MATERIAL SAFETY DATA SHEET
Product Identification: SYNTHETIC FLUID 285 Robotic Anti Spatter
Emergency Telephone Number
CLEARCO PRODUCTS CO., INC CHEM-TEL: 1 (800) 255 3924
3430-G PROGRESS DR
BENSALEM, PA. 19020 Date Prepared: 1-31-04
Telephone: 1 (800) 533 5823
Signature of Preparer:
----------------------------------------------------------------------------------------------------------------------------------------------------------------
SECTION II HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
INGREDIENTS
COMPONENTS CAS NUMBER AMOUNT
Polyether Polyol 9003-13-8 100.0%
HMIS RATING
FLAMMABILITY REACTIVITY HEALTH
1 0 2
------------------------------------------------------------------------------------------------------------------------------------------------
SECTION III PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point No Data
Specific Gravity (H2O=1) .98 - 1.003
Vapor Pressure (mm Hg)@25掳C No Data
Vapor Density (Air = 1): No Data
Evaporation Rate (Butyl Acetate = 1) No Data
Freezing Point -10掳F
Solubility in Water % by Wt, Insoluble
Appearance & Odor: Clear colorless liquid with a mild odor
----------------------------------------------------------------------------------------------------------------------------------------------------------------
SECTION IV FIRE AND EXPLOSION HAZARD DATA
Flash Point: (Method Used) Closed Cup 425掳F
Flammable Limits: LEL: N/D UEL: N/D
Extinguishing Media: Foam, Dry Chemical, Water Spray or Fog
Special Fire Fighting Procedures: None
Unusual Fire & Explosion Hazards: NONE
----------------------------------------------------------------------------------------------------------------------------------------------------------------
SECTION V - REACTIVITY DATA
Stability: Stable
Conditions to Avoid: No Data Available
Hazard Polymerization: None Known
Incompatibilities: None known
Hazardous Decomposition: None Known
SECTION VI HEALTH HAZARD DATA
Symptoms of Over Exposure: Eye and mucous membrane irriation. Lethargy and G.I. discomfort from oral ingestion.
Medical Conditions Aggravated: NONE
Carcinogenicity: NTP? NO IARC Monographs? NO OSHA Regulated? NO
Primary Routes of Entry: Inhalation, Eye/Skin contact, Ingestion
Health Hazards: None
Emergency and First Aid Procedures:
Inhalation Remove to fresh air. Call a physician.
Ingestion Immediately drink large quantities of water. Inuce vomiting by sticking finger down throat. Call a physician.
Eye Contact Flush eyes with clear water for a minimum of 15 minutes. Call a physician.
Skin Contact Flush with water. Washing any substance off skin is a good safety practice.
------------------------------------------------------------------------------------------------------------------------------------------------
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
Spill Response: If material is spraying or misting, use a NIOSH/MSHA approved dust/mist respirator in adition to wearing goggles, impervious
coveralls, gloves and boots. Follow OSHA regulations for respirator use (See 29 CFR 1910.134). Isolate area of spill by diking. Stop source of leak.
Add dry absorbent, shovel or sweep up. Place in appropriate container and seal. Wash all contaminated clothing before reuse.
Waste Disposal Method: Dispose of contaminated product, empty containers and materials used in cleaning up spills or leaks in a manner approved for
this material. Consult appropriate Federal, State and local regulatory agencies to ascertain proper disposal procedures.
Other Precautions: Do not store prodct where temperature will exceed 200掳F.
---------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
SECTION VIII - PROTECTION AND PRECAUTIONS
Ventilation: Local Exhaust - Preferred with face velocity 60 ppm
Special: None
Other: None
Respiratory Protection: None required when handling at abient temperatures.
Protective Gloves: Use vinyl or rubber gloves when handling product.
Eye Protection: Goggles or face shield.
Other Protective Equipment: Normally not needed.
Work Practices and Controls: Normal Precautions.
-------------------------------------------------------------------------------------------------------------------------------------
SECTION IX - DEPARTMENT OF TRANSPORTATION DATA
THIS MATERIAL NOT REGULATED AS A D.O.T. HAZARDOUS MATERIAL
Flammable No
Combustibile No
-------------------------------------------------------------------------------------------------------------------------------------
DISCLAIMER
Information presented herein has been compiled from information provided to us by our suppliers and other sources considered to be dependable and is
accurate and reliable to the best of our knowledge and belief but is not guaranteed to be so. We make no warranty as to the results to be obtained in
using any material and since conditions of use are not under our control, we must necessarily disclaim all liability with respect to the use of any
material supplied by us.
|