Page 1 of 4
DCT
Diversified Chemical Technologies, Inc.
15477 Woodrow Wilson
Detroit, MI 48238
(313) 867-5444
MATERIAL SAFETY DATA SHEET
Supersedes: 11/14/03 Issue Date: 07/14/05
SECTION I - CHEMICAL PRODUCT
Identity: 130440
Brands: DCT AUTO-DISH DELIMER
Hazard Rating: 3 Health: 3 4=EXTREME
Flammability: 0 3=HIGH
Reactivity: 0 2= MODERATE
1=SLIGHT
Emergency Telephone Number: (800) 424-9300 (24-HR 鈥? CHEMTREC)
SECTION II - COMPOSITION AND INGREDIENTS
Ingredients/Chemical Name: Citric acid and other proprietary ingredients
Hazardous Ingredients as defined by OSHA, 29 CFR 1910.1200.
Common CAS No. Recommended Limits Composition LD50/LC50
Chemical Name
Name Range
-same- 7664-38-2 OSHA PEL: 1 mg/m3 10 鈥? 20
TS 1072 鈥? Trade
3 mg/m3 STEL
Secret
30 鈥? 40
Citric acid,
anhydrous
1-5
TS 1020 鈥? Trade
Secret
SECTION III - HAZARDS IDENTIFICATION
Health Hazards (Acute and Chronic):
Ingestion: Can be harmful if swallowed.
Eye Contact: Can cause chemical burns upon direct contact. May cause eye irritation with prolonged,
repeated exposures.
Inhalation May cause irritation upon prolonged, repeated exposures.
Skin: Can cause chemical burns upon direct contact. May cause skin irritation with prolonged,
repeated exposures.
PDF created with FinePrint pdfFactory trial version www.pdffactory.com
DCT AUTO-DISH DELIMER MSDS (continued) Page 2 of 4
SECTION IV - FIRST AID INFORMATION
Emergency and First Aid Procedures:
Ingestion: Drink large quantities of water or milk. Do not induce vomiting. Seek prompt medical
attention.
Eye Contact: Hold eyelids open and flush thoroughly with plenty of water for at least 15 minutes. Seek
prompt medical attention.
Skin: Wash skin thoroughly with soap and water. If chemical burns exist or irritation persists,
seek prompt medical attention. If spilled on clothing, change clothes.
Inhalation: For accidental, high level inhalation, remove to fresh air. Get medical attention if irritation
persists.
Other: None
SECTION V - FIRE FIGHTING INFORMATION
Flash Point (Method Used): >200 F (PMCC) Explosive Limits: LEL: N/K UEL: N/K
Extinguishing Media: Use CO2, water, or dry chemical.
Special Fire Fighting Procedures: Firefighters should wear structural firefighting gear and SCBA if exposed to
vapors or products of combustion
Unusual Fire Hazards: Keep sides of containers cool with water spray until well after fire is out.
SECTION VI - ACCIDENTAL RELEASE MEASURES
Personal Precautions: Avoid contact with eyes.Wear personal protective equipment if prolonged exposure
and/or splashing is likely.
Environmental Precautions: DISPOSAL IS TO BE PERFORMED IN COMPLIANCE WITH ALL FEDERAL,
STATE AND LOCAL REGULATIONS.
Steps To Be Taken in Case Large Quantities of Material are Released or Spilled: Contain spill. Prevent
spills from reaching waterways or sewers untreated. Read 鈥淲aste Disposal Method鈥? below for further
information.
SECTION VII - HANDLING AND STORAGE
Precautions To Be Taken in Handling and Storing: Avoid contact eye and skin contact. Store in dry, cool,
well-ventilated area away from incompatibles. Keep container sealed when not in use. Wash thoroughly after
handling material. Avoid aerosol formation.
Other Precautions: For Institutional Use Only. Keep out of reach of children.
SECTION VIII 鈥? EXPOSURE CONTROLS, PERSONAL PROTECTION
Respiratory Protection (Specify Type): None required with normal use.
Ventilation General
Eye Protection: If splashing or heavy misting is likely, goggles or faceshield may be needed.
Protective Gloves: Protective gloves (neoprene preferred) required if prolonged, direct contact is anticipated.
Other Protective Equipment: Suitable eyewash facilities
2
PDF created with FinePrint pdfFactory trial version www.pdffactory.com
DCT AUTO-DISH DELIMER MSDS (Continued) Page 3 of 4
SECTION IX 鈥? PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point 掳F: NAV Specific Gravity (H2O=1): 1.23
Vapor Pressure (mm Hg): N/K Percent Volatile by Volume (%): N/K
Vapor Density (Air=1): N/K Evaporation Rate (nBuOAc=1): N/K
Appearance and Odor: Clear green liquid with light pH (F.S.): 1.25 鈥? 2.0
acidic odor
Coefficient of Water/Oil Distribution: N/K Solubility in Water: Complete
SECTION X 鈥? STABILITY AND REACTIVITY
Possible Hazardous Reactions/Conditions: None Known
Conditions to Avoid: None Known
Materials to Avoid: Strong oxidizers and strong bases
Hazardous Decomposition Products: acrid smoke/irritating fumes
Other Recommendations: None
Stability: Stable
Hazardous Polymerization: Will Not Occur
SECTION XI - TOXICOLOGICAL INFORMATION
NAV
SECTION XII - ECOLOGICAL INFORMATION
NAV
SECTION XIII - DISPOSAL CONSIDERATIONS
Waste Disposal Method: Small quantities: Contain spill. Any spillage should be cleaned up immediately.
Where possible, flush area with plenty of water to drain; otherwise, use inert, non-combustible abosrbent and
sweep up. Follow all local ordinances. Large Spills (i.e. 50 gallons or more): RCRA-corrosive (D002). Contain,
collect, and hold for disposal Do not allow to enter sewers or waterways untreated. DISPOSAL IS TO BE
PERFORMED IN COMPLIANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS.
SECTION XIV - TRANSPORT INFORMATION
DOT Classification: Corrosive liquids, n.o.s. (contains citric acid and other proprietary acidic ingredients), 8,
UN1760, PG II, Ltd Qty
SECTION XV - ADDITIONAL REGULATORY INFORMATION
All components are listed on the US TSCA Inventory.
All ingredients are listed on the Canadian DSL Inventory. The Canadian WHMIS classification is: Class D2B
(Stylized T) and E (Corrosive Material)
3
PDF created with FinePrint pdfFactory trial version www.pdffactory.com
DCT AUTO-DISH DELIMER MSDS (Continued) Page 4 of 4
SECTION XVI - OTHER INFORMATION
*N/A. - Not Applicable *N/K. - Not Known F.S. 鈥? Full Strength
The submission of this MSDS may be required by law, but this is not an assertion that the substance is hazardous
when used in accordance with proper safety practices and normal handling procedures. Data supplied is for use
only in connection with occupational safety and health.
The information contained herein has been compiled from sources considered by Diversified Chemical
Technologies, Inc. to be dependable and is accurate to the best of the Company鈥檚 knowledge. The information
relates to the specific material designated herein, and does not relate to the use in combination with any other
material or any other process. Diversified Chemical Technologies, Inc. assumes no responsibility for injury to the
recipient or third persons, for any damage to any property resulting from misuse of the controlled product.
4
PDF created with FinePrint pdfFactory trial version www.pdffactory.com
|