HYVAC PRODUCTS, INC.
P.O. Box 389 Phoenixville, Pa 19460 Ph 610-792-0500 Fax 610-792-0600
MATERIAL SAFETY DATA SHEET
Prepared 01/02/2002
This Product Safety information is provided periodically to assist our customers in assessing compliance with
Health/Safety/Environmental Regulations. Please forward this to your manager of Safety and Health.
SECTION I. IDENTIFICATION
TRADE NAME: HyVac Flushing Oil
CATALOG NUMBER: 93060
SYNONYMS: Flushing Oil
CAS REGISTRY NUMBER: 64741-88-4
UN NUMBER:
TECHNICAL CONTACT: (610) 792-0500
MATERIAL HAZARD EVALUATION (Per OSHA's Hazard Communication Standard 29 CFR Part
1910.100) (OHCS).
HEALTH: Non-Hazardous. (OHCS)
PRECAUTIONARY STATEMENT: None
SECTION II. GENERIC COMPOSITION / COMPONENTS
COMPONENTS CAS # % HAZARD DATA
Refined Petroleum 64741-88-4 100 Oral: LD50(rat): >15g/kg
Oil(s) Eye: Practically Non-Irritating
Skin: Practically Non-Irritating
3
Ihln: LC50/4H(rat): >5,000mg/m
SECTION III. PHYSICAL DATA
Physical Hazard Classification (Per 29 CFR Part 1910.1200)
O
BOILING POINT: 760 mmHg Wide Range F
O O
MELTING POINT: C- F NA
SPECIFIC GRAVITY: (H2O=1) 0.87
O
VAPOR PRESSURE: mmHg (20 C) Below .0001
VAPOR DENSITY: (Air=1) 14
SOLUBILITY: in H2O, % by Wt. Negligible
EVAPORATION RATE: (ethyl ether = 1) 1000 times slower
% VOLATILES: by Volume Negligible
PH OF UNDILUTED PRODUCT: ND
APPEARANCE: Light Amber liquid
ODOR: Little odor
No Combustible No Oxidizer No Pyrophoric
No Compressed Gas No Reactivity Yes Stable
No Explosive No Organic Peroxide No Unstable
No Flammable
SECTION IV. FIRE AND EXPLOSION DATA
O O
NEFAR
FLASH POINT, COC 215 C - 420 F
O O
FLASH POINT, PM 211 C - 412 F HEALTH: 1
O O
FIRE POINT, COC 245 C - 475 F FLAMMABILITY: 1
REACTIVITY: 0
FLAMMABLE LIMITS IN AIR, % VOL.:
Lower: ND
Upper: ND
EXTINGUISHING MEDIA: CO2, Dry chemical, Foam or Water Fog.
SPECIAL FIRE FIGHTING PROCEDURE: Wear self-contained breathing gear when fire fighting
in confined spaces.
UNUSUAL FIRE OR EXPLOSION HAZARD: Water may cause frothing.
HyVac庐 assignment based on our evaluation per NFPA guidelines.
Hazard Rating: Least - 0 Slight - 1 Moderate - 2 High - 3 Extreme - 4
SECTION V. REACTIVITY DATE
STABILITY: Stable - Yes Unstable - No
CONDITIONS CONTRIBUTING TO INSTABILITY: None
INCOMPATIBILITY: Strong Oxidants
HAZARDOUS DECOMPOSITION PRODUCTS
(THERMAL, UNLESS OTHERWISE SPECIFIED): CO, CO2
CONDITIONS CONTRIBUTING TO
HAZARDOUS POLYMERIZATION: None
SECTION VI. SPILL OR LEAK PROCEDURES
PROCEDURES IF MATERIAL IS SPILLED:
Remove sources of heat or ignition, provide adequate ventilation, contain the leak. Absorb small
spills with suitable material such as rags, straw or sand. Report spills as required to appropriate
authorities.
WASTE DISPOSAL:
It is the responsibility of the user to determine if the material is a hazardous waste at the time of
disposal. Please check before disposing of product or container to be sure you are in compliance
with all applicable laws and regulations.
PROTECTIVE MEASURES DURING REPAIR AND MAINTENANCE OF CONTAMINATED EQUIPMENT:
Refer to Section VIII - Special Protection Information.
Avoid prolonged contact with used oil, wash skin thoroughly with soap and water.
SECTION VII HEALTH HAZARD DATA
HEALTH HAZARD CLASSIFICATION (per 29 CFR Part 1910.1200)
Carcinogen: No Corrosive No
Animal Carcinogen: No Irritant No
Suspect Carcinogen: No Sensitizer No
Mutagen: No Teratogen No
Highly Toxic: No Target Organ No
Toxic: No
PRODUCT LISTED AS CARCINOGEN OR POTENTIAL CARCINOGEN BY:
NTP - No IARC - No OSHA - No Other - No
TOXICITY SUMMARY: Slightly toxic, 1 pt. to 1 qt. is approximate lethal oral dose for 150 lbs.
human adult.
MAJOR ROUTE(s) OF ENTRY: Inhalation of fumes.
ACUTE EXPOSURE SYMPTOMS
INHALATION: Low risk of inhalation. In enclosed spaces or when hot, vapors may
reach concentrations sufficient to cause drowsiness, dizziness,
headache, nausea, or lung irritation. Mists above TLV may cause
chemical pneumonitis.
DERMAL CONTACT: Transient, slight irritation.
EYE CONTACT: May be mildly irritating.
INGESTION: Generally low toxicity. Very large amounts may cause generalized
depression, headache, drowsiness, nausea, vomiting or diarrhea. Small
doses may produce irritation and diarrhea.
CHRONIC EXPOSURE: Prolonged and/or frequent contact may cause drying, cracking
(dermatitis) or folliculitis. Repeated, excessive exposure to mists or
fumes may induce pulmonary irritation or chronic bronchitis.
OTHER SPECIAL EFFECTS: None Expected.
FIRST AID AND EMERGENCY PROCEDURES FOR ACUTE EFFECT
INHALATION: Remove to fresh air. Respiratory support if necessary. Seek medical
aid.
DERMAL: Wash with soap and water. Do not wear heavily contaminated clothing
before laundering.
EYES: Flush with large volumes of water. See physician if any complications
arise.
INGESTION: Do not induce vomiting. Seek medical aid.
INJECTION: Subcutaneous injection is a medical emergency. Seek medical aid
immediately.
0
NOTES TO PHYSICIAN: Following ingestion, at a viscosity of about 350 SUS (100 F), the risk of aspiration
into the lungs is remote, but cuffed tube lavage is still recommended for
large quantities. Aspirated material may cause chemical pneumonitis or
lipoid pneumonia. Subcutaneous or intramuscular injection requires
prompt surgical debridement. If not familiar with technique, seek skilled
advice.
SECTION VIII SPECIAL PROTECTION INFORMATION
VENTILATION REQUIREMENT: Ventilation is required when work place exposures exceed TLV.
PERMITTED THRESHOLD: Agency: OSHA OSHA ACGIH
ACGIH
AIR CONCENTRATIONS: Year: 1972 1985 1985-86 1985-86
Type: TWA PEL TWA STEL
ppm: - - - -
3
mg/m 5 5 5 10
SPECIFIC PERSONAL PROTECTIVE EQUIPMENT
RESPIRATORY: Normally none required. If high vapor or mist concentrations expected -
use respirator approved for organic vapors and mists.
EYES: Safety goggles, or chemical splash goggles if splashing is anticipated.
DERMAL: Oil impervious gloves if frequent or prolonged contact is expected.
CLOTHING/EQUIPMENT: Wear body-covering work clothes to avoid prolonged or repeated
exposure. Launder soiled work clothes before reuse.
SECTION IX TRANSPORTATION AND SPECIAL PRECAUTIONS
HAZARDOUS MATERIAL PLACARD/LABEL: None
o
STORAGE: Store below 150 F. Do not apply high heat or flame to
container. Keep separate from strong oxidizing agents.
DOT INFORMATION:
DOT/UN Shipping Name: Petroleum Lubricating Oil.
DOT Hazard Class: Non-Hazardous
DOT/UN Hazard Identification #: None assigned
DOT Shipping Container Restrictions: None
DOT Placard: None
CAUTION: Empty containers may contain product residue which could include flammable or
explosive vapors.
Consult appropriate Federal, State and Local authorities before reusing, reconditioning, reclaiming, recycling
or disposing of empty containers and/or waste residues of this product.
_____________________________________________________________________
LABEL: Non-Hazardous. (OHCS)
_____________________________________________________________________
All statements, information, and data provided in this material safety data sheet are believed to be accurate
and reliable, but are presented without guarantee, warranty, or responsibility of any kind, expressed or
implied, on our part. Users should make their own investigation to determine the suitability of the
information or products for their particular purpose. Nothing contained h erein is intended as permission,
inducement or recommendation to violate any laws or to practice any invention covered by existing patents.
|