MATERIAL SAFETY DATA SHEET
SECTION I 鈥? PRODUCT IDENTIFICATION
Manufacturer: Desilube Technology Inc. Information Phone: 610-792-9460
904 Breezewood Lane Emergency Phone: 215-368-2327
Lansdale, PA 19446 Prepared by: J.P. King
Date: April 25, 2001
Revised: July 1, 2007
Trade Name: DESIGREEN WATER DILUTABLE 100
Synonyms: Metalworking Fluid
DOT Hazard Class: None
Proper Shipping Name: None
SECTION II 鈥? HAZARDOUS INGREDIENTS
Hazardous CAS Number % TLV (ACGIH)
Components
5 mg/m3
Triethanolamine 102-71-6 1-5%
SECTION III 鈥? PHYSICAL DATA
Boiling Range: 212oF Vapor Density: Not determined
Evap. Rate: Not determined Liquid Density: Not determined
Specific Gravity: 0.99 @ 60oF
Volatiles: 6%
Appearance: Clear amber liquid Oil Solubility: Soluble
Water Solubility: Emulsifiable pH @ 5%: 9.2
Odor: Fatty odor
SECTION IV 鈥? FIRE AND EXPLOSIVE DATA
Flammability Class: Flash Point: None
Extinguisher Media
-
Water Fog, Dry Chemical, Foam or CO2
Special Firefighting Procedures
-
Normal firefighting procedures may be used
Unusual Fire and Explosion Hazard
-
None
NFPA Codes: HMIS Codes:
-
Health 1 Health 1
Flammability 0 Flammability 0
Reactivity 0 Reactivity 0
Other: - Protection -
SECTION V 鈥? HEALTH HAZARD DATA
Under Normal Use Conditions:
-
No adverse effect detected.
Effects of Overexposure:
-
Eyes 鈥? Contact causes moderate irritation
Skin 鈥? Prolonged or repeated contact may cause irritation of the skin.
Inhalation 鈥? May cause respiratory irritation if mists and vapors are
generated.
Ingestion 鈥? May cause irritation of the mouth and throat, abdominal
discomfort and nausea.
Signs of Overexposure:
-
Dizziness, nausea, loss of consciousness and respiratory irritation
Routes of Entry
-
Primarily by way of eyes, skin, inhalation and ingestion.
First Aid:
-
Eye Contact 鈥? Flush with large amounts of water for 15 minutes. If
irritation persists, contact a physician.
Skin Contact 鈥? Immediately flush with copious amounts of water for at
least 15 minutes. If irritation persists, contact a physician immediately.
Ingestion - Obtain medical assistance.
Inhalation 鈥? Remove to fresh air. If symptoms persist, contact a physician.
SECTION VI 鈥? REACTIVITY DATA
Stability: ( ) Unstable (X) Stable
Hazardous Polymerization: ( ) May occur (X) Will not occur
- Incompatibility:
Do not mix with strong acids, strong bases or oxidizing agents.
- Conditions to Avoid:
Stable under normal storage and use conditions.
- Hazardous Decomposition Products:
Oxides of carbon, nitrogen, phosphorus, potassium and sodium.
SECTION VII 鈥? SPILL OR LEAK PROCEDURES
- Steps to be Taken in Case Material is Released or Spilled:
Contain spill. Use wet/dry vacuum, squeegee or mop to pick up material.
Transfer material into salvage vessels for disposal. Residual material may be
picked up with flame retardant absorbents such as diatomaceous earth. Treat
slippery surfaces with absorbents.
- Waste Disposal Methods:
Dispose of in accordance with federal, state and local regulations.
SECTION VIII 鈥? SPECIAL PROTECTION INFORMATION
- Respiratory Protection:
If mist/vapors are not adequately controlled by ventilation, use NIOSH/OSHA
Approved respiratory protection.
- Ventilation:
General room ventilation should be satisfactory. Local exhaust ventilation may
be necessary if vapor or misting is generated.
- Skin Protection:
Wear protective, rubber gloves.
- Eye Protection:
Safety glasses with side shields or chemical goggles. Use full face shield to
protect against splashing when appropriate. Do not wear contact lenses.
- Other Protective Equipment
Wear impervious, protective clothing including rubber safety shoes to avoid
skin contact.
SECTION IX 鈥? STORAGE AND HANDLING PROCEDURES
Avoid contact with skin and eyes. Avoid breathing vapors. Keep containers closed. Store
between 40oF and 120oF. Frozen material may be thawed in a warm room. Avoid
localized overheating. Vent drums while heating. Roll drum frequently to assure
homogeneity.
SECTION X 鈥? ADDITIONAL INFORMATION
Product contains Amines. Sodium Nitrite or other nitrosating agents should not be added
to this product. This step will prevent the formation of nitrosamines which are known
animal carcinogens.
SECTION XI 鈥? REGULATORY INFORMATION
- TSCA
All of the ingredients in this product are listed on the TSCA Inventory.
- California Proposition 65
None detectable
- Other states
None
THE ABOVE INFORMATION IS ACCURATE TO THE BEST OF OUR KNOWLEDGE. HOWEVER, SINCE
DATA, SAFETY STANDARDS, AND GOVERNMENT REGULATIONS ARE SUBJECT TO CHANGE AND THE
CONDITIONS OF HANDLING AND USE, OR MISUSE, ARE BEYOND OUR CONTROL, DESILUBE
TECHNOLOGY MAKES NO WARRANTY, EITHER EXPRESSED OR IMPLIED, WITH RESPECT TO THE
COMPLETENESS OR CONTINUING ACCURACY OF THE INFORMATION CONTAINED HEREIN AND
DISCLAIMS ALL LIABILITY FOR RELIANCE THEREON. USER SHOULD SATISFY HIMSELF THAT HE HAS
ALL CURRENT DATA RELEVANT TO HIS PARTICULAR USE.
|