Water & Oil Stain Repellant
For Use On:
Grout
Cement
Stone
Terra Cotta
Brick
Unglazed Tile
Concrete
DESCRIPTION
Ready-to-use water based penetrating sealer for use on porous mineral surfaces.
It provides a transparent subsurface barrier to give water and oil repellency. It
makes the surface stain resistant, allowing easy clean up of most spills. It is
non-yellowing for long lasting interior/exterior applications. This sealer provides
durable protection without leaving a visible film, allowing the natural beauty of
the stone to show.
DIRECTIONS
Clean surface with brush or broom to remove all loose dirt and debris. If dirt
remains scrub area with solution of MISCO Super Blue. Remove cleaning solu-
tion with a wet vacuum, rinse thoroughly with clean water. Allow surface to dry
completely before sealing.
Sealer can be applied with paintbrush, pad, roller or mop. Low-pressure pump-up
garden sprayers can also be used for large areas. Apply at coverage of 150 鈥? 1000
sq ft/gal. Generously wet the surface, but do not allow puddles to form. Coverage
will depend on the porosity of the stone. Highly porous surfaces such as cement
or concrete will require two coats. If a second coat is necessary, apply after first
coat has dried for 15 鈥?30 minutes.
Clean up all equipment with detergent and water, immediately after application.
Allow 4 hour to dry before opening area to light traffic. Maximum performance will
be reached in 48-72 hours.
PRODUCT SPECIFICATIONS
Color: Clear light amber Detergent Resistance: Excellent
Odor: Mild characteristic VOC Content: < 75 grams/liter
pH: 8.0 鈥? 9.0 Storage/Stability: 2 years
Flash Point (TCC): 144 0F Weight Per Gallon: 8.31 lbs./gal.
Dry/Recoat Time: 15-30 minutes min. Freeze/Thaw Stability: Keep from freezing
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
IPG MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Effective Date: 1/06 Revision: n/a
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer聮s Name: Product Name: Impregnator H2O Supplier聮s Name:
Misco Products Corporation Generic Name: Water and Oil Stain Repellent
Manufacturer聮s Address: Supplier聮s Address:
Chemical Family: Fluorochemical Dispersions
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer聮s Phone #: (610) 926-4106 Supplier聮s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 70 to 100
Aqueous Fluorochemical Solution Trade Secret 0 to 10
Fluoropolymer Dispersion Trade Secret 0 to 10
2-Butoxyethanol 111-76-2 0 to 5
Isopropanol 67-63-0 0 to 5
SECTION 4-FIRE AND EXPLOSION HAZARD DATA
SECTION 3-PHYSICAL DATA
Flash Point (Method Used): 144掳 F. (TCC)
Specific Gravity: 0.95 聳 1.05
Boiling Point (锟紽): 212掳 F.
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1 Upper Explosion Limit: 6.0 Lower Explosion Limit: 1.0
% Volatile: 90+ pH: 8.0 聳 9.0 Extinguishing Media: Water mist, Foam, CO2, or Dry Chemical
Solubility in Water: Complete Evaporation Rate (Water=1): <1 Special Firefighting Procedures: None
Physical Description: Thin clear light amber liquid with mild characteristic odor. Unusual Fire and Explosion Hazards: Drums heated by fire can explode.
VOC Content (Subpart D 搂59.406) : <75 gm/liter
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Will not occur Incompatibility (Materials to Avoid): None
SECTION 6-STORAGE AND HANDLING INFORMATION
Eye and Skin irritant. Avoid contact with eyes, skin and clothing. Avoid breathing of mists. Avoid circumstances that produce respirable particles (fine spray mists). Use in well-
ventilated area only. Wash hands thoroughly after use. Keep out of reach of children. For use by trained personnel only. Keep unauthorized personnel away when applying to floor.
Keep container closed during storage. For institutional and industrial use only.
SECTION 8-SPECIAL PROTECTION INFORMATION
SECTION 7-HEALTH HAZARDS AND FIRST AID
Respiratory Protection: Organic vapor canister respirator when in confined areas.
Effects of Overexposure:
Skin: Prolonged or repeated contact may cause moderate irritation including dermatitis. Ventilation Requirements: Provide adequate local where danger of mist contact will
Eyes: Eye irritant. May cause redness, tearing, burning sensation. occur.
Inhalation: Vapors may be irritating to nose, throat, and lungs. May cause dizziness, Protective Gloves: Chemical resistant rubber.
headache, and nausea. Excessive breathing of mists may cause serious injury to lungs. Eye Protection: Chemical splash goggles where danger of mist contact.
Ingestion: May be irritating to the mouth, throat, and gastrointestinal system. Vomiting Other Protective Equipment: Eyewash should be available. Protective footwear (e.g.
and diarrhea expected with large doses. rubber boots) and protective pants when applying to floors.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists. Steps to be taken in Case Material is Released or Spilled: Floors will become
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical attention. slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
Inhalation: Immediately remove victim to fresh air and monitor. Seek medical attention
Waste Disposal Method: Any method in accordance with local, state and federal laws.
if signs of irritation or difficulty breathing is observed.
Best method is to recycle or reuse for intended purpose. Consult local authorities for
Ingestion: Do not induce vomiting. Dilute with 2 glasses of water. Seek medical
disposal in public sewer. Do not dispose of into storm drain, stream, river or to ground.
attention if symptoms persist.
Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Domestic Shipping Information: HMIS Hazardous Materials
Identification System
No - Fire Hazard FOR CONTAINERS > 1 Gallon : Not Regulated
Health 2
No - Sudden Release of Pressure Hazard
Flammability 0
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Not Regulated
Reactivity 0
Yes - Immediate (acute) Health Hazard
Personal Protection B
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Not Regulated
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and
of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
|