SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET ZZ 50
Threshold Limited Value
ALDON None established for this material. (ACGIH 1983-84).
1533 W.Henrietta Rd.
ZZ 50
Avon, New York 14414 MSDS No.
庐
CORPORATION August 18, 1995
Effective Date Local toxicity, low. Causes nausea and vomiting when ingested, with larger
(716) 226-6177
Effects of Overexposure doses being self-purging. INHALATION: No specific hazard known. May
produce irritation and coughing. EYES: No specific hazard is known.
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE However, any material that contacts the eye may be irritating, with redness,
pain, and blurred vision. SKIN: Low hazard. May cause irritation. Exercise
Product ZINC CARBONATE, BASIC CHEMTREC appropriate procedures to minimize potential hazards.
Health 0
800-424-9300
Chemical
Emergency and
Zinc Carbonate, Hydroxide
Synonyms INHALATION: Remove to fresh air. If illness or discomfort develops, get
0
Fire
Day 716-226-6177
First Aid Procedures medical attention. EYES: Flush thoroughly with water for at least 15
Formula (ZnCO ) 鈥?(Zn(OH) ) 1
Reactivity
32 23 minutes, lifting upper and lower eyelids occasionally. Get medical
NFPA
HAZARD RATING attention. SKIN: Flush thoroughly with water, then wash with mild soap
HMIS *
Unit Size up to 2.5 Kg.
LEAST SLIGHT MODERATE HIGH EXTREME and water. INGESTION: If swallowed, if conscious, give water to drink,
0 1 2 3 4 induce vomiting and call physician. Never give anything by mouth to an
C.A.S. No. 5970-47-8
unconscious person.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable Decomposes at 300掳C (572掳F) to Zinc Oxide
Zinc Carbonate, Basic 100% None established.
and carbon dioxide (CO ).
Stable X 2
Incompatibility
Acids react with the formation of a great deal of heat and carbon dioxide.
(Materials to Avoid)
CAUTION! IRRITANT.
Hazardous Freshly formed Zinc Oxide dust may cause 鈥渂rass chills鈥? or 鈥渂rass
HARMFUL IF SWALLOWED.
Decomposition Products founders ague鈥?; may damage mucous membranes.
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) Loses CO2 at 300掳C (572掳F) 4.42-4.45
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) Decomposes. Non-volatile (NA).
by Volume (%) X
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) Negligible as solid. Non-volatile (NA).
=1)
(
Steps to be taken in case
Vapor Density (Air=1) Recover for use if not contaminated. Wear protective safety equipment
Data not listed.
material is released or spilled and use adequate ventilation. Avoid making dust. Sweep up and place
Solubility in Water Insoluble. in a suitable container for disposal. Flush spill area with water. Do not
allow wash water to pollute water ways and streams.
Appearance & Odor White crystalline powder; no odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dispose of in an approved chemical landfill or contract with a licensed waste
% by Volume
(Method Used) Non-flammable (NA). NA -------- --------
disposal service.
Extinguisher
SECTION VIII SPECIAL PROTECTION INFORMATION
Use any media suitable for extinguishing supporting fire.
Media
None needed in normal laboratory handling. If dusty conditions prevail, work in ventilation
Respiration Protection
hood or wear a NIOSH/MSHA-approved dust mask or respirator.
(Specify Type)
SPECIAL FIREFIGHTING
Local Exhaust Special
Yes. No.
PROCEDURES Ventilation Recommended. No.
Mechanical (General) Other
In fire conditions, wear a NIOSH/MSHA-approved self-contained
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
breathing apparatus. Self-extinguishing.
Other Protective
Lab coat, goggles, eye wash station, proper gloves, ventilation hood.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry place away from acids and acid fumes.
in Handling & Storing
EXPLOSION HAZARDS Wash thoroughly after handling.
Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
Evolves carbon dioxide at 300掳C (572掳F). Self-extinguishing. Fire or
excessive heat may produce hazardous decomposition products as
Avoid contact with eyes or prolonged contact with skin.
dust or fume; can react with acids.
Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date
No. 4 8/18/95 Michael Raszeja MR
Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|