SATELLITE CITY 鈥? SIMI VALLEY, CA 鈥? (805) 522-0062 24 HOUR EMERGANCY
1(860) 5715100
ISSUED 08/26/05
HOT STUFF - SUPER鈥橳鈥? (Yellow Label)
Cat#s (HST) 1/4, 1/2, 1, 2 4 and 16 (17426)
Refer to Item:
MATERIAL SAFETY DATA SHEET
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION 8. EXPOSURE CONTROLS, PERSONAL PROTECTION
Product Name: 17426 Satellite City Gap Filling Inst Adh
Item No.: 17426 Eyes: Safety glasses or goggles.
Product Type: Cyanoacrylate Ester Skin: Nitrile or polyethylene gloves and aprons.
Do not use cotton.
2. COMPOSITION, INFORMATION ON INGREDIENTS See supplemental page for additional information.
Ventilation: Positive down-draft exhaust ventilation should be
Ingredients CAS No. % provided to maintain vapor concentration below
TLV.
Ethyl cyanoacrylate 7085-85-0 90-95 Respiratory Not available
Poly (methyl methacrylate) 9011-14-7 5-10
HYDROQUINONE 123-31-9 0.1-1 See Section 2 for Exposure Limits.
Ingredients which have exposure limits 9. PHYSICAL AND CHEMICAL PROPERTIES
Exposure Limits (TWA) ACGIH OSHA OTHER Appearance: Clear liquid
Ingredients (TLV) (PEL) Odor: Sharp, Irritating
Boiling Point: More than 300掳F
Ethyl cyanoacrylate 0.2 ppm TWA None None pH: Does not apply
HYDROQUINONE 2 mg/m3 TWA 2 mg/m3 TWA 2 mg/m3 TWA Solubility in Water: Polymerized by water.
4 mg/m3 STEL Specific Gravity 1.0156 at 77掳F
Volatile Organic Compound
Exposure Limits (STEL) ACGIH OSHA (EPA Method 24) 87.1%; 914.55 g/l
Ingredients (TLV) (PEL) 4.10% 41.6 grams per liter of material
3. HAZARDS IDENTIFICATION (California SCAQMD Method 316b)
Vapor Pressure: Less than 0.2mm at 75掳F
Vapor Density: Approximately 3
Toxicity: Skin contact may cause burns. Evaporation Rate
Bonds skin rapidly and strongly. (Ether = 1) Not available
Skin and eye irritant.
Estimated oral LD50 more than 5000mg/kg. 10. STABILITY AND REACTIVITY
Estimated dermal LD 50 more than 2000 mg/kg.
Primary Routes of Entry: None known Stability: Stable
Signs and Symptoms Hazardous Polymerization: Will not occur
of Exposure: Vapor is irritating to eyes and mucous membranes Incompatibility: Polymerized by contact with water, alcohols,
above TLV. Exposure to vapors above the amines, alkalies.
established limits may cause symptoms of Conditions to Avoid: Not available
non-allergic asthma. Hazardous Decomposition
Existing Conditions Products (non-thermal): None
Aggravated by Exposure: None known
11. TOXICOLOGICAL INFORMATION
Literature Referenced Carcinogen
Ingredients Target Organ and Other Health Effects NTP IARC OSHA See Section 3.
Ethyl cyanoacrylate ALG IRR RES NO NO NO 12. ECOLOGICAL INFORMATION
Poly (methyl methacrylate) IRR NO N/A NO
HYDROQUINONE BLO BNM CNS EYE IMM IRR LIV MUT NO N/A NO No data available
SKI THY
Abbreviations 13. DISPOSAL CONSIDERATIONS
N/A Not Applicable ALG Allergen Recommended methods of
BLO Blood BNM Bone Marrow disposal: Polymerize as above. Incinerate following EPA
CNS Central nervous system EYE Eyes and local regulations.
IMM Immune system IRR Irritant EPA Hazardous Waste
LIV Liver MUT Mutagen Number NH - Not a RCRA Hazardous Waste Material
RES Respiratory SKI Skin
THY Thyroid 14. TRANSPORTATION INFORMATION
4. FIRST AID MEASURES DOT (49 CFR 172)
Domestic Ground Transport
Ingestion: Ingestion is not likely. See supplemental page for Proper Shipping Name: Unrestricted (Not more than 450 liters);
emergency procedures. Combustible liquids, n.o.s. (Cyanoacrylate ester)
Inhalation: Remove to fresh air. If symptoms persist, (More than 450 liters)
obtain medical attention. Hazard Class or
Skin Contact: Soak in warm water. See supplemental page for Division: Unrestricted (Not more than 450 liters)
emergency procedures. Combustible liquid (More than 450 liters)
Eye Contact: Flush with water. See supplemental page for Identification Number: None (Not more than 450 liters);
emergency procedures. NA 1993 (More than 450 liters)
Marine Pollutant: None
5. FIRE FIGHTING MEASURES IATA
Proper Shipping Name: Unrestricted (Not more than one pint);
Flash Point: 150 - 200掳F Method: Tag Closed Cup Aviation regulated liquid, n.o.s., (Cyanoacrylate
Recommended Ester) (More than one pint)
Extinguishing Agents: Carbon dioxide, foam, dry chemical Class or Division: Unrestricted (Not more than one pint); Class 9 (More than one pint)
Special Firefighting UN or ID Number: None (Not more than one pint) UN 3334 (More than one pint)
Procedures: Not available
Hazardous Products formed 15. REGULATORY INFORMATION
by Fire or Thermal Decomp Irritating organic fragments.
Unusual Fire or CA Proposition 65: No Prop65 Chemicals known to be present.
Explosion Hazards: None
16. OTHER INFORMATION NFPA is a registered trademark of the
Explosive Limits: National Fire Protection Assn.
(% by volume in air)Lower Not available Estimated NFPA(R) Code:
(% by volume in air)Upper Not available Health Hazard: 2 HMIS is a registered trademark of the
Fire Hazard: 2 National Paint and Coatings Assn.
6. ACCIDENTAL RELEASE MEASURES Reactivity Hazard: 1
Specific Hazard: Does not apply Health Hazard: 2
Steps to be taken in case Flammability Hazard: 2
of spill or leak: Flood with water to polymerize. Soak up with an Reactivity Hazards: 1
inert absorbent. Personal Protection: See Section 8.
7. HANDLING AND STORAGE
NFPA is a registered trademark of the National Fire Protection Assn.
Safe Storage: Store at or below 75 deg. F HMIS is a registered trademark of the National Paint and Coatings Assn.
Handling: Avoid contact with skin and eyes. Avoid breathing vapor. Prepared By: Stephen Repetto
Title: Research Chemist, Environmental Health & Safety
Company: Loctite Corp., 1001 Tr Br Cr, Rocky Hill CT 06067
(24hr.) Phone: (860) 571-5100
Revision Date: January 26, 1999 Revision: 0032
|