EFT Holdings, Inc. MATERIAL SAFETY DATA SHEET EFFECTIVE DATE: January 22, 2007
CREATION DATE: 1/19/07 NAME OF FINISHED SOLUTION: Crystal Clean 200-3313 REVISION DATE:
TRADE NAMES/SYNONYMS: EasyDECON鈩? 200; Meth Decontamainant
EMERGENCY TELEPHONE NUMBER: 24 Hour Emergency Assistance: ChemTrec: 800-424-9300; 703-527-3887
MANUFACTURER鈥橲 NAME & ADDRESS: General MSDS Assistance: EnviroFoam Technologies 1012 Oster Drive, Suite A, Huntsville, Alabama 35816; (256) 489-9245
SECTION I: MATERIAL IDENTIFICATION
Name & Part Number of Individual Component Penetrator 5000 Fortifier 0300 Booster - 0010
SECTION II: COMPOSITION & INFORMATION ON INGREDIENTS
EXPOSURE LIMITS: COMPONENT/CAS#:/QUANTITY % Quaternary Ammonium Compounds, Liquid Hydrogen Peroxide; CAS: 7722-84-1 <8.0% Diacetin; CAS: 25395-31-7
Benzyl-C12-C16 Alkyl Di-methyl Chlorides: CAS : 68424-85-1 5.5- 30-60%
6.5%
OSHA PEL-ppm mg/m3, AGIH TLVppmmg/m3 1 - OSHA PEL-ppm , 1 - AGIH TLVppm 1 - OSHA PEL-ppm , 1 - AGIH TLVppm None Established
COMPONENT/CAS#:/QUANTITY % Quaternary Ammonium Compounds; N,N,N,N鈥?,N鈥? 鈥? Pentamethyl-N鈥? Tallow
Alkyl- trimethylenedi-, Chlorides; CAS: 68607-29-4 1.5-
2.5%
OSHA PEL-ppm mg/m3, AGIH TLVppmmg/m3 1 - OSHA PEL-ppm , 1 - AGIH TLVppm
INERT INGREDIENTS wt.%: Balance of formula Balance of formula
Balance of formula
SECTION III: PHYSICAL DATA
BOILING POINT: 200F 210F/100C 280F/138C
FREEZING POINT : 26F 32F/0C NA
SPECIFIC GRAVITY (H2O=1): 1.09 g/cc; 9.255 Lb/gal; (Finished Blend 1.075 g/cc, 8.971 Lb/gal) 1.028 g/cc; 8.579 Lb/gal 1.18 g/cc; 9.875Lb/gal
EVAPORATION RATE: NA >0.23 NA
SOLUBILITY IN WATER: Complete Complete Miscible
PH: 10.5-10.7; (Finished Blend, 9.6-9.9) 3.0-6.0 Neutral
APPEARANCE: clear, pale yellow liquid Colorless liquid Colorless liquid
ODOR: Sweet, soapy None Solvent odor
VAPOR PRESSURE (mmHg): 18 @ 68F <1 mm @ 20C
VAPOR DENSITY (air-1): 0.2
Haz Rate: Health, Fire, React, Personal Protection 1, 0, 0, B
SECTION IV: FIRE & EXPLOSION DATA
FIRE AND EXPLOSION HAZARDS: Low fire hazard. In a fire, overheated sealed containers may explode from Low fire hazard Emits carbon monoxide and dioxide
overpressure.
EXTINGUISHING MEDIA: All types for surrounding fuel sources Water, water fog, CO2, dry chemical Water, CO2, dry chemical, alcohol or polymer foam
FLASH POINT: NONE, by Cleveland open cup Non Flammable 141C (Open Cup), 146C COC
FIRE FIGHTING: Move container from fire area if it can be done without risk. Cool well after the Flood with water. If excessive smoke, or fumes are encountered, wear self-contained breathing
fire is out. Reduce vapors with water spray. Avoid inhalation of material or apparatus and protective clothing. Material decomposes at 250-280C.
combustion by-products. Stay upwind and keep out of low areas.
SECTION V: HEALTH HAZARD DATA
EYE: Contact with eyes may cause irritation; prolonged eye contact may cause Contact with eyes may cause severe irritation; prolonged eye contact may Material causes irritation.
permanent damage. cause permanent damage.
SKIN: Prolonged contact with skin may cause irritation Prolonged contact with skin may cause irritation or discoloration. Material causes skin irritation. May be harmful by skin absorption
INGESTION: Can cause damage to mucous membranes. Strong emetic, may cause If swallowed can cause damage to digestive tract. May be harmful by ingestion.
vomiting and nausea for 24hrs
INHALATION: No known effects. Aspiration of liquid into respiratory passages may cause May cause respiratory tract irritation May cause respiratory tract irritation
damage to mucous membranes.
CARCINOGENICITY: This product or (components of its mixture) is not listed in IARC Monograph, the NTF Sixth Annual Report or the current ACGIH TLV鈥檚 as a carcinogen or potential carcinogen.
EMERGENCY AND FIRST AID PROCEDURES:
EYE CONTACT: Immediately flush eyes with plenty of water for at least 15 minutes. Then get Immediately flush eyes with plenty of water for at least 15 minutes. Then get Immediately flush eyes with plenty of water for at least 15 minutes,
immediate medical attention. immediate medical attention. occasionally lifting the upper and lower eyelids. Then get immediate medical
attention.
SKIN CONTACT: Flush with cool running water. If irritation develops get medical attention. Flush with cool running water. If irritation develops get medical attention Immediately wash skin with soap and copious amounts of water while
removing contaminated clothing and shoes. Wash contaminated clothing
before reuse. If irritation develops get medical attention.
Name & Part Number of Individual Component Penetrator 5000 Fortifier 0300 Booster - 0010
INGESTION: If conscious, give plenty of water. DO NOT induce vomiting. DO NOT give If conscious, give 2-4 cups of water. DO NOT induce vomiting. (DO NOT give Wash mouth out with water. Get medical attention.
liquids by mouth to an unconscious patient. Get medical attention. liquids by mouth to an unconscious patient) Get medical attention.
BREATHING: Move to fresh air. If breathing becomes labored consider oxygen, get medical Move to fresh air. If breathing becomes labored consider oxygen, get medical Move to fresh air.
attention. Give rescue breathing if breathing stops, get medical attention. attention. Give rescue breathing if breathing stops, get medical attention.
SECTION VI: STABILITY AND REACTIVITY
STABILITY: Stable at normal temperatures and pressure. Decomposes slowly to release oxygen Stable up to 200C, then progressive charring.
REACTIVITY: Stable at normal temperatures and pressure Stable at normal temperatures and pressure. No Information
CONDITIONS TO AVOID: Minimize contact . Keep out of water supplies Heat, rust, dirt, organic materials
INCOMPATIBILITIES: Cyanide, hexavalent chromium compounds, nitric acid, potassium Strong oxidizing agents.
permanganate, strong reducing agents, other flammable materials, metals
HAZARDOUS DECOMPOSITION: Thermal decomposition products: oxides of carbon and nitrogen, Release of oxygen Release of oxides of carbon
POLYMERIZATION: Will not polymerize Will not polymerize Will not polymerize.
SECTION VII: SPILL & ACCIDENTAL RELEASE MEASURE
IN CASE OF RELEASED/SPILLED MATERIAL: Keep out of water supplies. Flood with water. Drain to a chemical sewer or For large quantities, flood with water and drain to a chemical sewer or Flood with water and drain to a chemical sewer or wastewater treatment plant.
wastewater treatment plant. wastewater treatment plant. For small quantities, flood with water. Material
decomposes rapidly when on the ground.
OCCUPATIONAL RELEASE: Stop leak without personal risk Do not touch spilled material. Stop leak if possible without personal risk. Do not touch spilled material. Stop leak if possible without personal risk.
SECTION VIII: EXPOSURE CONTROLS, PERSONAL
PROTECTION
VENTILATION: Provide local exhaust or process enclosure ventilation system. Provide local exhaust or process enclosure ventilation system. Ensure Provide local exhaust or process enclosure ventilation system
compliance with applicable exposure limits.
EYE PROTECTION: Wear splash resistant safety goggles. Provide an emergency eye wash Wear splash resistant safety goggles with a face shield. Provide an Wear splash resistant safety goggles with a face shield. Provide an
fountain. emergency eye wash fountain. emergency eye wash fountain.
CLOTHING: Wear appropriate chemical resistant clothing Wear appropriate chemical resistant clothing.
Wear appropriate chemical resistant clothing.
GLOVES: Wear appropriate chemical resistant gloves Wear appropriate chemical resistant gloves Wear appropriate chemical resistant gloves
RESPIRATOR: For prolonged use or exposure in unventilated structures, a NIOSH approved For prolonged use or exposure in unventilated structures, a NIOSH approved NIOSH/MSHA-approved respirator
respiratory protection may be needed. respiratory protection may be needed.
SECTION IX: ADDITIONAL INFORMATION &
PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store and handle in accordance with all current regulations and standards. CAUTION! May cause skin irritation. May cause respiratory and digestive tract Safety shower and bath. Use only in well ventilated area. Avoid inhalation.
OSHA 29 CFR 1910.106. See original container for storage irritation. May cause severe eye irritation and possible injury. Do not get in Avoid contact with eyes, skin, and clothing. Wash thoroughly after handling.
recommendations. Keep separated from incompatible substances eyes. Avoid contact with skin and clothing. Avoid contact with flammable or Irritant. Keep tightly closed. Store in a cool dry place. There are no ingredients
combustible materials. OTHER PRECAUTIONS: Contact with organic liquids or no ingredients of sufficient quantity in this product to require reporting under
or vapors may cause immediate fire and explosion, especially if heated or SARA or CERCLA statutes. TSCA: All components of this chemical are listed
may result in delayed detonation. Conduct all initial experiments on small on the TSCA inventory.
scale and protect personnel with adequate shielding, as reactions are
unpredictable, being affected by impurities, contaminants, etc.
SECTION X: D.O.T. SHIPPING AND STORAGE
INFORMATION
PROPER SHIPPING NAME: Not regulated Not regulated Chemical, n.o.s
HAZARD CLASS: NA NA NA
D.O.T. LABEL REQUIRED: None None None
PACKAGING GROUP: NA NA NA
UN/UA: NA NA NA
REPORTABLE QTY OF PRODUCT: NA NA NA
This information is given without any warranty or representation. It is believed to be correct but does not claim to be all-inclusive and shall be used only as a guide. EnviroFoam Technologies, Inc. shall not be held liable for any damage resulting from handling or contact with the above
product. It is offered solely for your consideration, investigation and verification.
|