MATERIAL SAFETY DATA SHEET
1 CHEMICAL PRODUCT & COMPANY IDENTIFICATION
Trade Name ANTI CORROSION SPRAY
110
MSDS Number
- -0
CAS Number
ITW TRANS TECH
Supplier
475 N. GARY AVENUE
CAROL STREAM, IL 60188 USA
Telephone Numbers - 24 Hour Emergency Assistance
Emergency (352)323-3500
Telephone Numbers - General Assistance
Information (630)752-4000
2 COMPOSITION / INFORMATION ON INGREDIENTS
Concentration
Ingredient Name CAS Number Exposure Limits / Health Hazards
MINERAL SPIRITS 64742-88-7 24 % ACGIH TLV: 100 ppm
OSHA PELs: 100 ppm
MINERAL SPIRITS 140 FLASH 64742-88-7 35 %
PARAFFINIC MINERAL OIL 8042-47-5 10 % OSHA PEL: 5mg/m3 ACGIH TLV:
5mg/m3 as Mist
2-METHOXYMETHYLETHOXYPROPANO 34590-94-8 3% ACGIH TLV: 100 ppm (skin)
ACGIH TLV: 150 ppm (skin) STEL:
OSHA PELs: 100 ppm (skin)
OSHA PELs: 150 ppm (skin) STEL:
CARBON DIOXIDE 124-38-9 2% ACGIH TLV: 5000 ppm OSHA
PELs: 5000 ppm
3 HAZARDS IDENTIFICATION
Potential Health Effects, Skin
May cause irritation upon prolonged contact. Redness and itching or burning sensation may indicate eye or excessive skin
exposure.
Potential Health Effects, Eye
Irritating to eyes. Redness and itching or burning sensation may indicate eye or excessive skin exposure.
Potential Health Effects, Inhalation
Irritation of the upper respiratory system. May cause nervous system depression.
Potential Health Effects, Ingestion
NA
Signs & Symptoms of Short-Term (Acute) Exposure
Headache, dizziness, nausea, and loss of coordination are indications of excessive exposure to vapors or spray mists.
Pre-existing lung problems are aggravated by exposure. Extreme overexposure may result in unconsciousness and
possibly death.
Printed On 15-Sep-05
ND = No Data NA = Not Applicable NI = Not Indicated
110 ANTI CORROSION SPRAY
Material Id Trade Name 1/ 5
Effects of Long-Term (Chronic) Exposure
Repeated overexposure may cause harm to the peripheral nervous system.
4 FIRST AID MEASURES
Skin
Remove contaminated clothing and launder before reuse. Wash affected areas with soap and water.
Eye
Flush with large quantities of water for at least 15 minutes. Consult a physician.
Inhalation
Remove to fresh air. If breathing is difficult: artificial respiration. Keep person warm and at rest.
Ingestion
Do not induce vomiting. Seek medical advice immediately.
Medical Conditions Aggravated by Exposure
None generally recognized.
5 FIRE FIGHTING MEASURES
Extinguishing Media
Foam, carbon dioxide, dry chemical powder
Basic Fire Fighting Procedures
Aerosol cans may explode if heated above 120潞F. Full protective equipment including self contained breathing apparatus
should be used. Water-spray may be ineffective. If water is used, fog nozzles are preferable. Water may be used to cool
closed containers to prevent pressure build-up and possible autoignation or explosion when exposed to extreme heat.
Unusual Fire & Explosion Hazards
Closed container may explode when exposed to extreme heat. Application to hot surfaces requires special precautions.
During emergency conditions overexposure to decomposition products may cause a health hazard. Symptoms may not be
immediately apparent. Obtain medical attention.
121 潞F
Flash Point
0.9 - 14
AutoIgnition Temperature
6 ACCIDENTAL RELEASE MEASURES
Spill or Leak Procedure
Remove sources of ignition. Ventilate area. Remove with liquid binding material. Environmental precautions: prevent spills
from entering storm sewers or drains and contact with soil.
7 HANDLING & STORAGE
Handling
Use only in well ventilated areas. Keep away from heat, sparks and open flames. Consult NFPA Code. Use approved
Bonding and Grounding procedures. Contents under pressure, do not puncture, incinerate, or expose to temperature above
120F. Heat from sunlight, radiators, stoves, hot water and other heat sources could cause container to burst. Do not take
internally. Keep out of reach of children. Wash after handling. Avoid breathing vapors or mist.
Storage
Keep away from heat and open flame. Store at room temperature in tightly closed containers. Do not puncture, incinerate,
or expose to temperature above 120F潞.
Ventilation
Local exhaust preferable. General exhaust acceptable if the expsoure to materials in section ii is maintained below
applicable exposure limits. Refer to osha standards 1910.94, 1910.107, 1910.108.
Printed On 15-Sep-05
ND = No Data NA = Not Applicable NI = Not Indicated
110 ANTI CORROSION SPRAY
Material Id Trade Name 2/ 5
8 EXPOSURE CONTROLS / PERSONAL PROTECTION
Engineering Controls
Adequate to prevent accumulation of vapors. Use mechanical means if necessary to maintain levels below the exposure
limits. If working in a confined space, follow applicable OSHA regulations
Eye Protection: Personal Protection Equipments (PPE)
Wear safety spectacles with unpreforated side shields.
Skin Protection: Personal Protection Equipments (PPE)
Avoid contact with skin, eyes and clothing. For long or repeated contact, wear chemical resistant gloves.
Respiratory Protection: Personal Protection Equipments (PPE)
Avoid breathing vapors. If personal exposure cannot be controlled below applicable limits by ventilation, wear a properly
fitted organic vapor/particulate respirator approved by NIOSH/MSHA for protection against materials in Section 2.
General
Intentional misuse by deliberately concentrating and inhaling the contents can be harmful or fatal.
9 PHYSICAL & CHEMICAL PROPERTIES
Odor and Appearance
Dark viscous liquid, petroleum odor.
416 潞F
Boiling Point
0.88
Specific Gravity
N.A.
Melting Point
71
Percent Volatile
Faster than ether
Evaporation Rate
Heavier than air
Vapor Density
N.A.
Solubility In Water
62.2
Volatile Organic
NA
PH Value
10 STABILITY & REACTIVITY
Stability/Incompatibility
Stable
Conditions to avoid:
None known.
Incompatability:
None known.
Hazardous Reactions/Decomposition Products
In case of fire, mainly carbon dioxide, carbon monoxide and soot may be formed.
Hazardous Polymerization
Will not occur.
11 TOXICOLOGICAL INFORMATION
Routes of Exposure
Inhalation, ingestion, skin and eye contact.
Printed On 15-Sep-05
ND = No Data NA = Not Applicable NI = Not Indicated
110 ANTI CORROSION SPRAY
Material Id Trade Name 3/ 5
Carcinogenicity
No ingredient in this product is an IARC, NTP or OSHA listed carcinogen.
Sensitization to Material
Prolonged overexposure to solvent ingredients in Section 2 may cause adverse effects to the liver and urinary systems.
Reports have associated repeated and prolonged overexposure to solvents with permanent brain and nervous system
damage.
12 ECOLOGICAL INFORMATION
EcoToxicological Information
NA
Chemical Fate Information
NA
13 DISPOSAL CONSIDERATIONS
Waste Disposal
Waste from this product may be hazardous as defined under the Resource Conservation and Recovery Act (RCRA) 40
CFR 261. Waste must be tested for ignitability to determine the applicable EPA hazardous waste numbers. Do not
incinerate. Depressurize container. Dispose of in accordance with Federal, State/Provincial, and Local regulations
regarding pollution.
14 TRANSPORT INFORMATION
Department of Transportation (DOT) Requirements:
General Transportation Information for Bulk Shipments
Proper Shipping Name Paint related material
UN/NA Code 1263
15 REGULATORY INFORMATION
Federal Regulations
SARA 313 (40 CFR 372.65C) SUPPLIER NOTIFICATION
No ingredients in this product are subject to SARA 313 (40 CFR 372.65C) Supplier Notification.
All chemicals in this product are listed, or are exempt from listing on the TSCA Inventory.
State Regulations
WARNING: This material contains a chemical known to the State of California to cause cancer and birth defects or other
reproductive harm.
NFPA Ratings
Health Flammability Reactivity Special Hazards
HMIS Ratings
Health 2 Flammability 2 Reactivity 0 Personal Prot. Equip. B
Following ingredients of this product are listed in SARA313
SARA Listed Ingredient Name CAS Number Maximum %
N-HEXANE 110-54-3
Listed on the following Regulatory List(s)
SARA 313
16 OTHER INFORMATION
Disclaimer
The information and recommendations contained herein are believed to be reliable and accurate based on the data
available to us, however we make no warranty, expressed or implied, regarding the accuracy of this data or the results
obtained from the use of this product.
Printed On 15-Sep-05
ND = No Data NA = Not Applicable NI = Not Indicated
110 ANTI CORROSION SPRAY
Material Id Trade Name 4/ 5
Miscellaneous
This product has been classified in accordance with the hazard criteria of the Canadian Controlled Products Regulations
(CPR) and the MSDS contains all of the information required by the CPR.
9/15/2005 7/1/2003
Replaces Sheet Dated
Completed On
Completed By
Printed On 15-Sep-05
ND = No Data NA = Not Applicable NI = Not Indicated
110 ANTI CORROSION SPRAY
Material Id Trade Name 5/ 5
|