HENRY COMPANY CANADA INC.
10 St-Pierre, Lachine, Quebec H8R 1N7
Tel.:(514) 364-5224 Fax:(514)364-7270
EMERGENCY TEL. NO.: (514) 364-5224
MATERIAL SAFETY DATA SHEET
WHMIS: Not controlled
I - PRODUCT INFORMATION
Bakor Air-Bloc 31
PRODUCT NAME
Aqueous emulsion
PRODUCT TYPE
Liquid water based air barrier
PRODUCT USE
II - HAZARDOUS INGREDIENTS
INGREDIENTS % CAS # EXPOSURE LIMITS LD50/LC50(SPECIES & ROUTE)
Ethylene Glycol 1-5 107-21-1 50 ppm (ACGIH) LD50 (oral-rat) > 4700 mg/kg
TLV-vapour LD50(skin-rabbit) > 9530 mg/kg
III - PHYSICAL DATA
PHYSICAL [ ] GAS ODOUR & APPEARANCE ODOUR THRESHOLD (ppm)
Light grey, water based emulsion; slight sweet odour. N/A
STATE [x] LIQUIDE
[ ] SOLID
VOC
VOLATILE (VOL.) VAPOUR PRESSURE (mm Hg) VAPOUR DENSITY (AIR = 1) EVAPORATION RATE (BuAc=1)
46 - 50 % < 50 g/L As for water As for water As for water
BOILING POINT (掳C) FREEZING POINT (掳C) SPEC. GRAVITY (WATER - 1) DENSITY (g / ml)
100掳C 0掳C 1.01 1.01
Miscible in water as supplied
SOLUBILITY (IN WATER) COEF. OF WATER/OIL DIST. pH
Insoluble when dry N/D 9-11
IV - FIRE & EXPLOSION HAZARD
FLAMMABILITY [ ] YES CONDITIONS OF FLAMMABILITY
Not applicable.
[ X ] NO
None
FLASH POINT (掳C): FLAMMABLE LIMITS (% VOLUME) AUTO-IGNITION TEMP. (掳C)
None None None
METHOD: LOWER: UPPER:
TDG FLAMMABILITY CLASS SENSITIVITY TO MECHANICAL IMPACT SENSITIVITY TO STATIC DISCHARGE
Not Applicable None None
Exposure to flames or fire may cause thermal degradation with evolution SO2, CO and CO2.
HAZARDOUS COMBUSTION
Main combustion products are H2O, CO2 and C (as heavy smoke).
PRODUCTS
Not applicable
MEANS OF EXTINCTION
Not applicable
SPEC. FIRE FIGHTING PROCEDURES
V - PREPARATION OF M.S.D.S.
PREPARED BY: PHONE NUMBER DATE
WHMIS Group (514) 364-5224 May 2006
VI - REACTIVITY DATA Bakor Air-Bloc 31
CHEMICAL [ X ] YES CONDITIONS TO AVOID:
Freezing will damage emulsion. Acids will coagulate the product.
STABILITY [ ] NO
Materials that react with water.
INCOMPATIBILITY
(SUBSTANCE TO AVOID)
None.
CONDITIONS
OF REACTIVITY
If exposed to very high temperatures, thermal decomposition will give off CO and CO2.
HAZARDOUS DECOMPOS-
ITION PRODUCTS
VII - TOXICOLOGICAL PROPERTIES
LD50 (oral-rat) > 4700 mg/kg
THRESHOLD LIMIT VALUE LC50/LD50 (estimated)
50 ppm LD50 (skin-rabbit) > 9530 mg/kg
ROUTE OF ENTRY [ ] SKIN CONTACT [ ] SKIN ABS. [x] EYES [x] INGESTION [ ] INHALATION
Eye and skin contact may cause irritation. Ingestion may cause adverse health effects.
EFFECTS OF ACUTE
Inhalation of mist or spray may cause irritation of the respiratory tract.
EXPOSURE
Not known
EFFECTS OF
CHRONIC EXPOSURE
Eye irritant
IRRITANCY SENSITIZATION SYNERGISTIC MATERIALS
Not known Not known
[ ] CARCINOGENICITY [ ] REPRODUCTIVE EFFECTS [ ] TERATOGENICITY [ ] MUTAGENICITY
Product not believed to cause any of these effects.
VIII - FIRST AID MEASURES
Thoroughly wash exposed areas with soap and water.
SKIN
Flush eyes thoroughly with plenty of lukewarm water for at least 20 minutes. Get medical attention.
EYES
Remove victim to fresh air. If breathing is difficult, administer oxygen.
INHALATION
Consult a physician immediately.
If victim is conscious, give two glasses of water and induce vomiting.
INGESTION
Obtain medical attention.
IX - PREVENTIVE MEASURES
Safety goggles to protect against splash.
EYES:
Rubber or plastic gloves.
PERSONAL GLOVES:
Overalls or apron, solvent resistant.
PROTECTIVE CLOTHING:
Approved respirator in confined areas or if exposed to vapours or mist.
EQUIPMENT RESPIRATORY:
Exhaust ventilation required in confined spaces.
ENGINEERING CONTROLS
(VENTILATION, ETC.)
Wet material: Dike liquid and pump to disposal containers. wash with water.
LEAK AND SPILL
Dry material: Scrape up into disposal containers. Wash off with low hazard solvents.
PROCEDURE
Waste to be disposed of by incineration, in approved landfill or waste disposal facility, in accordance with
WASTE
local, provincial, state and federal regulations.
DISPOSAL
Handle with reasonable care and caution.
HANDLING PROCEDURES
Storage temperature: 10-27掳C. Protect from freezing. Avoid temperatures above 40掳C.
STORAGE REQUIREMENTS
Protect from freezing if possible.
SHIPPING INFORMATION
While Henry Company Canada Inc. believes that the data contained herein are factual & opinionsexpressed are those of qualified experts regarding the results of the
tests conducted, the data is not to be taken as warranty or representation for which Henry Company Canada Inc. assumes legal responsibility. These are offered solely
for your consideration, investigation and verification. Any use of this data and information must be determined by the user to be in accordance with federal,
provincial or municipal laws and regulations.
|