MATERIAL SAFETY DATA SHEET (MSDS)
TRADE NAME: ENDGERM RE CONCENTRATE #EPC 88
===============================================================================
SECTION I - IDENTIFICATION
===============================================================================
COMPANY NAME............................EPIC INDUSTRIES
COMPANY ADDRESS......................1007 JERSEY AVENUE
.............................................................NEW BRUNSWICK, NJ 08901
TELEPHONE NUMBER...................1 (800) 221-3742
EMERGENCY PHONE #..................1 (800) 255-3942 CHEM-TEL, INC.
PRODUCT HAZARD RATINGS: HEALTH=0, FIRE=0, REACTIVITY=0
PROTECTIVE EQUIPMENT: G(HMIG)
RATINGS LEGEND: 4=EXTREME, 3=SERIOUS, 2=MODERATE, 1=SLIGHT, 0=MINIMAL
===============================================================================
SECTION II - HAZARDOUS INGREDIENTS
===============================================================================
HAZARDOUS COMPONENTS HAZARDOUS% TLV(UNITS) PEL CAS #
ALKYLDIMETHYLBENZYL 5-15 NE NE 8001-54-5
AMMONIUM CHLORIDE
ETHOXYLATED ALKYL PHENOL <10 NE NE 9036-19-5
NON HAZARDOUS INGREDIENTS BAL.
UNIDENTIFIED INGREDIENTS ARE NOT CONSIDERED HAZARDOUS UNDER THE FEDERAL
HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
===============================================================================
SECTION III - PHYSICAL DATA
===============================================================================
BOILING POINT (F)....................212 FREEZING POINT (F)....................NA
VOLATILITY/VOL (%)...............>80 VAPOR PRESSURE..........................<18
SOLUBILITY IN H2O............COMPLETE SPECIFIC GRAVITY (H2O=1) 1.43
EVAPORATION RATE (BuAc=1) <1 pH................................................13.0
APPEARANCE/ODOR....................CLEAR, RED LIQUID; SLIGHT ODOR.
SECTION IV - FIRE AND HAZARD DATA
===============================================================================
FLASH POINT.......NONE LOWER FLAME LIMIT........NA HIGHER FLAME LIMIT......NA
EXTINGUISH MEDIA...................USE MEDIA SUITABLE FOR SURROUNDING MATERIALS.
FOR FIRE........................................NO SPECIAL PROCEDURES REQUIRED.
UNUSUAL FIRE HAZARD............ NONE KNOWN.
===============================================================================
SECTION V - HEALTH HAZARD DATA
===============================================================================
OVEREXPOSURE EFFECTS..............INHALATION OF MIST MAY CAUSE RESPIRATORY
IRRITATION; POSSIBLE SKIN IRRITATION. PROLONGED OR REPEATED CONTACT MAY CAUSE
BURNS. LIQUID IN EYE MAY CAUSE BURNING, IRRITATION AND DAMAGE.
FIRST AID PROCEDURES:
EYES: IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15
MINUTES WHILE HOLDING THE EYELIDS OPEN. GET PROMPT MEDICAL ATTENTION.
SKIN: REMOVE CONTAMINATED CLOTHING AND WASH AFFECTED AREA WITH LARGE
AMOUNTS OF WATER. GET MEDICAL HELP IF IRRITATION PERSISTS. WASH CLOTHING
BEFORE RE-USE.
INHALATION: MOVE VICTIM TO FRESH AIR. GET MEDICAL HELP IF IRRITATION PERSISTS.
INGESTION: CONTACT LOCAL POISON CENTER OR PHYSICIAN IMMEDIATELY!!
PAGE 2 ENDGERM RE CONCENTRATE #EPC 88
SECTION VI - REACTIVITY DATA
===============================================================================
STABILITY: NORMALLY STABLE
INCOMPATIBLE MATERIALS: STRONG ACIDS
DECOMPOSITION PRODUCTS: AMMONIA, CARBON MONOXIDE , CARBON DIOXIDE.
SECTION VII - SPILL OR LEAK PROCEDURE
===============================================================================
PROCEDURES: WEAR PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION VIII). CAREFULLY
CLEAN UP WITH ABSORBENT MATERIAL.
WASTE DISPOSAL METHOD: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.
===============================================================================
SECTION VIII - SPECIAL PROTECTION
===============================================================================
RESPIRATORY PROTECTION: NOT NORMALLY REQUIRED. IF TLV IS EXCEEDED, OR FOR
SYMPTOMS OF OVEREXPOSURE , WEAR NIOSH APPROVED DUST/MIST RESPIRATOR.
EYEWEAR: IF POTENTIAL FOR EYE CONTACT EXISTS, WEAR CHEMICAL GOGGLES OR FACE
SHIELD.
VENTILATION: LOCAL EXHAUST MAY BE NECESSARY UNDER SOME HANDLING/USE
CONDITIONS. SPECIFIC NEEDS SHOULD BE ADDRESSED BY SUPERVISORY OR
HEALTH/SAFETY PERSONNEL.
CLOTHING/PROTECTIVE GLOVES: WEAR NEOPRENE OR OTHER CHEMICAL RESISTANT
GLOVES AND CLOTHING AS NEEDED TO PREVENT SKIN CONTACT.
SECTION IX - SPECIAL PRECAUTIONS
===============================================================================
CORROSIVE. STORE IN CLOSED CONTAINER.
.........................................................................................................................................................................
APPROVAL LAWRENCE Y. LIOU TECHNICAL DIRECTOR 10/29/05
NAME TITLE DATE
************************************************************************************************************************
THE INFORMATION CONTAINED HEREIN HAS BEEN DEVELOPED BASED UPON CURRENT
AVAILABLE SCIENTIFIC DATA. NEW INFORMATION MAY BE DEVELOPED FROM TIME TO TIME
WHICH MAY RENDER THE CONCLUSION OF THIS REPORT OBSOLETE. THEREFORE, NO
WARRANTY IS EXTENDED AS TO APPLICABILITY OF THIS INFORMATION TO THE USERS
INTENDED PURPOSE OR FOR THE CONSEQUENCES OF ITS USE OR MISUSE.
NA - NOT APPLICABLE NE - NOT ESTABLISHED UN - UNAVAILABLE
|