SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET MM 592
ACGIH (TLV): TWA = 50 ppm, 269 mg/m3; STEL = 200 ppm, 1070 mg/m3 .
Threshold Limited Value
ALDON 1533 W.Henrietta Rd.
OSHA (PEL): TWA = 100 ppm, OSHA (PEL): Ceiling 200 ppm.
MM 592
Avon, New York 14414 MSDS No.
庐
CORPORATION June 19, 1996
Effective Date
(716) 226-6177
Effects of Overexposure INHALATION: Can irritate nose and throat with dizziness, drowsiness, headache,
nausea, unconsciousness and even death; resulting from exposure. EYES: Irritation
and lacrymation can result from exposure to vapor or liquid. SKIN: Causes irritation and
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE when prolonged or repeated; dermatitis. INGESTION: Causes irritation to the digestive
tract and may cause nausea and rapid drowsiness, partial paralysis, unconsciousness
MOLD RELEASE COMPOUND
Product CHEMTREC and kidney failure in severe cases.
1 2
Health
800-424-9300
Chemical
Emergency and
Mold Release Compound 2 0 EYES: Flush thoroughly with water for at least 15 minutes, lifting upper and lower eyelids
Synonyms 1
Fire
Day 716-226-6177
First Aid Procedures occasionally. Get immediate medical attention. SKIN: Remove contaminated clothing.
Mixture.
Formula Wash with mild soap and water. INHALATION: Remove to fresh air. If not breathing, give
0
Reactivity
NFPA artificial respiration. If breathing is difficult, give oxygen. Keep at rest and warm. Call
HAZARD RATING HMIS *
up to 30 mL.
Unit Size physician immediately; advise physician not to give adrenalin. INGESTION: Get immediate
LEAST SLIGHT MODERATE HIGH EXTREME medical help! Do NOT induce vomiting UNLESS directed by physician. (Authorities differ;
0 1 2 3 4 professional decisions required). Physician should be warned NOT TO USE adrenalin for
C.A.S. No. Mixture.
treatment. Never give anything by mouth to an unconscious person.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable X Excessive temperature and heat.
Trichloroethylene: (CAS No. 79-01-6) 75% See Section V.
Stable
Beeswax: (CAS No. 8012-89-3) 25% None listed. Incompatibility Contact with sodium hydroxide, potassium hydroxide or other strong alkali to form
explosive mixtures of chloroacetylenes. Soda ash does not react. Oxidizing materials.
(Materials to Avoid)
WARNING! VAPOR HARMFUL. MAY BE HARMFUL IF
Hazardous When exposed to high temperature, hydrogen chloride and phosgene (highly
SWALLOWED. * NOTE: SUSPECTED CARCINOGEN.
toxic) can be produced.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Approx. 40-50掳C (104-122掳F) Approx. 1.4 @ 25掳C
Melting Point (掳F) Polymerization of TCE is catalyzed by aluminum
May Occur Will Not Occur
X chloride, magnesium or aluminum powder can
Percent Volatile
Boiling Point (掳F) 87.1掳C (188掳F) Trichloroethylene 75% react with TCE.
by Volume (%)
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) 58 mm @ 20掳C CCI 0.69
=1)
( 4
Steps to be taken in case Recover for use if not contaminated. Using proper safety equipment (good
4.53 (Trichloroethylene)
Vapor Density (Air=1) ventilation, proper gloves); mop, wipe or soak up with absorbent materials.
material is released or spilled
Evaporate outdoors or in exhaust hood. Place absorbed waste in closed
Solubility in Water 0.1% in water @ 25掳C
container for disposal by incineration. Do not allow to enter water supply
Appearance & Odor sources.
White to yellow color gel; chloroform-like odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dispose of in an approved incinerator equipped with an afterburner and
% by Volume TCE @ 25掳C
Non-flammable. 8% 10.5%
(Method Used)
scrubber or contract with a licensed waste disposal service.
Extinguisher
Carbon dioxide (CO2 ); dry chemical (ABC); water spray. SECTION VIII SPECIAL PROTECTION INFORMATION
Media
If needed, wear a NIOSH/MSHA approved self-contained breathing apparatus or respirator
Respiration Protection
(Specify Type) containing organic vapor cartridge. Work in ventilation hood or well-ventilated area.
SPECIAL FIREFIGHTING The beeswax content is a combustible material. Trichloroethylene is
Recommended. No.
Local Exhaust Special
PROCEDURES Ventilation
normally considered non-combustible. However, when 15% vapor in air
Mechanical (General) Other
Recommended. Adequate to maintain below exposure limit.
at 33掳C is exposed to intense heat (electric arc) or to ordinary flame at
Protective Gloves Eye Protection
vapor-air temperatures exceeding 50掳C, it can be made to burn mildly. Neoprene, vitron. Chemical safety glasses.
Combustibility increases in oxygen-enriched air. In fire conditions, wear
Other Protective
a NIOSH/MSHA-approved, self-contained breathing apparatus and Goggles, lab coat, apron, ventilation hood, proper gloves, eye wash station.
Equipment
protective clothing to prevent contact with skin and eyes.
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken Store in a cool, well-ventilated area and use with adequate ventilation.
UNUSUAL FIRE AND Dangerous when heated to combustion; it emits highly toxic and corrosive in Handling & Storing Wash thoroughly after handling.
fumes (phosgene and hydrogen chloride), reacts with strong oxidizing
EXPLOSION HAZARDS Keep container tightly closed when not in use.
materials.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
Autoignition Temperature: Trichloroethylene is 420掳C (788掳F).
Use only in well-ventilated area. Avoid prolonged breathing of vapor. Avoid
contact with eyes and skin. Remove and wash contaminated clothing.
* RTECS No. KX4550000
CARCINOGENIC REVIEW: Animal positive, human indefinite. Cancer hazard
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
based on tests with laboratory animals. It is listed in Group 3 by IARC and is
Chemical Safety
not listed by HTP or OSHA. Approved
Revision Date
No. 3 Michael Raszeja
6/19/96 MR
Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|