD50: >2 G/KG 3.
CALCIUM ACETATE CARBONATE HYDROGENATED CASTROL FATTY ACID
NO TOXICITY DATA AVAILABLE
POLY ALPHA OLEFIN EYE-RBT SDT: 0.7/24 HOURS 4.
SKN-RBT PRIMARY IRRITATION INDEX: 0.2/4 HOURS 4.
HYDROGENATED HEAVY PARAFFINIC PETROLEUM DISTILLATE
ORL-RAT LD50: > 2 G/KG 4.
SKN-RBT LD50: > 2 G/KG 4.
IHL-RAT LC50: > 5 MG/L 4.
EYE-RBT DRAIZE SCORE BETWEEN 6 AND 15, PRACTICALLY
NON-IRRITATING 4.
SKN-RBT DRAIZE SCORE BETWEEN .5 AND 3, PRACTICALLY
NON-IRRITATING 4.
MINERAL OIL MISTS DERIVED FROM HIGHLY REFINED OILS ARE REPORTED TO HAVE LOW ACUTE
AND SUB-ACUTE TOXICITIES IN ANIMALS. EFFECTS FROM SINGLE AND SHORT-TERM REPEATED
EXPOSURES TO HIGH CONCENTRATIONS WELL ABOVE APPLICABLE WORKPLACE EXPOSURE
LEVELS INCLUDE LUNG INFLAMMATORY REACTION, LIPOID GRANULOMA FORMATION, AND LIPOID
PNEUMONIA. IN ACUTE AND SUB-ACUTE STUDIES INVOLVING EXPOSURES TO LOWER
CONCENTRATIONS AT OR NEAR CURRENT WORK PLACE EXPOSURE LEVELS PRODUCED NO
SIGNIFICANT TOXICOLOGICAL EFFECTS. IN LONG TERM STUDIES (UP TO TWO YEARS) NO
CARCINOGENIC EFFECTS HAVE BEEN REPORTED IN ANY ANIMAL SPECIES TESTED. THESE
PETROLEUM DISTILLATES ARE SEVERELY HYDROTREATED, SEVERELY SOLVENT EXTRACTED,
AND/OR PROCESSED BY MILD HYDROTREATMENT AND EXTRACTION. FOR THIS REASON, THEY
ARE NOT CLASSIFIED AS CANCER HAZARDS. 4.
SECTION 7 rEaCTIVITY DaTa
Stability: Stable: X Unstable:
Conditions to Avoid: NONE KNOWN.
Material Safety Data Sheet Page 4 of 5
UlTrEX EXTrEmE DUTY SYNTHETIC
BlEND GrEaSE NlGI #1
Incompatibility (Materials to Avoid): STRONG OXIDIZING AGENTS SUCH AS CHLORINE BLEACH AND
CONCENTRATED HYDROGEN PEROXIDE; ACIDS.
Hazardous Decomposition Products: OXIDES OF CARBON, NITROGEN, AND SULFUR.
Hazardous Polymerization: May Occur: Will Not Occur: X
Conditions to Avoid: N/A
SECTION 8 SPIll Or lEaK PrOCEDUrES
Steps to be Taken if Material is Released or Spilled:
WEAR APPROPRIATE PROTECTIVE CLOTHING. SHUT OFF SOURCE OF LEAK. FOR LARGE SPILLS,
SCOOP INTO A PROPERLY LABELED CONTAINER FOR REUSE OR DISPOSAL. FOR SMALL SPILLS,
WIPE WITH A CLOTH AND TRANSFER ALL MATERIALS INTO A PROPERLY LABELED CONTAINER
FOR DISPOSAL. USE CARE AS SPILLS MAY BE SLIPPERY.
Waste Disposal Method(s): DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, STATE, AND LOCAL
REGULATIONS.
Neutralizing Agent: N/A
SECTION 9 SPECIal PrOTECTION INfOrmaTION
Required Ventilation: GENERAL VENTILATION IS NORMALLY ADEQUATE. LOCAL VENTILATION IS RECOMMENDED TO
CONTROL EXPOSURE FROM OPERATIONS THAT CAN GENERATE EXCESSIVE LEVELS OF MISTS.
LOCAL VENTILATION IS PREFERRED, BECAUSE IT PREVENTS DISPERSION INTO WORK AREAS BY
CONTROLLING IT AT ITS SOURCE.
Respiratory Protection: NONE REQUIRED UNDER NORMAL CONDITIONS OF USE. RESPIRATORS SHOULD BE SELECTED
BY AND USED UNDER THE DIRECTION OF A TRAINED HEALTH AND SAFETY PROFESSIONAL
FOLLOWING REQUIREMENTS FOUND IN OSHA鈥橲 RESPIRATOR STANDARD (29 CFR 1910.134) AND
ANSI鈥橲 STANDARD FOR RESPIRATORY PROTECTION (Z88.2-1992). FOR CONCENTRATIONS ABOVE
THE TLV AND/OR PEL BUT LESS THAN 10 TIMES THESE LIMITS, A NIOSH APPROVED
HALF-FACEPIECE RESPIRATOR EQUIPPED WITH APPROPRIATE CHEMICAL CARTRIDGES MAY BE
USED. FOR CONCENTRATIONS GREATER THAN 10 TIMES THE TLV AND/OR PEL, CONSULT THE
NIOSH RESPIRATOR DECISION LOGIC FOUND IN PUBLICATION NO. 87-116 OR ANSI Z88.2-1992.
Glove Protection: NEOPRENE OR NITRILE RUBBER GLOVES SHOULD BE WORN. ENSURE COMPLIANCE WITH
OSHA鈥橲 PERSONAL PROTECTIVE EQUIPMENT (PPE) STANDARD FOR HAND PROTECTION,
29 CFR 1910.138.
Eye Protection: CHEMICAL GOGGLES SHOULD BE WORN. ENSURE COMPLIANCE WITH OSHA鈥橲 PERSONAL
PROTECTIVE EQUIPMENT (PPE) STANDARD FOR EYE AND FACE PROTECTION, 29 CFR 1910.133.
Other Protection: WEAR PROTECTIVE CLOTHING WHEN HANDLING. REMOVE SOAKED CLOTHING AND SHOES.
WASH CLOTHING AND CLEAN SHOES BEFORE REUSE. A SAFETY SHOWER AND AN EYEWASH
STATION SHOULD BE AVAILABLE.
SECTION 10 STOraGE aND HaNDlING INfOrmaTION
Storage Temperature: Indoors: X Outdoors: X Heated: X Refrigerated: X
Minimum Temperature: 0掳F Maximum Temperature: 120掳F
Precautions to be taken in Handling and Storing:
ALWAYS STORE MATERIAL IN ITS ORIGINAL CONTAINER. KEEP CONTAINER TIGHTLY CLOSED
WHEN NOT IN USE. EMPTY CONTAINERS MAY CONTAIN PRODUCT RESIDUES WHICH MAY EXHIBIT
THE HAZARDS OF THE PRODUCT. TO AVOID POSSIBLE EXPLOSION DO NOT PRESSURIZE, CUT,
WELD, SOLDER, DRILL, GRIND, OR EXPOSE EMPTY CONTAINERS TO HEAT, HOT SURFACES,
SPARKS, OR OPEN FLAMES. BULK STORAGE: FOR MAXIMUM PRODUCT LIFE, STORE INDOORS.
OUTDOOR STORAGE TIP: STORE CONTAINERS ON THEIR SIDE TO HELP PREVENT WATER
ACCUMULATION ON A FLAT END AND CONSEQUENT PRODUCT CONTAMINATION. CARTRIDGE
STORAGE: FOR MAXIMUM PRODUCT LIFE, STORE INDOORS OR IN A COOL, DRY AREA. ALWAYS
STORE IN AN UPRIGHT POSITION TO PREVENT OILS FROM LEAKING OUT OF THE CARTRIDGE.
Other Precautions: KEEP OUT OF REACH OF CHILDREN. READ THE ENTIRE LABEL BEFORE USING THE PRODUCT.
FOLLOW THE LABEL DIRECTIONS.
Material Safety Data Sheet Page 5 of 5
UlTrEX EXTrEmE DUTY SYNTHETIC
BlEND GrEaSE NlGI #1
SECTION 11 rEGUlaTOrY INfOrmaTION
Chemical Name CAS Number Upper % Limit
Those Ingredients listed above are subject to the reporting requirements of 313 of Title III and of the
Superfund Amendments and Reauthorization Act of 1986 and 40 CFR part 372.
CALIFORNIA PROPOSITION 65
WARNING: This product contains the following chemical(s) know to the State of California to cause
(1)Cancer or (2)Birth Defects or other reproductive harm. THIS PRODUCT CONTAINSARSENIC(1&2),
CADMIUM(1&2), TOLUENE(2), MERCURY(2), ISOPRENE(1), ACETALDEHYDE(1), BERYLLIUM(1),
CHROMIUM(1), NICKEL(1), CRYSTALLINE SILICA(1), AND LEAD(1&2) AS TRACE CONTAMINANTS.
SECTION 12 rEfErENCES
1. THRESHOLD LIMIT VALUES FOR CHEMICAL SUBSTANCES AND PHYSICAL AGENTS AND
BIOLOGICAL EXPOSURE INDICES, ACGIH, 2005.
2. OSHA PEL.
3. REGISTRY OF TOXIC EFFECTS OF CHEMICAL SUBSTANCES, CCINFOWeb, 2005.
4. VENDOR鈥橲 MSDS.
ALL THE COMPONENTS OF THIS PRODUCT ARE IN COMPLIANCE WITH THE TOXIC SUBSTANCES
CONTROL ACT (TSCA) AND ARE EITHER LISTED ON THE TSCA INVENTORY OR OTHERWISE
EXEMPTED FROM LISTING.
IRR:IRRITANT, FLAM/FLAMM:FLAMMABLE, COMB:COMBUSTIBLE, CORR:CORROSIVE
CARC:CARCINOGENIC, TOX:TOXIC, N/A:NOT APPLICABLE, N/E:NOT ESTABLISHED,
COC:CLEVELAND OPEN CUP, PMCC:PENSKY-MARTIN CLOSED CUP, TCC:TAGLIABUE CLOSED
CUP, LEL:LOWER EXPLOSION LIMIT, UEL:UPPER EXPLOSION LIMIT, NFPA:NATIONAL FIRE
PROTECTION ASSOCIATION, IARC:INTERNATIONAL AGENCY FOR THE RESEARCH ON CANCER,
NTP:NATIONAL TOXICOLOGY PROGRAM, OSHA:OCCUPATIONAL SAFETY & HEALTH
ADMINISTRATION, ACGIH:AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL
HYGIENISTS, TLV:THRESHOLD LIMIT VALUE, PEL:PERMISSIBLE EXPOSURE LIMIT,
STEL:SHORT-TERM EXPOSURE LIMIT, MLD:MILD, MOD:MODERATE, SEV:SEVERE,
MUT:MUTAGENIC, ASPHYX:ASPHYXIANT, PNOS:PARTICLES (INSOLUBLE) NOT OTHERWISE
SPECIFIED, SDT:STANDARD DRAIZE TEST, ORL:ORAL, IHL:INHALATION, HMN:HUMAN
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE IN LIGHT OF
CURRENT FORMULATION. HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING
THE ACCURACY OF THESE DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF.
MATERIAL SAFETY DATA SHEET
GREASE, EX DUTY NLGI #1, TESCO
Global locations:
Asia Pacific
Canada Scotland
Calgary, Alberta Jakarta, Indonesia Aberdeen, Aberdeenshire
Email: CABU_Sales@tescocorp.com Email: APBU_Sales@tescocorp.com Email: EURO_Sales@tescocorp.com
United States Middle East & Africa Russia
Houston, Texas Jebel Ali Free Zone Moscow
United Arab Emirates
Email: USBU_Sales@tescocorp.com Email: RUSSIA_Sales@tescocorp.com
Email: MEABU_Sales@tescocorp.com
Argentina, Bolivia, Brasil,
Colombia, Ecuador, Mexico, China
Trinidad, Venezuela Chaoyang District , Beijing,
TESCO
Buenos Aires, Argentina Email: CHINA_Sales@tescocorp.com
Email: LABU_Sales@tescocorp.com
Printed in Canada
|