Bomanite Micro-Top Tint Pack Toluidine Red
Material Safety Data Sheet HMIS Ratings
Bomanite Corporation Health: 2
232 S. Schnoor Ave. Flammability: 0
Madera, CA 93637 Reactivity: 0
Personal Protection See VII
Equipment:
Emergency Telephone Number:
Chemtrec: (800) 424-9300
Notice: The following information is accurate to the best of our knowledge and is offered in good faith. No
warranty, either expressed or implied, is hereby made. The recommended industrial hygiene and safe handling
procedures are believed to be generally applicable. However, each user should review these recommendations in
specific context of the intended use and determine whether they are appropriate.
I. IDENTIFICATION
Product Name: Bomanite Micro-Top Tint Pack Toluidine Red
Synonymous: N/A
Chemical Family: N/A
Chemical Formula: Proprietary
D.O.T. Hazard Class: Not regulated
Appearance & Odor: Red liquid, slight ammonia odor.
II. HAZARDOUS COMPONENTS & EXPOSURE LIMITS
Composition % OSHA TWA ACGIH TLV CAS NO.
CI Pigment Red 3 Not established Not established 2425-85-6
Diethylene Glycol 5-10 Not established Not established 111-46-6
III. TYPICAL PHYSICAL & CHEMICAL CHARACTERISTICS
Specific Gravity (H2O=1): > 1, < 2
Boiling Point: 212 掳F (100 掳C)
Melting Point: N/A
Vapor Pressure: 17.5mm Hg @ 68 掳F (20 掳C)
Vapor Density: N/A
Evaporation Rate: <1.0
Solubility In Water: Miscible
IV. FIRE EXPLOSION & REACTIVITY DATA
Flash Point: N/A
Flammable Limits: N/A
Firefighting Media: Water, carbon dioxide, and foam.
Firefighting
Procedure: Positive pressure, self-contained breathing apparatus. Wear full
protective clothing. Toxic vapors are emitted in a fire condition.
Revised Bomanite Micro-Top Tint Pack Toluidine Red - Page 1 of 3
06/2007
Special Firefighting
Procedure: N/A
Unusual Fire Hazards: N/A
Reactivity: Stable.
Incompatibilities: None.
Decomposition or
Byproducts: Oxides of carbon.
Hazardous
Polymerization: Will not occur.
Conditions to Avoid: None.
V. HEALTH HAZARD DATA
Inhalation: Exposure to vapors or mist, generated at higher temperatures, may
cause drowsiness and headache. Inhalation of vapor and/or mist may be
significant if material is heated, agitated or sprayed.
Skin Contact: Prolonged or repeated contact causes mild skin irritation.
Eye Contact: May cause severe irritation. Causes redness, tearing and blurred vision.
Ingestion: May cause tissue damage. May cause central nervous system effects.
May cause liver and kidney damage. May be fatal if swallowed.
Health Hazards: May cause severe eye irritation. Prolonged or repeated exposure may
cause skin irritation, gastrointestinal disorders.
Chronic Health
Hazards: May cause liver and kidney damage. May cause formation of bladder
stones, May cause bladder cancer.
Overexposure Effects: Gastrointestinal system disorders, central nervous system damage.
Causes respiratory tract irritation, may result in dizziness and
drowsiness.
Aggravated Medical
Conditions: Kidney disorders. Liver disorders. Neurological ailments.
Carcinogenicity: This product does not contain 0.1% or more of any substance that is
listed as a carcinogen by NTP, IARC or OSHA.
Emergency and First Aid Procedures
Inhalation: Move person to fresh air. Aid in breathing if necessary, and get
immediate medical attention.
Skin Contact: Flush skin with large amounts of water. If irritation persists, get medical
attention.
Eye Contact: Immediately flush eyes with plenty of water for at least 15 minutes and
get medical attention if irritation persists.
Revised Bomanite Micro-Top Tint Pack Toluidine Red - Page 2 of 3
06/2007
Ingestion: Get medical attention. If vomiting occurs, keep head lower than hips to
prevent aspiration.
VI. SPILL PROCEDURES & WASTE DISPOSAL
Spill: Contain spillage. Neutralize with sodium bicarbonate, soda ash or lime.
Soak up spill using an absorbent material. Scoop into a suitable
container.
Waste
Disposal: Dispose of in accordance with Federal, State and Local regulations.
Precautions for
Safe Handling
And Storage: Keep container closed; keep from freezing.
Other Precautions: N/A
VII. PROTECTIVE CONTROL MEASURES
Respirator: Use approved respiratory protection if exposure limits are exceeded, or
overuse is likely.
Ventilation: General ventilation. Local exhaust ventilation as necessary to control
dust, mist, vapor or fumes.
Special: Avoid breathing vapors and mist.
Protective Gloves: Rubber or neoprene gloves.
Eye Protection: Safety glasses with side shields.
Other Protective
Clothing Required: Long sleeve shirts and trousers.
Work/Hygiene Practices
Wash hands after use and before eating, drinking or smoking.
Revised Bomanite Micro-Top Tint Pack Toluidine Red - Page 3 of 3
06/2007
Bomanite Micro-Top Tint Pack Azo Yellow
Material Safety Data Sheet HMIS Ratings
Bomanite Corporation Health: 2
232 S. Schnoor Ave. Flammability: 0
Madera, CA 93637 Reactivity: 0
Personal Protection See VII
Equipment:
Emergency Telephone Number:
Chemtrec: (800) 424-9300
Notice: The following information is accurate to the best of our knowledge and is offered in good faith. No
warranty, either expressed or implied, is hereby made. The recommended industrial hygiene and safe handling
procedures are believed to be generally applicable. However, each user should review these recommendations in
specific context of the intended use and determine whether they are appropriate.
I. IDENTIFICATION
Product Name: Bomanite Micro-Top Tint Pack Azo Yellow
Synonymous: N/A
Chemical Family: N/A
Chemical Formula: Proprietary
D.O.T. Hazard Class: Not regulated
Appearance & Odor: Yellow liquid, slight ammonia odor.
II. HAZARDOUS COMPONENTS & EXPOSURE LIMITS
Composition % OSHA TWA ACGIH TLV CAS NO.
CI Pigment Yellow 74 40-60 Not established Not established 6358-31-2
III. TYPICAL PHYSICAL & CHEMICAL CHARACTERISTICS
Specific Gravity (H2O=1): 1.0
Boiling Point: >212 掳F (100 掳C)
Melting Point: N/A
Vapor Pressure: 17.5mm Hg @ 68 掳F (20 掳C)
Vapor Density: N/A
Evaporation Rate: <1.0
Solubility In Water: Dispersible
IV. FIRE EXPLOSION & REACTIVITY DATA
Flash Point: > 212 掳F (100 掳C)
Flammable Limits: N/A
Firefighting Media: Water, carbon dioxide, and foam
Firefighting
Procedure: Positive pressure, self-contained breathing apparatus. Toxic vapors are
emitted in a fire condition.
Revised Bomanite Micro-Top Tint Pack Azo Yellow - Page 1 of 3
06/2007
Special Firefighting
Procedure: N/A
Unusual Fire Hazards: N/A
Reactivity: Stable
Incompatibilities: None.
Decomposition or
Byproducts: Oxides of carbon, oxides of nitrogen, metal oxide fumes.
Hazardous
Polymerization: Will not occur.
Conditions to Avoid: None.
V. HEALTH HAZARD DATA
Inhalation: Exposure to vapors or mist, generated at higher temperatures, may
cause drowsiness and headache.
Skin Contact: Prolonged or repeated contact causes mild skin irritation.
Eye Contact: Causes eye irritation.
Ingestion: May cause pain, nausea, vomiting and diarrhea.
Health Hazards: Causes eye irritation. Prolonged or repeated exposure may cause skin
irritation. Causes respiratory tract irritation, may result in dizziness and
drowsiness. May cause irritation to the mouth, throat and stomach.
Aggravated Medical
Conditions: Eye, dermal, respiratory ailments; blood, kidney and liver disorders.
Carcinogenicity: This product does not contain 0.1% or more of any substance that is
listed as a carcinogen by NTP, IARC or OSHA.
Emergency and First Aid Procedures
Inhalation: Move person to fresh air. Aid in breathing if necessary, and get
immediate medical attention.
Skin Contact: Flush skin with large amounts of water. If irritation persists, get medical
attention.
Eye Contact: Immediately flush eyes with plenty of water for at least 15 minutes and
get medical attention if irritation persists.
Ingestion: Get medical attention. If vomiting occurs, keep head lower than hips to
prevent aspiration.
VI. SPILL PROCEDURES & WASTE DISPOSAL
Revised Bomanite Micro-Top Tint Pack Azo Yellow - Page 2 of 3
06/2007
Spill: Contain spillage. Soak up spill using an absorbent material. Scoop into a
suitable container.
Waste
Disposal: Dispose of in accordance with Federal, State and Local regulations.
Precautions for
Safe Handling
And Storage: Keep container closed; keep from freezing.
Other Precautions: N/A
VII. PROTECTIVE CONTROL MEASURES
Respirator: Use approved respiratory protection if exposure limits are exceeded, or
overuse is likely.
Ventilation: General ventilation. Local exhaust ventilation as necessary to control
dust, mist, vapor or fumes.
Special: Avoid breathing vapors and mist.
Protective Gloves: Rubber or neoprene gloves.
Eye Protection: Safety glasses with side shields.
Other Protective
Clothing Required: Long sleeve shirts and trousers.
Work/Hygiene Practices
Wash hands after use and before eating, drinking or smoking.
Revised Bomanite Micro-Top Tint Pack Azo Yellow - Page 3 of 3
06/2007
Bomanite Micro-Top Tint Pack Black Iron Oxide
Material Safety Data Sheet HMIS Ratings
Bomanite Corporation Health: 2
232 S. Schnoor Ave. Flammability: 0
Madera, CA 93637 Reactivity: 0
Personal Protection See VII
Equipment:
Emergency Telephone Number:
Chemtrec: (800) 424-9300
Notice: The following information is accurate to the best of our knowledge and is offered in good faith. No
warranty, either expressed or implied, is hereby made. The recommended industrial hygiene and safe handling
procedures are believed to be generally applicable. However, each user should review these recommendations in
specific context of the intended use and determine whether they are appropriate.
I. IDENTIFICATION
Product Name: Bomanite Micro-Top Tint Pack Black Iron Oxide
Synonymous: N/A
Chemical Family: N/A
Chemical Formula: Proprietary
D.O.T. Hazard Class: Not regulated
Appearance & Odor: Black liquid, slight ammonia odor.
II. HAZARDOUS COMPONENTS & EXPOSURE LIMITS
Composition % OSHA TWA ACGIH TLV CAS NO.
CI Pigment Black 11 40-60 Not established Not established 12227-89-3
3.5 mg/m3 3.5 mg/m3
CI Pigment Black 7 1-10 1333-86-4
III. TYPICAL PHYSICAL & CHEMICAL CHARACTERISTICS
Specific Gravity (H2O=1): 1.98
Boiling Point: >212 掳F (100 掳C)
Melting Point: N/A
Vapor Pressure: 17.5mm Hg @ 68 掳F (20掳C)
Vapor Density: N/A
Evaporation Rate: <1.0
Solubility In Water: Dispersible
IV. FIRE EXPLOSION & REACTIVITY DATA
Flash Point: >212 掳F (100 掳C)
Flammable Limits: N/A
Firefighting Media: Water, carbon dioxide, and foam.
Revised Bomanite Micro-Top Tint Pack Black Iron Oxide - Page 1 of 3
06/2007
Firefighting
Procedure: Positive pressure, self-contained breathing apparatus. Wear full
protective clothing. Toxic vapors are emitted in a fire condition.
Special Firefighting
Procedure: N/A
Unusual Fire Hazards: N/A
Reactivity: Stable.
Incompatibilities: None.
Decomposition or
Byproducts: Oxides of carbon, oxides of nitrogen, metal oxide fumes.
Hazardous
Polymerization: Will not occur.
Conditions to Avoid: None.
V. HEALTH HAZARD DATA
Inhalation: Exposure to vapors or mist, generated at higher temperatures, may
cause drowsiness and headache.
Skin Contact: Prolonged or repeated contact causes mild skin irritation.
Eye Contact: Causes eye irritation.
Ingestion: May cause pain, damage, vomiting and diarrhea.
Health Hazards: Cancer hazard. Not a hazard in wet form. Prolonged or repeated
exposure may cause eye and skin irritation. May cause irritation of the
mouth, throat and stomach.
Aggravated Medical
Conditions: Eye, dermal and respiratory ailments; blood, kidney and liver disorders.
Carcinogenicity: IARC: CI Pigment Black 7
The primary route of potential human exposure is by the inhalation of
Respirable airborne particles. Since this material is in a liquid form, it is
not expected to pose a cancer risk unless it is allowed to dry.
Emergency and First Aid Procedures
Inhalation: Move person to fresh air. Aid in breathing if necessary, and get
immediate medical attention.
Skin Contact: Flush skin with large amounts of water. If irritation persists, get medical
attention.
Eye Contact: Immediately flush eyes with plenty of water for at least 15 minutes and
get medical attention if irritation persists.
Ingestion: Get medical attention. If vomiting occurs, keep head lower than hips to
prevent aspiration.
Revised Bomanite Micro-Top Tint Pack Black Iron Oxide - Page 2 of 3
06/2007
VI. SPILL PROCEDURES & WASTE DISPOSAL
Spill: Contain spillage. Soak up spill using an absorbent material. Scoop into a
suitable container.
Waste
Disposal: Dispose of in accordance with Federal, State and Local regulations.
Precautions for
Safe Handling
And Storage: Keep container closed; keep from freezing.
Other Precautions: N/A
VII. PROTECTIVE CONTROL MEASURES
Respirator: Use approved respiratory protection if exposure limits are exceeded, or
overuse is likely.
Ventilation: General ventilation. Local exhaust ventilation as necessary to control
dust, mist, vapor or fumes.
Special: Avoid breathing vapors and mist.
Protective Gloves: Rubber or neoprene gloves.
Eye Protection: Safety glasses with side shields.
Other Protective
Clothing Required: Long sleeve shirts and trousers.
Work/Hygiene Practices
Wash hands after use and before eating, drinking or smoking.
Revised Bomanite Micro-Top Tint Pack Black Iron Oxide - Page 3 of 3
06/2007
Bomanite Micro-Top Tint Pack Titanium Dioxide White
Material Safety Data Sheet HMIS Ratings
Bomanite Corporation Health: 2
232 S. Schnoor Ave. Flammability: 0
Madera, CA 93637 Reactivity: 0
Personal Protection See VII
Equipment:
Emergency Telephone Number:
Chemtrec: (800) 424-9300
Notice: The following information is accurate to the best of our knowledge and is offered in good faith. No
warranty, either expressed or implied, is hereby made. The recommended industrial hygiene and safe handling
procedures are believed to be generally applicable. However, each user should review these recommendations in
specific context of the intended use and determine whether they are appropriate.
I. IDENTIFICATION
Product Name: Bomanite Micro-Top Tint Pack Titanium Dioxide White
Synonymous: N/A
Chemical Family: N/A
Chemical Formula: Proprietary
D.O.T. Hazard Class: Not regulated
Appearance & Odor: White liquid, slight ammonia odor.
II. HAZARDOUS COMPONENTS & EXPOSURE LIMITS
Composition % OSHA TWA ACGIH TLV CAS NO.
10 mg/m3 (Total Dust) 10 mg/m3 (Total Dust)
Titanium Dioxide 60-75 13463-67-7
5 mg/m3 (Respirable Dust)
Diethylene Glycol 5-10 Not established Not established 111-46-6
15 mg/m3 (Total Dust) 10 mg/m3
Calcium Carbonate 1-5 1317-65-3
5 mg/m3 (Respirable Dust)
III. TYPICAL PHYSICAL & CHEMICAL CHARACTERISTICS
Specific Gravity (H2O=1): 1.5 - 2
Boiling Point: 212 掳F (100 掳C)
Melting Point: N/A
Vapor Pressure: 17.5mm Hg @ 68 掳F (20 掳C)
Vapor Density: N/A
Evaporation Rate: <1.0
Solubility In Water: Dispersible
IV. FIRE EXPLOSION & REACTIVITY DATA
Flash Point: N/A
Flammable Limits: N/A
Firefighting Media: Water, carbon dioxide, and foam.
Revised Bomanite Micro-Top Tint Pack Titanium Dioxide White - Page 1 of 3
06/2007
Firefighting
Procedure: Positive pressure, self-contained breathing apparatus. Wear full
protective clothing. Toxic vapors are emitted in a fire condition.
Special Firefighting
Procedure: N/A
Unusual Fire Hazards: N/A
Reactivity: Stable.
Incompatibilities: None.
Decomposition or
Byproducts: Oxides of carbon.
Hazardous
Polymerization: Will not occur.
Conditions to Avoid: None.
V. HEALTH HAZARD DATA
Inhalation: Exposure to vapors or mist, generated at higher temperatures, may
cause drowsiness and headache. Inhalation of vapor and/or mist may be
significant if material is heated, agitated or sprayed.
Skin Contact: Prolonged or repeated contact causes mild skin irritation.
Eye Contact: May cause severe irritation. Causes redness, tearing and blurred vision.
Ingestion: May cause tissue damage. May cause central nervous system effects.
May cause liver and kidney damage. May be fatal if swallowed.
Health Hazards: May cause severe eye irritation. Prolonged or repeated exposure may
cause skin irritation, gastrointestinal disorders.
Chronic Health
Hazards: May cause liver and kidney damage. May cause formation of bladder
stones. May cause bladder cancer.
Overexposure Effects: Gastrointestinal system disorders, central nervous system damage.
Causes respiratory tract irritation, may result in dizziness and
drowsiness.
Aggravated Medical
Conditions: Kidney disorders. Liver disorders. Neurological ailments.
Carcinogenicity: This product does not contain 0.1% or more of any substance that is
listed as a carcinogen by NTP, IARC or OSHA.
Emergency and First Aid Procedures
Inhalation: Move person to fresh air. Aid in breathing if necessary, and get
immediate medical attention.
Revised Bomanite Micro-Top Tint Pack Titanium Dioxide White - Page 2 of 3
06/2007
Skin Contact: Flush skin with large amounts of water. If irritation persists, get medical
attention.
Eye Contact: Immediately flush eyes with plenty of water for at least 15 minutes and
get medical attention if irritation persists.
Ingestion: Get medical attention. If vomiting occurs, keep head lower than hips to
prevent aspiration.
VI. SPILL PROCEDURES & WASTE DISPOSAL
Spill: Contain spillage. Neutralize with sodium bicarbonate, soda ash or lime.
Soak up spill using an absorbent material. Scoop into a suitable
container.
Waste
Disposal: Dispose of in accordance with Federal, State and Local regulations.
Precautions for
Safe Handling
And Storage: Keep container closed; keep from freezing.
Other Precautions: N/A
VII. PROTECTIVE CONTROL MEASURES
Respirator: Use approved respiratory protection if exposure limits are exceeded, or
overuse is likely.
Ventilation: General ventilation. Local exhaust ventilation as necessary to control
dust, mist, vapor or fumes.
Special: Avoid breathing vapors and mist.
Protective Gloves: Rubber or neoprene gloves.
Eye Protection: Safety glasses with side shields.
Other Protective
Clothing Required: Long sleeve shirts and trousers.
Work/Hygiene Practices
Wash hands after use and before eating, drinking or smoking.
Revised Bomanite Micro-Top Tint Pack Titanium Dioxide White - Page 3 of 3
06/2007
Bomanite Micro-Top Tint Pack Toluidine Red YS
Material Safety Data Sheet HMIS Ratings
Bomanite Corporation Health: 2
232 S. Schnoor Ave. Flammability: 0
Madera, CA 93637 Reactivity: 0
Personal Protection See VII
Equipment:
Emergency Telephone Number:
Chemtrec: (800) 424-9300
Notice: The following information is accurate to the best of our knowledge and is offered in good faith. No
warranty, either expressed or implied, is hereby made. The recommended industrial hygiene and safe handling
procedures are believed to be generally applicable. However, each user should review these recommendations in
specific context of the intended use and determine whether they are appropriate.
I. IDENTIFICATION
Product Name: Bomanite Micro-Top Tint Pack Toluidine Red YS
Synonymous: N/A
Chemical Family: N/A
Chemical Formula: Proprietary
D.O.T. Hazard Class: Not regulated
Appearance & Odor: Red liquid, slight ammonia odor.
II. HAZARDOUS COMPONENTS & EXPOSURE LIMITS
Composition % OSHA TWA ACGIH TLV CAS NO.
CI Pigment Red 3 45-55 Not established Not established 2425-85-6
Ammonium <1 35ppm (as ammonia) STEL 35ppm (as ammonia) STEL 1336-21-6
Hydroxide* 25ppm (as ammonia)
* Denotes reportable chemicals pursuant to SARA Title III, Section 313.
III. TYPICAL PHYSICAL & CHEMICAL CHARACTERISTICS
Specific Gravity (H2O=1): > 1
Boiling Point: >212 掳F (100 掳C)
Melting Point: N/A
Vapor Pressure: 17.5mm Hg @ 68 掳F (20掳C)
Vapor Density: N/A
Evaporation Rate: <1.0
Solubility In Water: Dispersible
IV. FIRE EXPLOSION & REACTIVITY DATA
>212 掳F (100 掳C)
Flash Point:
Flammable Limits: N/A
Firefighting Media: Water, carbon dioxide, and foam.
Revised Bomanite Micro-Top Tint Pack Toluidine Red YS - Page 1 of 3
06/2007
Firefighting
Procedure: Positive pressure, self-contained breathing apparatus. Wear full
protective clothing. Toxic vapors are emitted in a fire condition.
Special Firefighting
Procedure: N/A
Unusual Fire Hazards: N/A
Reactivity: Stable.
Incompatibilities: None.
Decomposition or
Byproducts: Oxides of carbon, oxides of nitrogen, metal oxide fumes.
Hazardous
Polymerization: Will not occur.
Conditions to Avoid: None.
V. HEALTH HAZARD DATA
Inhalation: Exposure to vapors or mist, generated at higher temperatures, may
cause drowsiness and headache.
Skin Contact: Prolonged or repeated contact causes mild skin irritation.
Eye Contact: Causes eye irritation.
Ingestion: May cause pain, damage, vomiting and diarrhea.
Health Hazards: Causes eye irritation. Prolonged or repeated exposure may cause skin
irritation, respiratory tract irritation. May result in dizziness and
drowsiness. May cause irritation of the mouth, throat and stomach.
Aggravated Medical
Conditions: Eye, dermal, respiratory ailments; blood, kidney and liver disorders.
Carcinogenicity: This product does not contain 0.1% or more of any substance that is
listed as a carcinogen by NTP, IARC or OSHA.
Emergency and First Aid Procedures
Inhalation: Move person to fresh air. Aid in breathing if necessary, and get
immediate medical attention.
Skin Contact: Flush skin with large amounts of water. If irritation persists, get medical
attention.
Eye Contact: Immediately flush eyes with plenty of water for at least 15 minutes and
get medical attention if irritation persists.
Ingestion: Get medical attention. If vomiting occurs, keep head lower than hips to
prevent aspiration.
Revised Bomanite Micro-Top Tint Pack Toluidine Red YS - Page 2 of 3
06/2007
VI. SPILL PROCEDURES & WASTE DISPOSAL
Spill: Contain spillage. Soak up spill using an absorbent material. Scoop into a
suitable container.
Waste
Disposal: Dispose of in accordance with Federal, State and Local regulations.
Precautions for
Safe Handling
And Storage: Keep container closed; keep from freezing.
Other Precautions: N/A
VII. PROTECTIVE CONTROL MEASURES
Respirator: Use approved respiratory protection if exposure limits are exceeded, or
overuse is likely.
Ventilation: General ventilation. Local exhaust ventilation as necessary to control
dust, mist, vapor or fumes.
Special: Avoid breathing vapors and mist.
Protective Gloves: Rubber or neoprene gloves.
Eye Protection: Safety glasses with side shields.
Other Protective
Clothing Required: Long sleeve shirts and trousers.
Work/Hygiene Practices
Wash hands after use and before eating, drinking or smoking.
Revised Bomanite Micro-Top Tint Pack Toluidine Red YS - Page 3 of 3
06/2007
|