Food Service Products
Force
Non-Acid For Use On:
Drain Opener Hair Greases Vegetable Oils
Animal Fat Organic Matter
Starches
DESCRIPTION
A non-acid drain opener that is non-fuming and safe for use
on all plumbing fixtures, septic tanks, garbage disposals, and
porcelain. Pours through standing water, so clogged drains do
not have to be emptied first. Will dissolve starches, fats, oils,
greases, hair, vegetable gums and other organic wastes.
DIRECTIONS
Open carefully. Slowly pour directly into drain opening.
Avoid all splashing. If spilled, clean up immediately. Keep off
aluminum, plastic, and floors.
FOR CLOGGED DRAINS: No need to remove standing water.
Use 1/2 bottle and allow to work for 30 minutes. If necessary,
repeat operation and allow to work for 1 hour. Flush with
warm water.
FOR SLOW DRAINS: Use 1/4 bottle twice at 15 minute
intervals, flush with warm water.
FOR PREVENTING FUTURE PROBLEMS: Use 1/4 bottle
weekly. Allow to stand 30 minutes. Flush with water.
PRODUCT SPECIFICATIONS
13.0 卤 0.5%
Active Ingredients: Acid Content: None
Color: Clear Fumes: None
Odor: Not objectionable Emulsification: Excellent
Base: Potassium hydroxide Flash Point: None (waterbased)
pH: 13.5 - 14.0 Biodegradability: Complete
Viscosity: Water thin Storage/Stability: 2 years
Foam: None Weight per Gallon: 11.68 lbs./gal.
Abrasives: None Freeze / Thaw Stability: Keep from freezing
Phosphate Content: None
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
FOR MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 5/99 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer's Name: Product Name: Force
Misco Products Corporation Generic Name: Non-Acid Drain Opener
Manufacturer's Address: Chemical Family: Alkaline Detergent Blend
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer's Phone #: (610) 926-4106
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
3
Potassium Hydroxide 1310-58-3 10 to 15 N/A C2mg/M N/A
Sodium Hypochlorite 7681-52-9 0 to 5
Anionic Surfactant N/A 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): N/A
Boiling Point (掳F): 211 F. Specific Gravity: 1.40
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: N/A
% Volatile: 75+ pH: 13.5-14.0
Special Firefighting Procedures: Non Flammable
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Unusual Fire and Explosion Hazards: N/A
Physical Description: Thin clear liquid with characteristic odor.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids. Aluminum contact may release
hydrogen gases
SECTION 6-STORAGE AND HANDLING INFORMATION
CORROSIVE. Avoid contact with eyes, skin and clothing. Wear rubber gloves and eye protection when handling. Wash hands immediately after use. Keep out of reach of children.
For use by trained personnel only. Keep container tightly closed during storage. For institutional and industrial use only. Avoid breathing of vapors. Use in well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: Use in well-ventilated area.
Skin: Severe skin irritant. May cause moderate reddening, swelling, and possible skin Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-
damage. gredients below acceptable limit.
Eyes: Severe eye irritant. Liquid and mists may damage eyes, causing corneal damage. Protective Gloves: Chemical resistant rubber, alkaline resistant.
Inhalation: Vapors and mists may be irritating to mucous membranes in the nose, Eye Protection: Safety glasses or full-face shield recommended.
throat, and lungs. Other Protective Equipment: Eye wash. Protective clothing should be worn when
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache, nausea, handling.
abdominal pain, vomiting, and diarrhea. Excessive amounts may cause collapse.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists. Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical attention
otherwise absorb and hold disposal. For large spills, avoid discharge to sewer or open
if irritation persists.
waterways.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Waste Disposal Method: Any method in accordance with local, state and federal laws.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
Best method is to recycle or reuse for intended purpose. If discarded, this material and
attention immediately.
containers should be treated as hazardous waste based on the characteristic of
corrosivity as defined under federal RCRA regulations (40 CFR 261). Consult local
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
river or to ground. Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid, Identification System
No - Sudden Release of Pressure Hazard (Potassium Hydroxide), 8, NA-1760, PG III Health 3
Yes - Reactivity Hazard FOR 1 GALLON CONTAINERS: Compounds, cleaning liquid, Flammability 0
Yes - Immediate (acute) Health Hazard (Potassium Hydroxide), 8, NA-1760, PG III (Limited Quantity) Reactivity 1
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : ORM-D Personal Protection D
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and
of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
|