MATERIAL SAFETY DATA SHEET
1 CHEMICAL PRODUCT & COMPANY IDENTIFICATION
Trade Name FLOWING AGENT VL
37
MSDS Number
- -0
CAS Number
TRANS TECH AMERICA, INC.
Supplier
475 N. GARY AVENUE
CAROL STREAM, IL 60188 USA
Telephone Numbers - 24 Hour Emergency Assistance
Emergency (352)323-3500
Telephone Numbers - General Assistance
Information (630)752-4000
2 COMPOSITION / INFORMATION ON INGREDIENTS
Concentration
Ingredient Name CAS Number Exposure Limits / Health Hazards
NAPHTHA, SOLVENT 100 64742-95-6 40 - 100 % OSHA PEL: 100ppm ACGIH TLV:
125ppm
3 HAZARDS IDENTIFICATION
Emergency Overview
Avoid prolonged contact with skin.
Signs & Symptoms of Short-Term (Acute) Exposure
Dizzy feeling, irritation of mucous membranes.
Effects of Long-Term (Chronic) Exposure
The effects of excessive, long-term exposure to this product have not been fully investigated.
4 FIRST AID MEASURES
Medical Conditions Aggravated by Exposure
ND
5 FIRE FIGHTING MEASURES
Extinguishing Media
Chemical powder, carbonic acid - co2, foam.
Basic Fire Fighting Procedures
Water spray may be ineffective. For extinguishing larger fires or inside buildings an independent self-contained breathing
apparatus is recommended to protect fire fighters from any hazardous combustion products.
Unusual Fire & Explosion Hazards
Water may be used to cook endangered containers. Keep containers tightly closed.
Printed On 31-Mar-03
ND = No Data NA = Not Applicable NI = Not Indicated
37 FLOWING AGENT VL
Material Id Trade Name 1/ 3
45 C
Flash Point
0.8
Flammability Limits in Air, Lower, % by Volume
6 ACCIDENTAL RELEASE MEASURES
Spill or Leak Procedure
Take up with liquid binding materials, such as vermiculite. Take the material in closed containers to the responsible
authority for elimination.
7 HANDLING & STORAGE
Handling
NI
Storage
Do not store above +50C. Keep tightly closed. Store containers away from heat in a cool ventilated place. No smoking.
Ventilation
Local exhaust: yes mechanical (general): yes
8 EXPOSURE CONTROLS / PERSONAL PROTECTION
Eye Protection: Personal Protection Equipments (PPE)
When handling with thinner, use splash goggles. Use protective cream where skin contact is likely. Remove and wash
contaminated clothing before re-use. Dont eat and drink at the working place. When using, do not eat, drink or smoke.
Skin Protection: Personal Protection Equipments (PPE)
Required for prolonged and repeated contact. Use neoprene gloves to prevent skin contact.
9 PHYSICAL & CHEMICAL PROPERTIES
Odor and Appearance
Clear liquid with odor of organic solvents
160 C
Boiling Point
0.9
Specific Gravity
NI
Melting Point
6.76 lbs. per gallon
Percent Volatile
5 mbar 20C
Vapor Pressure
NI
Evaporation Rate
>1
Vapor Density
Not soluable
Solubility In Water
10 STABILITY & REACTIVITY
Stability/Incompatibility
Stable Peroxides and other strong oxidizers.
Hazardous Reactions/Decomposition Products
Ni
Hazardous Polymerization
Will not occur.
Printed On 31-Mar-03
ND = No Data NA = Not Applicable NI = Not Indicated
37 FLOWING AGENT VL
Material Id Trade Name 2/ 3
11 TOXICOLOGICAL INFORMATION
Routes of Exposure
Inhalation: remove to fresh air. Restore breathing. Treat symptomatically. Consult a physician. Eyes: splash; flush
immediately with large amounts of water for at least 15 minutes. Take to a physician for medical treatment. Skin: splash;
wash affected areas with soap and water. Remove contaminated clothing. Consult a physician if irritation persists.
Ingestion: do not induce vomiting. Consult a physician or poison control center immediately, treat symptomatically.
12 ECOLOGICAL INFORMATION
13 DISPOSAL CONSIDERATIONS
Waste Disposal
Disposal according to federal, state and local regulations.
14 TRANSPORT INFORMATION
15 REGULATORY INFORMATION
NFPA Ratings
Health Flammability Reactivity Special Hazards
HMIS Ratings
Health 2 Flammability 1 Reactivity 0 Personal Prot. Equip. C
16 OTHER INFORMATION
Disclaimer
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of
Trans Tech America, Inc. The data on this sheet applies only to the specific material designated herein. Trans Tech
America, Inc. assumes no legal responsibility for use of reliance upon this data.
8/18/1998 12/15/1997
Replaces Sheet Dated
Completed On
TRANS TECH AMERICA, INC.
Completed By
Printed On 31-Mar-03
ND = No Data NA = Not Applicable NI = Not Indicated
37 FLOWING AGENT VL
Material Id Trade Name 3/ 3
|