E04
DILUTION: 1:64
2 OUNCES PER GALLON OF WATER (660 ppm quat)
A multi-purpose, neutral pH, germicidal detergent and deodorant effective in hard water up to 400 ppm (calculated as CaCO3) in the presence of a moderate amount of soil (5% organic serum) according
to the AOAC Use-dilution Test. Disinfects, cleans and deodorizes in one labor-saving step.
Recommended for use in hospitals, nursing homes, schools, colleges, commercial and industrial institutions, office buildings, veterinary clinics, animal life science laboratories, zoos, pet shops, airports,
kennels, hotels, motels, breeding establishments, grooming establishments and households.
Disinfects, cleans, and deodorizes the following hard, nonporous, inanimate surfaces: floors, walls, (non-medical) metal surfaces, (non-medical) stainless steel surfaces, glazed porcelain, plastic
surfaces (such as polypropylene, polystyrene, etc.).
DIRECTIONS FOR USE
It is a violation of Federal law to use this product in a manner inconsistent with its labeling.
This product is not for use on medical device surfaces.
DISINFECTION / CLEANING / DEODORIZING DIRECTIONS: Remove heavy soil deposits from surface, then thoroughly wet surface with a use-solution of 2 ounces of the concentrate per gallon of
water. The use-solution can be applied with a cloth, mop, sponge, or coarse spray or by soaking. For sprayer applications, use a coarse spray device. Spray 6-8 inches from the surface, rub with a
brush, cloth or sponge. Do not breathe spray. Let solution remain on surface for a minimum of 10 minutes. Rinse or allow to air dry. Rinsing of floors is not necessary unless they are to be waxed or
polished.
Food contact surfaces must be thoroughly rinsed with potable water. This product must not be used to clean the following food contact surfaces: utensils, glassware and dishes.
BACTERICIDAL STABILITY OF USE-DILUTION: Tests confirm that this product, when diluted in 400 ppm hard water, remains effective against Pseudomonas aeruginosa, Staphylococcus aureus and
Salmonella choleraesuis for up to 3 months when stored in a sealed container such as a spray bottle. If product becomes visibly dirty or contaminated, the use-dilution must be discarded and fresh
product prepared. Always use clean, properly labeled containers when diluting this product. Bactericidal stability of the use-dilution does not apply to open containers such as buckets or pails.
TOILET BOWLS: Swab bowl with brush to remove heavy soil prior to cleaning or disinfecting. Clean by applying solution around the bowl and up under the rim. Stubborn stains may require brushing.
To disinfect, first preclean to remove heavy soil, then remove or expel over the inner trap the residual bowl water. Pour in three ounces of the diluted solution. Swab the bowl completely using a scrub
brush or mop, making sure to get under rim. Let stand for 10 minutes or overnight, then flush.
FUNGICIDAL DIRECTIONS:
For use in areas such as locker rooms, dressing rooms, shower and bath areas and exercise facilities follow disinfection directions.
MILDEWSTATIC INSTRUCTIONS: Will effectively control the growth of mold and mildew, plus the odors caused by them when applied to hard, nonporous surfaces such as walls, floors and table
tops. Apply use-solution of 2 ounces per gallon of water with a cloth, mop, sponge or coarse spray. Make sure to wet all surfaces completely. Let air dry. Repeat application weekly or when growth
reappears.
*KILLS HIV-1 (AIDS VIRUS) AND HBV (HEPATITIS B VIRUS) AND HCV (HEPATITIS C VIRUS) ON PRECLEANED, ENVIRONMENTAL SURFACES / OBjECTS PREVIOUSLY SOILED WITH
BLOOD / BODY FLUIDS in health care settings or other settings in which there is an expected likelihood of soiling of inanimate surfaces/objects with blood / body fluids, and in which the surfaces /
objects likely to be soiled with blood / body fluids can be associated with the potential for transmission of Human Immunodeficiency Virus Type I (HIV-1) (associated with AIDS) or Hepatitis B Virus
(HBV) or Hepatitis C Virus (HCV).
PRODUCT SPECIFICATIONS
Dilution: 2 oz./gal. (1:64)
Color: Yellow
Detergency: Excellent
Odor: Lemon
Rinsability: Excellent
pH: 7.2 - 8.2
Hard Water Tolerance: 400 ppm
Base: Quaternary ammonium
Biodegradability: Complete
chloride
Storage/Stability: 1 year
Viscosity: Water thin
Weight per Gallon: 8.336 lbs./gal.
Foam: Moderate
Freeze / Thaw Stability: Keep from freezing
Abrasives: None
Solubility: Complete with water
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
EO4 MATERIAL SAFETY DATA SHEET N/A= Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 2/04 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Product Name: Disinfectant Cleaner
Manufacturer鈥檚 Name: Supplier鈥檚 Name:
Misco Products Corporation Generic Name: Neutral Disinfectant & Detergent
Chemical Family: Quaternary Detergent Blend
Manufacturer鈥檚 Address: Supplier鈥檚 Address:
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer鈥檚 Phone #: (610) 926-4106 EPA Reg. No. 47371-131-8325 Supplier鈥檚 Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
Dimethyl Benzyl Ammonium Chloride 8001-54-5 1.69
Didecyl Dimethyl Ammonium Chloride 7173-51-5 2.54
Octyl Dimethyl Amine Oxide 2605-78-9 0 to 5
Trisodium Salt of EDTA 150-38-9 0 to 5
Perfume Oil N/A 0 to 5
Dye N/A 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): None
Boiling Point ( F): 210 F. Specific Gravity: 1.00
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: N/A
% Volatile: 85+ pH: 7.2-8.2
Special Firefighting Procedures: Non Flammable
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Unusual Fire and Explosion Hazards: N/A
Physical Description: Thin yellow liquid with characteristic odor.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Thermal decomposition may produce toxic Incompatibility (Materials to Avoid): Strong oxidizing or reducing agents
vapors/fumes of hydrogen chloride, amines, and oxides of carbon and nitrogen.
SECTION 6-STORAGE AND HANDLING INFORMATION
Severe eye irritant. Skin irritant. Avoid contact with eyes, skin and clothing. Wear protective gloves and eyewear when handling concentrate. Keep out of reach of
children. For use by trained personnel only. Keep container closed during storage. For institutional and industrial use only. EPA registered product, follow direction
exactly. Use in well ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Respiratory Protection: No special requirements.
Effects of Overexposure:
Skin: Skin irritant. Prolonged or repeated contact may cause dermatitis. Ventilation Requirements: General ventilation acceptable.
Eyes: Severe eye irritant. Liquid and mists may injure the eyes, causing corneal Protective Gloves: Chemical resistant rubber or neoprene.
damage. Eye Protection: Safety glasses or chemical splash goggles.
Inhalation: Inhalation of mists will cause respiratory irritation marked by Other Protective Equipment: Eyewash station should be provided nearby. Wear
coughing, sneezing, burning sensation of nose and throat. protective rubber footwear when using on floors.
Ingestion: May be irritating to the mouth, throat, and gastrointestinal system.
Burning, pain, and diarrhea expected with large doses.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Remove contaminated clothing. Flush affected areas with large quantities of Steps to be taken in Case Material is Released or Spilled: Floors will become
water. Seek medical attention if irritation persists. slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
attention. Waste Disposal Method: EPA registered pesticide. Any method in accordance
Inhalation: Remove victim to fresh air. Seek medical attention if irritation persists with local, state and federal laws governing such. Best method is to recycle or
Ingestion: Give large quantities of milk and water. Do not induce vomiting. Seek reuse for intended purpose. Consult local authorities for disposal in public sewer.
medical attention immediately. Do not dispose of into storm drain, stream, river or to ground. Triple rinse
Note to Physician: Probable mucosal damage may contraindicate the use of gastric container thoroughly before discarding in trash.
lavage. Supplemental oxygen and other measures to support breathing may be
needed to combat circulatory shock.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
No - Fire Hazard FOR CONTAINERS > 1 Gallon : Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Non Hazardous Health 3
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Cleaning Compound Flammability 0
Yes - Immediate (acute) Health Hazard Non Hazardous Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound Personal Protection D
Non Hazardous
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the
improper handling and use of this product
|