Onyx
High Productivity FOR USE ON:
Floor Strippers
Stripper Vinyl Tile Rubber Tile* Terrazzo
Vinyl Asbestos Concrete Ceramic Tile
Asphalt Tile* Flagstone
Linoleum
DESCRIPTION
A new generation 铿俹or 铿乶ish stripper that rapidly
penetrates and solubilizes 铿俹or 铿乶ish. Powerful solvents
combined with penetrating amines dissolve the 铿乶ish
on contact, reducing the waiting periods for removal of
the 铿乶ish. This product completely evaporates from the
surface. Can be used with or without a 铿俹or machine.
DIRECTIONS
1. Sweep or dust mop the 铿俹or to remove any debris.
2. Dilute Low Odor Floor Finish Remover from 1:3 to 1:14
(32oz. to 9oz./gal) with cold or warm water, depending
on age and build-up of 铿乶ish. Do not use hot water.
3. Apply liberally with a mop to an area small enough so
as not to allow the product to dry. Be sure to completely
cover 铿俹or to baseboards.
4. After 3 to 5 minutes, agitate the wet section with a mop
or machine scrub. Pick up solution using a mop, wet vac
or automatic scrubber.
5. Rinse thoroughly with clear water to remove residue as
necessary.
PRODUCT SPECIFICATIONS
Active Ingredients: 55.0 卤 0.5% Emulsi铿乧ation: Excellent
Color: Clear Detergency: Excellent
Odor: Sassafras Rinsability: Excellent
145oF (TCC)
pH: 12.5 - 13.0 Flash Point:
Viscosity: Water thin Biodegradability: Complete
Foam: Low Storage/Stability: 2 years
Abrasives: None Weight per Gallon: 8.27 lbs./gal.
Phosphate Content: None Freeze / Thaw Stability: Keep from freezing
Solubility: Complete with water
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
ONY MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 6/99 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer鈥檚 Name: Product Name: Onyx Supplier鈥檚 Name:
Misco Products Corporation Generic Name: High Productivity Stripper
Manufacturer鈥檚 Address: Chemical Family: Solvent Detergent Blend Supplier鈥檚 Address:
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer鈥檚 Phone #: (610) 926-4106 Supplier鈥檚 Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
2-Butoxyethanol 111-76-2 40 to 50 25 ppm 25 ppm N/A
8mg/M3
Ethanolamine 141-43-5 5 to 10 N/A N/A
Nonionic Surfactant 9016-45-9 0 to 5
Potassium Fluoroalkyl Carboxylate (C8) 2991-51-7 0 to 5
Perfume Oils N/A <1
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (掳F): 210 F. Specific Gravity: .994 Flash Point (Method Used): 145 F. (TCC)
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1 Upper Explosion Limit: 10.6 Lower Explosion Limit: 1.1
% Volatile: 96+ pH: 12.5 鈥? 13.0 Extinguishing Media: Alcohol foam, water fog, CO2 or dry chemical.
Solubility in Water: Complete Evaporation Rate (Water=1): <1 Special Firefighting Procedures: Wear self-contained breathing apparatus
Physical Description: Thin liquid with characteristic odor. for confined areas. Keep fire exposed containers cool with water spray.
Unusual Fire and Explosion Hazards: Vapors heavier than air.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids.
SECTION 6-STORAGE AND HANDLING INFORMATION
Combustible liquid- Avoid contact with heat, spark or open flame. Keep out of reach of children. For use by trained personnel only. Keep unauthorized personnel
away when applying to floor. Keep container closed during storage. For institutional and industrial use only. Avoid contact with eyes, skin and clothing. Wear
protective eyewear, gloves and footwear when handling. Avoid breathing of vapors. Use in well-ventilated area only.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: Use NIOSH approved organic vapor respirator or self-
contained breathing apparatus in confined or poorly ventilated areas.
Skin: Severe skin irritant. May cause moderate reddening, swelling, and possible
Ventilation Requirements: Provide mechanical exhaust to keep TLV of Section
skin damage.
2 ingredients below acceptable limits.
Eyes: Severe eye irritant. Liquid and mists may damage eyes, causing corneal
Protective Gloves: Chemical resistant rubber or neoprene.
damage.
Eye Protection: Chemical splash goggles or full-face shield.
Inhalation: Vapors and mists may be irritating to mucous membranes in the nose,
Other Protective Equipment: Eye wash station nearby. Protective outerwear
throat, and lungs.
and rubber boots should be worn when using.
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache,
nausea, abdominal pain, vomiting, and diarrhea. Excessive amounts may cause
collapse.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Steps to be taken in Case Material is Released or Spilled: Floors will become slippery.
Skin: Flush with water. Seek medical attention if irritation persists.
Avoid walking in product. Keep unessential personnel away. Mop up or otherwise
Eyes: Contact damage is immediate. Immediately flush with large quantities of
absorb and hold disposal. Avoid discharge to sewer or open waterways.
water, holding eyelids open. Seek medical attention immediately.
Waste Disposal Method: Any method in accordance with local, state and federal laws.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Best method is to recycle or reuse for intended purpose. If discarded, this material and
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical containers should be treated as hazardous waste based on the characteristic of corrosivity
attention immediately. and ignitability as defined under federal RCRA regulations (40 CFR 261).Consult local
authorities for disposal in public sewer. Do not dispose of into storm drain, stream, river
or to ground. Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Shipping Information:
Categories:
No - Fire Hazard FOR CONTAINERS > 1 Gallon : Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Health 3
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Cleaning Compound Flammability 2
Yes - Immediate (acute) Health Hazard Reactivity 0
Yes - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know
Act of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
111-76-2 Glycol Ether 46%
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
|