Part Number(s):
MATERIAL SAFETY DATA SHEET 650007
Form WI04-11A Rev. 1
Product Name: Solo Tach Activator Release Date: March 14, 2007
1. Product and Company Identification
Trade Name & Synonyms MSDS Code Number
Solo Tach 庐 Activator Refer to part number
Chemical Name Manufacture / Distributor
NA GAC International Inc.
C.A.S. Number Address
94-36-0 355 Knickerbocker Ave.
Bohemia, NY USA 11716
Grades or Minor Variant Identities Information Telephone Number
NA 1-631-419-1700
Product Use (for Canada) Emergency Telephone Number
NA 1-631-419-1700
2. Composition of Ingredients
Hazardous Components OSHA PEL (mg/m3) ACGIH TLV (mg/m3) C.A.S. Number Exposure Limits %
Benzoyl peroxide 5 5 94-36-0 NA NA
3. Hazard Identification
Emergency Overview
NA
Routes of Signs and Symptoms Single, Repeated, or Severity (Mild, Acute and Chronic Target
Exposure Lifetime Exposure Moderate, Severe) Health Effect(s) Organ(s)
Dusts will irritate the NA NA NA NA
Eye
eyes and prolonged
contact may burn the
eyes. May cause
superficial corneal
opacity and redness and
swelling of the eye
membranes.
Contact with skin can Prolonged or NA NA NA
Skin
cause irritation. repeated contact may
Yes
be more irritating and
cause allergic
reactions, such as
sensitization
dermatitis.
Inhalation of dusts or Overexposure may NA NA NA
Inhalation
solids may irritate entire cause tearing,
Yes
respiratory tract. May salivation, decreased
cause asthmatic effects. respiratory rates,
difficulty in
breathing, and
lethargy.
NA NA NA Chronic effects of exposure: May NA
Ingestion
produce allergic reactions
Yes
characterized by redness, itching,
oozing, crusting, and scaling of the
skin and asthmatic wheezing.
NA NA NA NA NA
Other
Medical Conditions Aggravated by Exposure
None reported.
Carcinogenicity (IARC, NTP)
NTP?: No TARC monographs?: No OSHA regulated?: No
Potential Environmental Effects
Page 1 of 5
Part Number(s):
MATERIAL SAFETY DATA SHEET 650007
Form WI04-11A Rev. 1
Product Name: Solo Tach Activator Release Date: March 14, 2007
4. First Aid Measures
Routes of Exposure First Aid Instructions Immediate Medical Attention Delayed Effects
Immediately flush eyes with lots of NA NA
Eye
running water for 15 minutes,
lifting the upper and lower eyelids
occasionally.
Immediately flush skin with lots of Get immediate medical NA
Skin
running water for 15 minutes. attention if irritation persists
Remove contaminated clothing after washing.
and shoes. Wash before reuse.
Remove to fresh air. Give artificial Get immediate attention. NA
Inhalation
respiration if not breathing.
If conscious, immediately induce Get immediate medical NA
Ingestion
vomiting by giving two glasses of attention. Do not give anything
water and sticking a finger down by mouth to an unconscious or
the throat. convulsing person.
NA NA NA
Other
Note to Physicians (Treatment, Testing, and Monitoring)
NA
5. Fire and Explosion Data
Flashpoint & Method: Flammable (Explosive) Limits in Air Autoignition Temperature Other
掳C / 掳F N/A LEL: N/A UEL: N/A NA
NA
Properties Contributing to Flammability Classification
Flame Propagation or Burning
Fire Intensity Health-2, Flammability-1, Reactivity-1.
NA
NA Specific hazard OXY. NFPA Hazard
classifications.
NFPA- National fire protection
association.
Extinguishing Media Extinguishing Media to Avoid
Do not attempt to fight fire with small extinguisher. Evacuate the area NA
and let automatic sprinklers take over. Fight large fires with water
applied from a safe distance.
Protection and Procedures for Firefighters
Fire fighter should wear self-contained breathing apparatus and full protective clothing. Use water spray to cool nearby containers and structures
exposed to fire. Apply water from a safe distance. Do not permit fire fighting where there is an explosion hazard, such as areas where benzoyl
peroxide is confined or present in large quantities..
Unusual Fire and Explosion Hazards
Benzoyl peroxide will burn with deflagration in the open. May explode when confined. Decomposition vapors are flammable and toxic (Biphenyl
0.2 PPM TLV). In addition to the usual heat and ignition sources, the ignition pf dry benzoyl peroxide may be started by friction impact and
contamination.
Page 2 of 5
Part Number(s):
MATERIAL SAFETY DATA SHEET 650007
Form WI04-11A Rev. 1
Product Name: Solo Tach Activator Release Date: March 14, 2007
6. Accidental Release Measures
Containment Techniques
NA
Spill/Leak Clean-Up Procedures and Equipment
Wear protective equipment including rubber boots, rubber gloves, rubber apron and a self-contained breathing apparatus in the pressure demand
mode or a supplied 鈥揳ir respirator. If the spill or leak is small, a full face piece air-purifying cartridge respirator equipped with particulate filters
may be satisfactory. In any event, always wear eye protection. For small spills, wet down spill then sweep up and dispose of in DOT-approved
waste containers. For large spills, wet down spill and then shovel into DOT-approved waste containers. Use non-sparking tools only. Keep out of
sewers, storm drains, surface waters, and soil. Comply with all applicable governmental regulations on spill reporting and handling and disposal of
waste.
Evacuation Procedures
NA
Special Instructions
NA
Reporting Requirements
NA
7. Handling and Storage
Handling Practices and Warnings
Keep away from heat, sparks, and flames.
Storage Practices and Warnings
(掳C / 掳F). Store in a cool (less than 100掳F), dry place. Electrically ground all equipment when handling this product and use only non-sparking
tools. Store and dispense peroxide only in original plastic containers.
Other precautions: Store away from heat and heat sources. Observe normal warehousing and handling procedures.
8. Exposure Control/Personal Protection
Ventilation Other Engineering Controls
Local mechanical exhaust ventilation capable of maintaining dust NA
emissions at the point of use below the PEL.
Routes of Entry: Personal Protective Equipment (PPE) for Normal Use: PPE for Emergencies:
Eye/Face Chemical goggles unless a full facepiece respirator is also worn. It is NA
generally recognized that contact lenses should not be work when
working with chemicals because contact lenses may be contribute to the
severity of an eye injury.
Skin Rubber gloves. NA
Inhalation If use conditions generate dusts, wear an NIOSH-approved respirator NA
appropriate for those emission levels. Appropriate respirators may be a
full face piece or a half mask air-purifying cartridge respirator with
particulate filters. A self-contained breathing apparatus in the pressure
demand mode, or a supplied air respirator. Benzoyl peroxide is a strong
oxidizer and should not come in contact with oxidizable materials. Some
cartridges and canisters may contain activated charcoal and should not be
used to provide protection against this product. Use only non-oxidizable
sorbents.
General Hygiene Considerations and Work Practices
Observe normal care in working with chemicals.
Protective Measures During Repair and Maintenance of Contaminated Equipment
NA
Other Protective Measures and Equipment
Long sleeved shirt, trousers, safety shoes, rubber gloves, and rubber apron. An eyewash and safety shower should be
nearby and ready for use.
Page 3 of 5
Part Number(s):
MATERIAL SAFETY DATA SHEET 650007
Form WI04-11A Rev. 1
Product Name: Solo Tach Activator Release Date: March 14, 2007
9. Physical and Chemical Characteristics
Appearance Odor
Fine, white powder. Slight odor
Boiling Point 掳C / 掳F decomposes
Normal Physical State:
Liquid Gas
Melting Point 掳C / 217 掳F
(decomposes)
Solid NA (Other)
Freezing Point 掳C / 掳F NA
Specific Gravity or Density (H20=1) Solubility in Water pH
NA Not soluble NA
Vapor Pressure (mm Hg @ 20掳C) Vapor Density (AIR= 1) Evaporation Rate (Butyl Acetate = 1)
N/A N/A N/A
Other
NA
10. Stability and Reactivity Data
Incompatibility (Materials to Avoid)
Acids, oxidizing or reducing agents, combustible materials such as wood, cloth, or organic materials. Metals such as iron and copper and their
alloys, and accelerators for polymerization reactions.
Hazardous Products Produced During Decomposition
At high temperatures may liberate toxic, flammable biphenyl.
Hazardous Polymerization? Conditions to Avoid
Temperatures above 100 掳C / 掳F Do not grind peroxides or add to
May Occur May Not Occur
hot materials.
Stability? Conditions to Avoid
Stable Unstable Temperatures above 100 掳C / 掳F. Do not grind peroxides or add to
hot materials.
11. Toxicological Information
Toxicity Data, Epidemiology Studies, Carcinogenicity, Neurological Effects, Genetic or Reproductive Effects, or Structure Activity Data
NA
12. Ecological Information
Toxicity, Environmental Fate, Physical/Chemical Data, or Other Data Supporting Environmental Hazard Statements
NA
13. Disposal Considerations
Regulations
Waste disposal methods: Dispose of contaminated product and materials used in cleaning up spills or leaks in a
manner approved for this material. Consult appropriate federal, state and local regulatory agencies to ascertain proper
disposal procedures. Note: Empty containers can have residues, gases and mists and are subject to proper waste
disposal, as above.
Properties (Physical/Chemical) Affecting Disposal
NA
Page 4 of 5
Part Number(s):
MATERIAL SAFETY DATA SHEET 650007
Form WI04-11A Rev. 1
Product Name: Solo Tach Activator Release Date: March 14, 2007
14. Transport Information
Regulated for shipping? Proper Shipping Name Packing Group
Solo tach activator NA
Yes No NA
Hazard Class Identification Number
Do changes in quantity, packaging, or shipment method change product classification?
NA NA
Yes No NA
Other
NA
15. Regulatory Information
Federal Regulations
NA
International Regulations
NA
Other
NA
16. Other Information
Supplier Number: 2/53 Supplier Release: October 2, 1996
N/A = not applicable. NA = not available, N/E = not established. N/D = not determined.
Page 5 of 5
|