Food Service Products
Lime-Off
Non-Foaming For Use On:
Descaler Sinks
Stainless Coffee Urns
Utensils
Steel Glasses
Dishes
Ceramics Yogurt
Fixtures Machines
DESCRIPTION
A multi-purpose, non-foaming acid cleaner which removes mineral
deposits and other difficult acid susceptible soils. This product removes
lime, food film, and scale from stainless steel, aluminum, ceramic, and
plastics. For use in food service areas, dairies, washrooms, shower
rooms, laboratories, veterinary areas, and general housekeeping.
Excellent for use on dishwashers, coffee urns, steamtables, and other
food service equipment.
DIRECTIONS
鈥擳o remove light or medium build up in dishwashers, fill tank 3/4 full,
add one gallon of this product to tank, turn on and circulate until lime
disappears.
鈥擣or glassware, use 1/2 ounce per gallon of water and soak glasses
until clear of lime build up, rinse thoroughly.
鈥擳o clean yogurt machines and coffee urns, use 3 ounces of product per
2 gallons of hot water. Swab down interior, drain and flush thoroughly.
鈥擮n steamtables, brush or spray full strength. Let stand for 5 minutes,
fill with hot water. Brush steamtable thoroughly, drain and rinse with
clean water.
PRODUCT SPECIFICATIONS
40.0 卤 0.5%
Active Ingredients: Sequestration: Excellent
Color: Light pink Detergency: Excellent
Odor: Mild Rinsability: Excellent
Base: Sequestering acids Fumes: None
pH: 1.0 - 1.5 Flash Point: None (waterbased)
Viscosity: Water thin Biodegradability: Complete
Foam: Low Storage/Stability: 2 years
Abrasives: None Weight per Gallon: 11.67 lbs./gal.
Solubility: Complete with water Freeze / Thaw Stability: Keep from freezing
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
LIM MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 5/99 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Product Name: Lime Off
Manufacturer's Name:
Misco Products Corporation Generic Name: Non-Foaming Descaler
Manufacturer's Address: Chemical Family: Acid Detergent Blend
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer's Phone #: (610) 926-4106
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
1mg/M3 1mg/M3 3mg/M3
Phosphoric Acid 7664-38-2 35 to 40
Nonionic Surfactant 9016-45-9 0 to 5
Dye N/A 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): N/A
Boiling Point (掳F): 210 F. Specific Gravity: 1.401
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Vapor Pressure: <20mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: N/A
% Volatile: 60+ pH: 1.0-1.5
Special Firefighting Procedures: Non Flammable
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Unusual Fire and Explosion Hazards: N/A
Physical Description: Thin pink liquid with characteristic odor.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Phosphoric oxide vapors in a fire. Hydrogen Incompatibility (Materials to Avoid): Strong alkalis and oxidizers. Avoid
gas evolved when in contact with aluminum. contact with aluminum, brass, soft metals.
SECTION 6-STORAGE AND HANDLING INFORMATION
Corrosive. Keep out of reach of children. For use by trained personnel only. Keep container closed during storage. For institutional and industrial use only. Avoid
contact with eyes, skin and clothing. Wear rubber gloves and protective eyewear when handling. Wash hands after use. Avoid breathing of vapors. Use in well-
ventilated area. Avoid contact with aluminum. Do not mix with any other chemicals or cleaners
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: Use in well-ventilated area.
Skin: Severe skin irritant. Prolonged or repeated contact can cause chemical burns Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-
or dermatitis. gredients below acceptable limit.
Eyes: Severe eye irritant. Liquid and mists may burn or injure eyes, causing Protective Gloves: Acid proof rubber or viton.
corneal damage. Eye Protection: Safety glasses or chemical splash goggles.
Inhalation: May be irritating to mucous membranes of the nose, throat, and lungs. Other Protective Equipment: Eyewash station, chemical resistant apron and
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache, boots.
nausea, abdominal pain, vomiting and diarrhea. Excessive amounts may cause
collapse.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush exposed area with large quantities of water. Seek medical attention if Steps to be taken in Case Material is Released or Spilled: Floors will become
irritation persists. slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
attention immediately. Waste Disposal Method: Any method in accordance with local, state and federal
laws. Best method is to recycle or reuse for intended purpose. Consult local
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
river or to ground. Rinse container thoroughly before discarding in trash.
attention immediately.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid Identification System
No - Sudden Release of Pressure Hazard (phosphoric acid), 8, NA-1760, PGIII Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS: Compounds, cleaning liquid Flammability 0
Yes - Immediate (acute) Health Hazard (phosphoric acid), 8, NA-1760, PGIII (Limited Quantity) Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON: ORM-D Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
7664-38-2 Phosphoric Acid 38
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the
improper handling and use of this product
|