Page 1 of 4
DCT Diversified Chemical Technologies, Inc.
15477 Woodrow Wilson
Detroit, MI 48238
(313) 867-5444
MATERIAL SAFETY DATA SHEET
Issue Date: 10/20/06
Supersedes: 07/12/05
SECTION I - CHEMICAL PRODUCT
Identity: 130350
Brands: DCT Auto-Dish Sanitizer
Hazard Rating: 3 Health: 3 4=EXTREME
Flammability: 0 3=HIGH
Reactivity: 2 2= MODERATE
1=SLIGHT
Emergency Telephone Number: 1-800- 424-9300 (24-HR 鈥? CHEMTREC)
SECTION II - COMPOSITION AND INGREDIENTS
Ingredients/Chemical Name: Sodium hypochlorite, sodium chloride and other proprietary ingredients
Hazardous Ingredients as defined by OSHA, 29 CFR 1910.1200.
Common CAS No. Recommended Limits Composition LD50/LC50
Chemical
Name Range
Name
None established
Sodium -same- 7681-52-9 1 鈥? 10
hypochlorite
None established
Sodium - same- 7647-14-5 1-5
chloride
SECTION III - HAZARDS IDENTIFICATION
Health Hazards (Acute and Chronic):
Ingestion: Harmful if ingested.
Inhalation: Harmful if inhaled. Inhalation can be irritating to nose, mouth, throat, and lungs.
Eye Contact: Severe irritation and/or chemical burns upon direct exposure.
Skin: Severe irritation and/or chemical burns upon direct exposure.
SECTION IV - FIRST AID INFORMATION
Emergency and First Aid Procedures:
Ingestion: Seek prompt medical attention. Do NOT induce vomiting.
Inhalation: Remove to fresh air. Seek prompt medical attention if irritation or burns exist.
Eye Contact: Flush with large amounts of water for at least 15 minutes. Seek prompt medical attention.
Skin: Flush with large amounts of water for at least 15 minutes. Seek prompt medical attention.
Other: N/A
DCT AUTO-DISH SANITIZER MSDS (Continued) Page 2 of 4
SECTION V - FIRE FIGHTING INFORMATION
Flash Point (Method Used): NAV (PMCC) Explosive Limits: LEL: N/A UEL: N/A
Extinguishing Media: CO2, water, foam or dry chemical
Special Fire Fighting Procedures: Fire fighters should wear structural firefighting gear and SCBA if exposed to
vapors or products of combustion.
Unusual Fire Hazards: In case of fire, hazardous concentrations of chlorine may be formed.
SECTION VI - ACCIDENTAL RELEASE MEASURES
Personal Precautions: Avoid direct contact with product.
Environmental Precautions: DISPOSAL IS TO BE PERFORMED IN COMPLIANCE WITH ALL FEDERAL,
STATE AND LOCAL REGULATIONS.
Steps To Be Taken in Case Large Quantities of Material are Released or Spilled: Put on safety glasses or
goggles and chemical-resistant gloves. Contain spill. Use water spray to dilute and wash away spills. Follow
local ordinances. Sorbents may be used.
SECTION VII - HANDLING AND STORAGE
Precautions To Be Taken in Handling and Storing: Avoid eye and skin contact. Store in cool, dry, well-
ventilated area away from open flame, heat, ignition sources or other incompatibles.
Other Precautions: Keep out of reach of children. For institutional use only.
SECTION VIII - EXPOSURE CONTROLS, PERSONAL PROTECTION
Respiratory Protection (Specify Type): None required with normal use.
Ventilation General
Eye Protection: If splashing is likely, goggles or faceshield may be needed.
Protective Gloves: May be necessary with extended contact.
Other Protective Equipment: suitable eyewash facilities.
SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point 掳F: Decomposes on heating Specific Gravity (H2O=1): 1.09 鈥? 1.11
Vapor Pressure (mm Hg): N/K Percent Volatile by Volume (%): 87.5 鈥? 94.5%
Vapor Density (Air=1): N/K Evaporation Rate (nBuOAc=1): Unknown
Appearance and Odor: Clear greenish-yellow liquid Freezing Point: N/A
with chlorine odor. pH (FS): 12.4 鈥? 12.8
Coefficient of Water/Oil Disitribution: N/A Solubility in Water: Complete
2
DCT AUTO-DISH SANITIZER MSDS (Continued) Page 3 of 4
SECTION X - STABILITY AND REACTIVITY
Possible Hazardous Reactions/Conditions/By Products: None known
Conditions to Avoid: None
Materials to Avoid: None
Hazardous Decomposition Products: None known
Other Recommendations: None
Stability: Stable
Hazardous Polymerization: Will Not Occur
SECTION XI - TOXICOLOGICAL INFORMATION
LD50 (rats oral): N/A
ED50: N/A
Sodium hypochlorite has been shown to produce damage to genetic material when tested in vitro. Studies in vivo
have shown no evidence of mutagenic potential for this material. Chemicals potent with biocidal activity,
typical hypochlorite compounds, may comprise the integrity of many of the treated cells which remain viable
during an in vitro assay. It is judged that the risk of genetic damage is insignificant for sodium hypochlorite
because of its biocidal activity, lack of mutogencicity in vivo, and failure to produce a carcinogenic response.
SECTION XII - ECOLOGICAL INFORMATION
N/A
SECTION XIII - DISPOSAL CONSIDERATIONS
Waste Disposal Method: DISPOSAL IS TO BE PERFORMED IN COMPLIANCE WITH FEDERAL, STATE
AND LOCAL REGULATIONS.
SECTION XIV - TRANSPORT INFORMATION
DOT Classification: This material is regulated by the U.S. Department of Transportation.
For finished packaged product transported by ground: Hypochlorite solutions with more than 5 percent
but less than 16 percent available chloride, 8, UN 1791, PG III, Ltd Qty, RQ 100 lb
For finished packaged product transported by sea: Hypochlorite solutions with more than 5 percent but
less than 16 percent available chloride, 8, UN 1791, PG III, Ltd Qty, RQ 100 lb
For finished packaged product transported by air: Hypochlorite solutions with more than 5 percent but less
than 16 percent available chloride, 8, UN 1791, PG III, Ltd Qty, RQ 100 lb
SECTION XV - ADDITIONAL REGULATORY INFORMATION
All components are listed on the US TSCA Inventory. .
All ingredients are listed on the Canadian DSL Inventory. The Canadian WHMIS classification is: Class E
(Corrosive Material).
3
DCT AUTO-DISH SANITIZER MSDS (Continued) Page 4 of 4
SECTION XVI - OTHER INFORMATION
*N/A. - Not Applicable *N/K. - Not Known
The submission of this MSDS may be required by law, but this is not an assertion that the substance is hazardous
when used in accordance with proper safety practices and normal handling procedures. Data supplied is for use
only in connection with occupational safety and health.
The information contained herein has been compiled from sources considered by Procter & Gamble to be
dependable and is accurate to the best of the Company鈥檚 knowledge. The information relates to the specific
material designated herein, and does not relate to the use in combination with any other material or any other
process. Procter & Gamble assumed no responsibility for injury to the recipient or third persons, for any damage to
any property resulting from misuse of the controlled product.
4
|