Food Service Products
Fast Break
Quarry & Hard For Use On:
Tile Cleaner
Cafeterias
Quarry Tile Concrete
Kitchens
Porcelain Meatrooms
Terrazzo Delis
DESCRIPTION
This product is a special blend of mild organic acids coupled with powerful
penetrants designed to remove slippery grease and soapy build-up
from quarry tile and concrete floors. It deep cleans by penetrating and
re-opening the pores of the floor. When used properly, this product can
help prevent slipping while promoting cleanliness in kitchens, meatrooms,
delis, cafeterias, and anywhere else greasy soiled floors may be a
problem. Can be used on quarry tile, concrete, glazed tile, resilient tile and
vinyl floors. It will penetrate, clean and brighten tile grouting. DO NOT
let product stand on polished marble, wood, aluminum, nylon carpet
or painted surfaces. If uncertain, test in a small inconspicuous area
before using.
DIRECTIONS
Remove food and equipment from area before using.
DAILY CLEANING: Dilute product 4 ozs. Per gallon of hot or cold water.
Pour solution directly onto floor and spread over entire floor with mop
or deck brush (alternatively, solution may be applied with a foaming
applicator). Allow to stand for 5 minutes and agitate with brush. Remove
solution with squeegee or wet-vac, rinse well, and dry floor with
squeegee or wet-vac.
HEAVILY SOILED GREASY FLOORS: Wet floor with water or 4 ozs. per
gallon solution. Apply product full strength directly to floor and follow
above directions.
PRODUCT SPECIFICATIONS
17.0 卤 0.5%
Active Ingredients: Sequestration: Excellent
Color: Clear Detergency: Excellent
Odor: None Rinsability: Excellent
Base: Sequestering acids Fumes: None
pH: 1.0 - 1.5 Flash Point: None (waterbased)
Viscosity: Moderately viscous Biodegradability: Complete
Foam: High Storage/Stability: 2 years
Abrasives: None Weight per Gallon: 8.75 lbs./gal.
Solubility: Complete with water Freeze / Thaw Stability: Keep from freezing
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
FAS MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 5/99 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Product Name: Fast Break
Manufacturer's Name:
Misco Products Corporation Generic Name: Quarry & Hard Tile Cleaner
Manufacturer's Address: Chemical Family: Acid Detergent Blend
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer's Phone #: (610) 926-4106
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
1mg/M3 1mg/M3 3mg/M3
Phosphoric Acid 7664-38-2 0 to 5
Citric Acid 77-92-9 5 to 10
NonIonic Surfactant 9016-45-9 0 to 5
Anionic Surfactant 27176-87-0 5 to 10
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): N/A
Boiling Point (掳F): 210 F. Specific Gravity: 1.078
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Vapor Pressure: <20mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: N/A
% Volatile: 80+ pH: 1.0-1.5
Special Firefighting Procedures: Non Flammable
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Unusual Fire and Explosion Hazards: N/A
Physical Description: Clear liquid with pleasant odor.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Phosphoric oxide vapors in a fire. Incompatibility (Materials to Avoid): Strong alkalis, Oxidizing agents, Chlorine
Bleach.
SECTION 6-STORAGE AND HANDLING INFORMATION
Keep out of reach of children. For use by trained personnel only. Keep unauthorized personnel away when applying to floor. Keep container closed during storage. For
institutional and industrial use only. Avoid contact with eyes, skin and clothing. Avoid breathing of vapors. Use in well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: Use in well-ventilated area.
Skin: Severe skin irritant. Prolonged or repeated contact can cause chemical burns Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-
or dermatitis. gredients below acceptable limit.
Eyes: Severe eye irritant. Liquid and mists may burn or injure eyes, causing Protective Gloves: Acid proof rubber or neoprene.
corneal damage. Eye Protection: Safety glasses or chemical face shield.
Inhalation: May be irritating to mucous membranes of the nose, throat, and lungs. Other Protective Equipment: Eyewash station, chemical resistant apron and
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache, protective footwear e.g., rubber boots should be worn.
nausea, abdominal pain, vomiting, and diarrhea. Excessive amounts may cause
collapse.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush exposed area with large quantities of water. Seek medical attention if Steps to be taken in Case Material is Released or Spilled: Floors will become
irritation persists. slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
attention if irritation persists. Waste Disposal Method: Any method in accordance with local, state and federal
laws. Best method is to recycle or reuse for intended purpose. Consult local
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
river or to ground. Rinse container thoroughly before discarding in trash.
attention immediately.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
No - Fire Hazard FOR CONTAINERS < 1Gallon: ORM-D Identification System
No - Sudden Release of Pressure Hazard FOR 1 GALLON CONTAINERS : Compound, Cleaning Liquid Health 2
No - Reactivity Hazard (Phosphoric Acid Solution), 8, NA-1760, PGIII (Limited Qty.) Flammability 0
Yes - Immediate (acute) Health Hazard FOR CONTAINERS > 1 GALLON : Compound, Cleaning Reactivity 0
No - Delayed (chronic) Health Hazard Liquid (Phosphoric Acid Solution), 8, NA-1760, PGIII Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
7664-38-2 Phosphoric Acid 0 to 5
27176-87-0 Dodecylbenzene Sulfonic Acid 5 to 10
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the
improper handling and use of this product
|