SATELLITE CITY SIMI VALLEY, CA Page 1 of 3 EMERGENCY PHONES:(303) 592-1711(Poison Control)
TELEPHONE (805) 522-006 (800) 424-9300 (Chemtrec)
NCF Accelerators (860) 571-5100 (Loctite#20302)
(NCF & NCFM) 2, 5 and 18 ISSUED 9/23/03
MATERIAL SAFETY DATA SHEET
1. PRODUCT IDENTIFICATION
Product Name NCF Part No. NCF
Product Type CYANOACRYLATE ACCELERATOR Formula No. N/A
2. COMPOSITION Other
Ingredients Chem. Formula Generic Name(s) CAS No. %
SNPB (n-Propyl Bromide) 106-94-5 98-99
"N,N-Dialkyltoluidine" n/a n/a 99-97-8 0.015-0.016
Organic Fragrance n/a n/a Proprietary 0.002-0.003
"2,6-DI-tert-Butyl-p-CRESOL" n/a n/a 128-37-0 0.002-0.003
3. CHEMICAL AND PHYSICAL PROPERTIES
Vapor Pressure: 1143 mmHg
Vapor. Density: (Air = 1.0) 4.3
Solubility in Water: 1.32
Specific Gravity: 1.33 at 70 deg. F
Boiling Point:. 89.6 deg. F
% VolatiIes 100
Evaporation Rate (Ether = 1) >1
pH: Does not apply
Appearance: clear liquid
Odor: Mild
4. FLAMMABILITY AND EXPLOSIVE PROPERTIES
Flash Point: None
Flash Point Method Material is not flammable
Health Hazard: 2
Fire Hazard: 0
Reactivity Hazard: 0
Specific Hazard: No Water
Estimated HMIS Code:
Health Hazard: 1
Flammability Hazard: 0
Reactivity Hazard: 0
Personal Protection: See Section 10.
Flame Propagation Rate(Solids): Not solid Material
OSHA Flammability Class: N/A
Recommended
Extinguishing Agents: Material is not flammable
Hazardous Products Formed
"by Fire or Thermal Decomp Toxic chlorides and fluorides,"
Unusual Fire or Explosion Hazards:
Product will decompose at temperatures above 400 deg. C. Decomposition products include carbon monoxide, carbon dioxide, hydrogen
bromide and / or bromine.
Compressed Gases:
None
Pressure at Room Temp.: N/A
Special Firefighting Precautions/Instructions:
Firefighters should wear NIOSH approved positive pressure self contained breathing apparatus for protection against suffocation and
possible exposure to hydrochloric and hydroflouric acids and phosgene. Also, proper eye and skin protection should be used. Use water
spray to keep containers cool.
5. SPILL OR LEAK AND DISPOSAL PROCEDURES
Steps to be taken in case of spill or leak: - (Always wear recommended personel protective equipment.)
(Less than 1 pint): Move upwind and/or out of the area and allow to evaporate with good ventilation.
(Large Spills): Immediately evacuate the area and provide maximum ventilation. Only personnel equipped with proper respiratory and
eye/skin protection should be permitted in area. Dyke to contain the spill.
Take precautions as necessary to prevent contamination of ground and surface water. Spills and released may need to
be reported to Federal and or local authorities.
SATELLITE CITY SIMI VALLEY, CA Page 2 of 3 EMERGENCY PHONES:(303) 592-1711(Poison Control)
TELEPHONE (805) 522-006 (800) 424-9300 (Chemtrec)
NCF Accelerators (860) 571-5100 (Loctite#20302)
(NCF & NCFM) 2, 5 and 18 ISSUED 9/23/03
MATERIAL SAFETY DATA SHEET
6. STORAGE AND HANDLING PROCEDURES
Storage:
Keep product tightly capped and in original container. Store room temperature. Do not store near food. Keep away from children.
Handling:
Always wear recommended personal protective equipment.) Avoid prolonged
skin contact. Keep away from eyes. Avoid prolonged breathing of vapors.
7. SHIPPING REGULATIONS
US DOT CLASS: Not Regulated
US DOT ID NUMBER: Not Regulated
IATA
Proper Shipping Name non-flammable liquid
Class or Division Packing Group III
UN or ID Number None
IMO
Substance Non flammable liquid
Marine Pollutant Status Not regulated
Class Not regulated
Subsidiary Risk Label Not regulated
IMDG Code Page Not regulated
UN Number Not regulated
8. REACTIVITY DATA
Stability: Stable
Hazardous Polymerization? Will not occur
Hazardous Decomposition "Product will decompose at temperatures above 400 deg. C. Decomposition products include
hydrochloric acid, hydroflouric acid, and carbonyl halides such asphosgene."
Incompatibility:
Finely divided reactive metals. May attack some plastics. Avoid stong oxidizers and acids. Thoroughly test for all appli
cations before use.
9. EMERGENCY TREATMENT PROCEDURES
Ingestion: Swallowing of this material may result in irritation of the mouth and gastrointestinal tract, abdominal pain and vomiting in
addition to effects similar to those caused by inhilation. If victim is conscious, have him drink large amounts of water,
Do not induce vomiting unless instructed to by a physician. Take immediately to a hospital or physician.
Inhalation: High concentrations are irritating to the repiratory tract. May cause headache, dizziness, nausea/vomitting, narcosis.
Remove to fresh air. Give artificial resuscitation(CPR) if breathing has stopped. Give oxygen as necessary if
qualified operator is available. Get immediate medical attention.
Skin Contact: Brief contact may cause slight irritaion, prolonged contact may cause moderate irritaion and dermititis. This problem is
accentuated when liquid is trapped against skin by contaminated clothing and shoes. Remove contaminated clothing
and shoes and wash promptly with soap and water. Thoroughly clean contaminat
ed clothing and shoes before reuse of discard. If irritaions persists, get medical attention.
Eye Contact: Contact with high vapor consentration may cause irritation and pain. "Flush with large amounts of water for at least
15 minutes . If irritaions persists, get medical attention.
10. PERSONAL PROTECTION
Eyes: Splash-proof chemical safety goggles or face shield. Contact lenses should not be worn when using this product
Skin: Use protective gloves such as Viton & Norfiol are recommended; Do not use natural rubber.
Respiratory Protection: At high levels of concentration, use self contained breathing apparatus. Use local exhaust vetilation to keep vapors as
low as possibleUse NIOSH approved self-con
tained, positive pressure respirators for emergencies and in situations where air may be displaced by vapors.
Additional Recommendations: Safety shower and eye-wash fountain in immediate area. Personal protective clothing and use of equipment
must be in accordance with OSHA standards 29 CFR 1910.133 and 29 CFR 1910.132
SATELLITE CITY SIMI VALLEY, CA Page 3 of 3 EMERGENCY PHONES:(303) 592-1711(Poison Control)
TELEPHONE (805) 522-006 (800) 424-9300 (Chemtrec)
NCF Accelerators (860) 571-5100 (Loctite#20302)
(NCF & NCFM) 2, 5 and 18 ISSUED 9/23/03
MATERIAL SAFETY DATA SHEET
11. HEALTH HAZARD DATA
Primary Routes of Entry: "Skin contact, Inhalation, Ingestion, and Eye contact."
Signs and Symptoms
of Exposure:
Skin: Prolonged and or repeated contact with this solvent can cause irritation of the skin (defatting of skin).
Eyes: Irritant: Liquid contact will irritate eyes and may cause conjunctivitis.
Inhalation: "Dizziness, loss of concentration and irritation. With high exposure levels, effects can include central nervous system (CNS)
depression (intoxication) and cardiac arrhythmia. Product vapors displace air and can cause suffocation especially in a
confined space.
Ingestion: Similar symptoms as for inhalation. Discomfort due to volatility of the solvent would be expected.
Delayed Effects: None currently found.
Existing Conditions
Aggravated by Exposure: None known
Exposure Limits (TWA) ACGIH OSHA OTHER
Ingredients (TLV) (PEL) LIMITS
Dichlorofluoroethane None Established None Established 500ppm 8 hour
Ingredients for which no Exposure Limits have been established are not listed above.
Literature Referenced Carcinogen
Ingredients Target Organ and Other Health Effects NTP IARC OSHA
N N-Dialkyltoluidine No Data NO N/A NO
Organic Fragrance No Data NO NO NO
12 . HEALTH HAZARD ABBREVIATIONS
N/A Not Applicable CAR Cardiac
IRR Irritant KID Kidney
LIV Liver MET Metabolic
NER Nervous System
Emergency Phone Numbers:
(303) 592-1711(Poison Control) - (800) 424-9300 (Chemtrec) - (860) 571-5100 (LOCTITE#20302)
Revision Date: Januaray 03, 2006 Revision: 0004
FOR ADULT USE ONLY KEEP AWAY FROM CHILDREN
|