Food Service Products
Lift Away
Oven & Grill For Use On:
Cleaner Fryers Stove Burners
Ovens
Fry Pans Accessories
Grills
DESCRIPTION
A slight viscous, ready-to-use oven & grill cleaner for easy removal
of grease, carbon deposits and baked-on foods from ovens, grills,
hoods, and drip pans. Thickened formula clings to surfaces. Designed
to be sprayed or brushed on surface for rapid, easy cleaning. Works
best on warm surfaces. Dissolves deposits quickly for easy removal
by wiping or rinsing.
DIRECTIONS
FAST CLEANING FOR OVENS: Preheat oven to approximately 200藲
F, then turn off. Wear long rubber gloves. Liberally spread newspaper
under oven door to protect 铿俹or. Spray or brush full strength solution
onto surface to be cleaned. Allow to soak for several minutes, then
rinse with potable water using a cloth or sponge. Steel wool pads
may be necessary for stubborn areas.
FOR GRILLS: Warm grill to approximately 150藲F. Dilute concentrate
with equal parts water and pour on surface to be cleaned. Agitate with
a scraper or aggressive pad. Rinse with potable water using a sponge
or cloth. Do not use on grill exterior, interior or components.
This product meets the maximum content requirements for Volatile
Organic Compounds (VOCs) as established by state and Federal
regulations.
PRODUCT SPECIFICATIONS
Active Ingredients: 7 + 0.5%Min. Solubility: Complete with water
Color: Clear Rinsability: Complete with water
Odor: Characteristic Flash Point: None
pH: 13 - 14 Storage/Stability: One year
Viscosity: Slight Viscous Weight Per Gallon: 8.54 lbs. per gallon
Foam: High
LFT MATERIAL SAFETY DATA SHEET N/A= Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 1/02 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer s Name: Product Name: Lift Off Supplier s Name:
Misco Products Corporation Generic Name: Oven & Grill Cleaner
Manufacturer s Address: Supplier s Address:
Chemical Family: Alkaline Detergent Blend
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer s Phone #: (610) 926-4106 Supplier s Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
3
Potassium Hydroxide 1310-58-3 0 to 5 N/A C2mg/M N/A
Alkyl Aryl Alkoxy Phosphate Ester 52623-95-7 0 to 5
2-Butoxythanol 111-76-2 0 to 5 25 ppm 25 ppm N/A
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): N/A
Boiling Point (掳F): 212 F. Specific Gravity: 1.023
掳
Upper Explosion Limit: N/A Lo wer Explosion Limit: N/A
Vapor Pressure: <20mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: N/A
% Volatile: 80+ pH: 13.0-14.0
Special Firefighting Procedures: Non Flammable
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Unusual Fire and Explosion Hazards: N/A
Physical Description: Clear liquid with characteristic odor.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids.
SECTION 6-STORAGE AND HANDLING INFORMATION
Corrosive. Severe eye and/or skin irritant. Avoid contact with eyes, skin and clothing. Wear rubber gloves and eye protection when handling. Avoid breathing of vapors or mists.
Use in well-ventilated area. Keep out of reach of children. For use by trained personnel only. Keep container closed during storage. For institutional and industrial use only.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: Use in well-ventilated area.
Skin: Severe skin irritant. May cause moderate reddening, swelling, and possible skin Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-
damage. gredients below acceptable limit.
Eyes: Severe eye irritant. Liquid and mists may damage eyes, causing corneal damage. Protective Gloves: Chemical resistant rubber.
Inhalation: Vapors and mists may be irritating to mucous membranes in the nose, Eye Protection: Safety glasses or chemical splash goggles.
throat, and lungs. Other Protective Equipment: Eyewash should be nearby in case of contact. Protective
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache, outerwear should be worn when danger of splash may occur.
nausea, abdominal pain, vomiting, and diarrhea. Excessive amounts may cause
collapse.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists. Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical attention
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
if irritation persists.
Waste Disposal Method: Any method in accordance with local, state and federal laws.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Best method is to recycle or reuse for intended purpose. If discarded, this material and
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
containers should be treated as hazardous waste based on the characteristic of
attention immediately.
corrosivity as defined under federal RCRA regulations (40 CFR 261). Consult local
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
river or to ground. Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid, Identification System
No - Sudden Release of Pressure Hazard (Potassium Hydroxide), 8, NA-1760, PG III Health 3
No - Reactivity Hazard FOR 1 GALLON CONTAINERS: Compounds, cleaning liquid, Flammability 0
Yes - Immediate (acute) Health Hazard (Potassium Hydroxide), 8, NA-1760, PG III (Limited Quantity) Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : ORM-D Personal Protection D
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986
and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using
the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this
product
|