MATERIAL SAFETY DATA SHEET
(Prepared According to 29 CFR 1910.1200)
ShockWaveTM (8310)
SECTION I - PRODUCT IDENTIFICATION
Fiberlock Technologies, Inc. Date of Preparation: September 9, 2005
150 Dascomb Rd. Information Telephone Number; 978-623-9987
Andover, MA 01810 Emergency Telephone Numbers:
978-623-9987 Weekdays: 978-623-9987
978-475-6205 fax After hours, weekends & holidays: 鈥淐HEMTEL鈥?
www.fiberlock.com Emergency Contact Number: 800-255-3924
SECTION II - INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLVSTEL-TLV
Water 7732-18-5 to 100
Dimethyl Benzyl Ammonium Chloride 68391-01-5 2.25
Dimethyl Ethylbenzyl Ammonium Chloride 68956-79-6 2.25
Nonionic Surfactant 9016-45-9 0 to 5
Sodium Carbonate 497-19-8 0 to 5
Tetrasodium EDTA 64-02-8 0 to 5
Perfume Oil N/A 0 to 5
Dye N/A 0 to 5
This product does not contains any toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community
Right-To-Know Act of 1986 and of 40 CFR 372.
SECTION III - PHYSICAL DATA
Boiling Point (掳F): 210 F. Vapor Density (Air=1): >1 Solubility in Water: Complete
Specific Gravity: 1.040 % Volatile: 90+ Evaporation Rate (Water=1): <1
Vapor Pressure: 20mm Hg @ 68 F. pH: 11.5-12.0 Physical Description: Thin light blue liquid with pleasant odor.
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): N/A Lower Explosion Limit: N/A Special Firefighting Procedures: Non Flammable
Upper Explosion Limit: N/A Extinguishing Media: N/A Unusual Fire and Explosion Hazards: N/A
SECTION V - REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Will not occur. Incompatibility (Materials to Avoid): None
SECTION VI - STORAGE AND HANDLING INFORMATION
Keep out of reach of children. For use by trained personnel only. Keep container closed during storage. For institutional and industrial
use only. Avoid contact with eyes, skin and clothing. Avoid breathing of mists. Use in well-ventilated area.
SECTION VII - HEALTH HAZARDS AND FIRST AID
Effects of Overexposure: Skin: Skin irritant. Prolonged or repeated contact may cause dermatitis. Eyes: Severe eye irritant. Liquid
and mists may injure the eyes causing corneal damage. Inhalation: Mists are irritating to throat, nose and lungs. Ingestion: Irritating to
the mouth, throat, and gastrointestinal system. Burning, pain, and diarrhea expected with large doses.
First Aid Procedures:
Skin: Remove contaminated clothing. Flush affected areas with large quantities of water. Seek medical attention if irritation persists.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical attention. Inhalation: Remove victim to fresh air and
monitor. Seek medical attention if symptoms persist. Ingestion: Give large quantities of water. Seek medical attention immediately.
SECTION VIII - SPECIAL PROTECTION INFORMATION
Respiratory Protection: No special requirements. Avoid breathing mists. Ventilation Requirements: Provide local exhaust to keep TLV of
Section 2 ingredients below acceptable limit. Protective Gloves: Latex, rubber, vinyl, or nitrile Eye Protection: Chemical goggles
recommended when spraying diluted product. Other Protective Equipment: Eyewash station should be provided nearby.
SECTION IX - SPILL OR LEAK PROCEDURES
Steps to be taken in Case Material is Released or Spilled: Floors will become slippery. Avoid walking in product. Keep unessential
personnel away. Mop up or otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
Waste Disposal Method: Any method in accordance with local, state and federal laws. Best method is to recycle or reuse for intended
purpose. Consult local authorities for disposal in public sewer. Do not dispose of into storm drain, stream, river or to ground. Rinse
container thoroughly before discarding in trash.
SECTION X - REGULATORY INFORMATION
SARA Title III - Section 311/312 - Hazard Categories:
No - Fire Hazard
No - Sudden Release of Pressure Hazard
No - Reactivity Hazard
Yes - Immediate (acute) Health Hazard
Shipping Class: Cleaning Compound
No - Delayed (chronic) Health Hazard
To comply with New Jersey DOH Right-To-Know
labeling law (N.J.A.C. 8:59 - 5.1 & 5.2)
CAS. No.: CHEMICAL INGREDIENTS: HMIS HAZARD RATING
7732-18-5 Water Health 2 Flammability 0 Physical Hazard 0 Personal Protection B
68391-01-5 Dimethyl Benzyl Ammonium Chloride
HAZARD INDEX: 0=Minimal, 1=Slight, 2=Moderate, 3=Serious, 4=Severe
68956-79-6 Dimethyl Ethylbenzyl Ammonium Chloride
9016-45-9 Nonionic Surfactant
497-19-8 Sodium Carbonate
|