______________________________________________________________________________
MATERIAL SAFETY DATA SHEET
__________________________ Page 1 of 4
Revised 2/02/04
DUJEL 1150 Replaces 12/11/03
Printed 2/03/04
MSDS ID: 11121
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
I. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Name: DuJEL 1150
Product Descriptor: ALKALINE CHLORINATED GEL CLEANER
MANUFACTURER: JOHNSONDIVERSEY, INC. EMERGENCY PHONE NUMBER:(800)851-7145
3630 E. KEMPER ROAD
CINCINNATI, OH. 45241
______________________________________________________________________________
______________________________________________________________________________
II. HAZARDOUS COMPONENTS
Component Name CAS Number % Exposure Limits Units
----------------------------- ----------- ---------- ---------------- -------
POTASSIUM HYDROXIDE 1310-58-3 1 - 5% TWA - C 2 MG/M3
SODIUM HYPOCHLORITE 7681-52-9 1 - 5% None established
______________________________________________________________________________
______________________________________________________________________________
III. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW:
CORROSIVE - Contains alkalis and chlorinated chemicals. Causes severe burn to
skin and eyes. May be fatal if swallowed. Do not contact eyes, skin or
clothing. Wear goggles, face shield, rubber gloves, and protective clothing
and boots when handling products. Avoid breathing dust or spray mist. Use
respiratory protection for any breathing difficulty. TOXIC CHLORINE VAPORS
may be released by fire or mixing with acids or ammonia. Contain spill and
runoff, which may cause environmental damage.
POSSIBLE ROUTES OF ENTRY: Inhalation and ingestion.
SIGNS AND SYMPTOMS OF OVEREXPOSURE
ACUTE: EYES: Corrosive. May cause permanent damage including blindness.
SKIN: Corrosive. May cause permanent damage. INGESTION:
Corrosive. May cause burns to mouth, throat and stomach.
INHALATION: May cause irritation and corrosive effects to nose,
throat and respiratory tract.
CHRONIC: Same as acute effects.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: Individuals with chronic
respiratory disorders such as asthma, chronic bronchitis or empheysema, etc.,
may be more susceptible to irritating effects. Persons with pre-existing
skin disorders may be more susceptible to irritating effects.
TARGET ORGAN(S) OF CHEMICAL HAZARD(S): Eyes, skin, respiratory tract, and
gastrointestinal tract.
______________________________________________________________________________
______________________________________________________________________________
IV. FIRST AID MEASURES
EYES: Immediately flush eyes with running water for at least 15 minutes
keeping eyelids open. Get medical attention immediately.
SKIN: Flush immediately with plenty of water for at least 15 minutes.
Get medical attention immediately.
INGESTION: Do not induce vomiting. Immediately drink one cupful of water or
Industrial
______________________________________________________________________________
MATERIAL SAFETY DATA SHEET
__________________________ Page 2 of 4
Revised 2/02/04
DUJEL 1150 Replaces 12/11/03
Printed 2/03/04
MSDS ID: 11121
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
IV. FIRST AID MEASURES (Cont.)
milk. Never give anything by mouth to an unconscious person. Get
medical attention immediately.
INHALATION: If breathing is affected, remove to fresh air. Get medical
attention immediately.
______________________________________________________________________________
______________________________________________________________________________
V. FIRE FIGHTING MEASURES
FLASH POINT (degrees F): >212F FLAME EXTENSION: N/A
FLAMMABLE LIMITS IN AIR BY VOLUME: LEL: N/E UEL: N/E
UNUSUAL FIRE OR EXPLOSIVE HAZARDS: Burning or decomposition may form hydrogen
chloride or other toxic gasses. Liquid produces hydrogen on contact with
soft, active metals.
EXTINGUISHING MEDIA: Water spray, CO2, foam or dry powder.
FIRE FIGHTING INSTRUCTIONS: Wear full protective gear and positive pressure
breathing apparatus SCBA) in fire area.
SPECIAL INSTRUCTIONS: Spilled product may cause slippery surface and fall
hazard.
______________________________________________________________________________
______________________________________________________________________________
VI. ACCIDENTAL RELEASE MEASURES
IF MATERIAL IS RELEASED OR SPILLED:
Contain spill. Wear protective clothing. Soak up or absorb liquid on
suitable absorbent material. Collect and place in chemical waste container.
Dispose of in accordance with local, State and Federal regulations. Flush
spill area with water.
The Reportable Quantity (RQ) of Sodium Hypochlorite, CAS #7681-52-9 is 251
gallons or 2210 lbs.
______________________________________________________________________________
______________________________________________________________________________
VII. HANDLING AND STORAGE
HANDLING AND STORAGE PRECAUTIONS: CHLORINATED PRODUCT. Do not mix or store
with acids or ammonia containing chemicals. Toxic chlorinated gasses may be
released. Keep container closed when not in use. Wear protective gear when
handling or using product. Protect from high temperatures.
______________________________________________________________________________
______________________________________________________________________________
VIII. EXPOSURE CONTROLS/PERSONAL PROTECTION
EYE/FACE PROTECTION: Chemical goggles if contact or splash hazard exists.
Face shields.
PROTECTIVE GLOVES: Alkali resistant.
RESPIRATORY PROTECTION: Product does not have any established exposure limits.
NIOSH/MSHA approved respirator recommended in enclosed or confined spaces
where high air concentration or long exposure may occur.
OTHER PROTECTIVE CLOTHING/EQUIPMENT: Rubber boots and chemical resistant apron
if contact or splash hazard exists. Eyewash and safety shower in area if
contact or splash hazard exists.
ENGINEERING CONTROLS:
VENTILATION: Good general ventilation should be sufficient to control airborne
levels.
Industrial
______________________________________________________________________________
MATERIAL SAFETY DATA SHEET
__________________________ Page 3 of 4
Revised 2/02/04
DUJEL 1150 Replaces 12/11/03
Printed 2/03/04
MSDS ID: 11121
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
IX. PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE AND ODOR: Viscous, light yellow liquid with chlorine odor
BOILING POINT (DEG F): >200F FREEZING POINT: 32F
SPECIFIC GRAVITY/BULK DENSITY: 1.07
pH: 13.5 pH 1% SOLUTION: 12.5%
VOLATILE BY VOLUME: 89.4%
SOLUBILITY IN WATER: Soluble
VAPOR PRESSURE(mmHg): 17.3 at 20C VAPOR DENSITY: 17.3
______________________________________________________________________________
______________________________________________________________________________
X. STABILITY AND REACTIVITY
CHEMICAL STABILITY: Product stable.
INCOMPATIBILITY WITH OTHER MATERIALS: Acids; Ammonia
HAZARDOUS DECOMPOSITION PRODUCTS: Incomplete combustion forms; hydrogen
chloride, chlorine and chlorinated compounds; oxides of carbon; oxides of
sulfur
HAZARDOUS POLYMERIZATION: None known.
______________________________________________________________________________
______________________________________________________________________________
XI. TOXICOLOGICAL INFORMATION
TOXICOLOGICAL TESTING: Toxicological testing has not been performed on the
product. Listed below is the available toxicology test
data for components of the product.
TOXICITY TEST DATA:
Potassium Hydroxide :
Acute Oral LD50 (rat) - 365 mg/kg (RTECS)
Acute Skin LD50 (rabbit) - 1260 mg/kg (MSI)
Sodium Hypochlorite:
Acute Oral LD50 (rat) - 2840 mg/kg (PTI)
______________________________________________________________________________
______________________________________________________________________________
XII. ECOLOGICAL INFORMATION
Toxicological testing has not been performed on the product. Listed below is
the available toxicology test data for components of the product.
ECOTOXICITY TEST DATA:
Potassium Hydroxide:
Acute LC50 (96 hr.) (Pimephles promelas) - 179 mg/l
Acute LC50 (96 hr.) (Daphnia magna) - 60 mg/l
ENVIRONMENTAL FATE: No data available.
______________________________________________________________________________
______________________________________________________________________________
XIII. DISPOSAL CONSIDERATIONS
RCRA REGULATED: Product is considered to be D002 - Corrosive if declared
hazardous waste.
Spent or excess product is hazardous waste. Do not discharge to sewer or
environment. Arrange disposal through a licensed disposal company or treat by
special Waste Disposal Sheet. Recycle or dispose of containers by product
labeling or governmental regulations.
Industrial
______________________________________________________________________________
MATERIAL SAFETY DATA SHEET
__________________________ Page 4 of 4
Revised 2/02/04
DUJEL 1150 Replaces 12/11/03
Printed 2/03/04
MSDS ID: 11121
______________________________________________________________________________
______________________________________________________________________________
______________________________________________________________________________
XIV. TRANSPORT INFORMATION
Please refer to the Bill of Lading/receiving documents for up to date shipping
information.
______________________________________________________________________________
______________________________________________________________________________
XV. REGULATORY INFORMATION
U.S. Federal Regulations:
TSCA: All ingredients in this product are on TSCA inventory.
HAPS: None
VOC CONTENT (EPA Method 24A): % VOC: 0 Lb/Gal VOC: 0
CERCLA/EPCRA:
Section 313 Toxic Chemicals:
NONE
SARA Section 311/312:
ACUTE:YES CHRONIC:NO FIRE:NO REACTIVITY:NO
SUDDEN RELEASE OF PRESSURE:NO
LISTED CARCINOGEN: None
NTP: NO IARC: No OSHA: NO
HMIS RATINGS: HEALTH: 3 FIRE: 0 REACTIVITY: 0
PERSONAL PROTECTIVE EQUIPMENT: D
NFPA RATING: HEALTH: 3 FIRE: 0 REACTIVITY:0 SPECIAL:ALKALI
STATE RIGHT-TO-KNOW INFORMATION:
SODIUM HYPOCHLORITE - CAS #7681-52-9
POTASSIUM HYDROXIDE - CAS #1310-58-3
TRADE SECRET - NJ-TSRN-DL-00001
TRADE SECRET - NJ-TSRN-DL-00024
TRADE SECRET - NJ-TSRN-DL-0059
CALIFORNIA PROPOSITION 65:
None of the ingredients are on the California proposition 65 list.
______________________________________________________________________________
______________________________________________________________________________
XVI. OTHER INFORMATION
Disclaimer: The information contained in this material safety data sheet is
based on the knowledge of this specific product and current national legisla-
tion. It applies to the product as sold, use dilutions may be less hazardous.
It may not be valid for this material if used in combination with any other
materials or in a process. It is the user's responsibility to evaluate the
handling, and use.
Industrial
|