Material Safety Data Sheet HMIS铮?
May be used to comply with OSHA's HEALTH 1 REACTIVITY 0
Hazard Communication Standard,
29 CFR 1910.1200. Standard must be PERSONAL PROTECTION
FLAMMABILITY 0 B
consulted for specific requirements.
Note: Blank spaces are not permitted. If any item is not applicable, or no
Identity (As Used on Label and List) EPA Reg. No. 11694-88 information is available, the space must be marked to indicate that.
08032, 08025, 08001, 08005, 08094, 08035, 08055
Do-It All Germicidal Foaming Cleaner
SECTION I
Manufacturer's Name Emergency Telephone Number
ITW Dymon 1-800-535-5053
Address (Number, Street, City, State, and ZIP Code) Telephone Number for Information
805 East Old 56 Highway 1-913-397-9889
Date Prepared
Olathe, Kansas 66061 April 3, 2000
Signature of Preparer (Optional)
Regulatory Dept.
SECTION II - Hazardous Ingredients/Identity
Information
Hazardous Components (Specific Other Limits
Chemical Identity, Common Name(s)) CAS No. OSHA PEL ACGIH-TLV Recommended %(Opt.)
* 2-Butoxyethanol (skin designation) 111-76-2 50 ppm 25 ppm 0.5 鈥? 2 %
<1%
n-Alkyl dimethyl benzyl ammonium chlorides 68391-01-5 None estab. None estab.
n-Alkyl dimethyl ethylbenzyl ammonium chlorides <1%
68956-79-6 None estab. None estab.
* This product contains 2-Butoxyethanol (a glycol ether compound) which is listed and may require reporting under SARA Title
III Sec. 313 if used over the threshold reporting quantity. This information must be included in all MSDSs that are copied and
distributed for this material.
TSCA: All ingredients are on the TSCA inventory or are not required to be listed on the TSCA inventory.
Any substance listed as hazardous by the States of California, Florida, Illinois, Michigan, New Jersey, Ohio, Pennsylvania or
Texas is described above if known present in regulated concentrations.
SECTION III Physical/Chemical Characteristics
Boiling Point Specific Gravity (H 2 O = 1)
212 o F 1.034
@70o F
70o
Vapor Pressure (mm Hg @ F) Not Melting Point
Applicable No Data
Vapor Density (AIR = 1) Greater Evaporation Rate (Ethyl Ether = 1)
than one (1) No Data
Solubility in Water pH
Complete 11.0 + 0.5
Appearance and Odor - Clear light amber liquid with a lemon scent.
SECTION IV - Fire and Explosion Hazard Data
Flash Point (Method Used) Flammable Limits LEL UEL
None to boiling point (PMCC - est.) No Data No Data No Data
Extinguishing Media - Not usually necessary as this product does not readily support combustion. Use an extinguishing agent
applicable to the fire's fuel source (i.e. - carbon dioxide, dry chemical, foam, fog, and water spray).
Special Fire Fighting Procedures - Keep containers cool and vapors down with water spray. Prevent runoff from entering sewers
and public waterways. Wear SCBA in chemical fires.
Unusual Fire and Explosion Hazards - None known.
08032, 08025, 08001, 08005, 08094, 08035, 08055 April 3,
SECTION V - Reactivity Data
Stability Unstable Conditions to Avoid - None known
Stable X
Incompatibility (Materials to Avoid) - Strong acids and oxidizers.
Hazardous Decomposition or Byproducts - Carbon dioxide, carbon monoxide, nitrous oxides, hydrogen chloride, and ammonia.
Hazardous May Occur Conditions to Avoid - None known
Polymerization Will Not Occur X
SECTION VI - Health Hazard Data
Route(s) of Entry Eyes?
Inhalation? Skin? Ingestion?
Yes Yes Yes Yes
Health Hazards (Acute and Chronic) Warning: Causes eye and skin irritation. Harmful if swallowed. Product may be absorbed
through intact skin. May cause irritation to throat and gastrointestinal tract. Use good chemical hygiene practices to avoid these hazards.
Carcinogenicity: NTP? IARC Monographs? OSHA Regulated?
None known. No No No
Signs and Symptoms of Exposure - Redness, tearing, burning of eyes. Redness, drying, cracking of skin. Nausea, vomiting or
diarrhea. Irritation of nose or throat.
Medical Conditions Generally Aggravated by Exposure - Pre-existing skin and lung disorders may be aggravated by
prolonged or repeated occupational overexposures.
Emergency and First Aid Procedures Eyes - Flush with plenty of water for at least 15 minutes. Call a physician.
Ingestion - If swallowed, drink egg whites, gelatin solution or if these are not available, drink large quantities of water. Call a
physician. Inhalation - Get to fresh air. If breathing has stopped, qualified personnel should administer artificial respiration.
Skin - Flush with plenty of water for at least 15 minutes. Remove and wash all contaminated clothing before reuse.
SECTION VII - Precautions for Safe Handling and Use
Steps to be Taken in Case Material is Released or Spilled - Caution: Slip hazard. Small Spill - Pick up on absorbent. Large
spill - Isolate traffic and ventilate area. Wear protective gear as necessary. Dike to prevent spread. Prevent run-off from entering sewers or
public waterways. Vacuum or pick up on absorbent. Put in suitable container.
Waste Disposal Method - Consult local, state, and federal regulations. Do not contaminate water, food or feed by storage or disposal.
Wastes resulting from the use of this product may be disposed of on site or at an approved waste disposal facility. Open dumping is
prohibited. Do not reuse container. Triple rinse (or equivalent). The offer for recycling or reconditioning or puncture and dispose of in a
sanitary landfill, or incineration, or if allowed by state and local authorities, by burning. If burned stay out of smoke.
Precautions to be Taken in Handling and Storing - Do not get in eyes, skin or on clothing. When using spray applicator, direct
spray away from face. Wash thoroughly after handling. Do not swallow. Avoid inhaling mist or vapors.
Other Precautions - Follow label directions carefully. Keep out of reach of children. Keep containers tightly sealed when not in use.
Store containers indoors and in a dry area. Keep from freezing. Use from original container only. Do not contaminate water, food or feed
by use or storage.
SECTION VIII - Control Measures
Respiratory Protection (Specify Type)
Not usually necessary. Use with adequate ventilation. Use NIOSH/MSHA approved respirator if PELs or TLVs are exceeded.
Ventilation Local Exhaust Acceptable Special None
Mechanical (General) Yes Other None
Protective Gloves - As necessary to avoid Eye Protection -
contact with product. Use impervious type. Yes, approved glasses or goggles. (ANSI Z87)
Other Protective Clothing or Equipment - Not usually necessary. If direct contact possible, use apron, boots, etc. For HIV
disinfection procedures, follow label instructions carefully.
Work/Hygienic Practices - Normal. Wash hands after use and before eating, drinking, smoking, using restrooms, etc.
WARNING! The use of this product is beyond the control of the manufacturer; therefore, no guarantee, expressed or implied, is made as to the effects of such or the results to be obtained if not used in accordance with directions or established safe practice. The user must assume all responsibility, including injury or damage,
resulting from its misuse as such, or in combination with other materials. The manufacturer warrants only that this product meets the manufacturer's specifications for such product. THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, AS TO DESCRIPTION , QUALITY,
MERCHANTABILITY, FITNESS FOR ANY PARTICULAR PURPOSE, PRODUCTIVENESS, OR ANY OTHER MATTER, OF THIS PRODUCT. THE MANUFACTURER SHALL BE IN NO WAY RESPONSIBLE FOR THE PROPER USE OF THIS PRODUCT. The sole and exclusive remedy against the manufacturer for
breach of warranty shall be reimbursement of the purchase price of the product in the event that a defective condition of the product shall be found to exist. NO OTHER REMEDY (INCLUDING BUT NOT LIMITED TO INCIDENTAL OR CONSEQUENTIAL DAMAGES FOR INJURY TO PERSON OR PROPERTY OR ANY
OTHER INCIDENTAL OR CONSEQUENTIAL LOSS) SHALL BE AVAILABLE.
|