MATERIAL SAFETY DATA SHEET
COMPLIES WITH OSHA鈥橲 HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
SECTION I 路 PRODUCT IDENTIFICATION
Product Name: Choke & Carburetor Cleaner Formula: Proprietary HMIS Rating (Based on Aerosol Conc.):
Product Number: RL74115 Date Prepared: 03/07/05 0-Minimal 1- Slight 2- Moderate
Product Type: AEROSOL Emergency Phone: (800) 255-3924 3- Serious 4 - Extreme
Distributor's Name: IBS, Inc. Information Phone: (800) 678-1906 HEALTH: 2 FIRE: 3 REACTIVITY: 0
Distributor's Address: P.O. Box 1717, Auburn, WA 98071-1717 Personal Protection : B
D.O.T. Hazard Class: CONSUMER COMMODITY 路 ORM-D
SECTION II 路 INGREDIENTS
CHEMICAL NAME CAS # %WT 313/Chem Skin Carcinogen PEL TWA/TLV
Toluene 108-88-3 22-32 YES NO NO 100 ppm 100 ppm
Methanol 67-56-1 15-25 YES NO NO 200 ppm 200 ppm
Acetone 67-64-1 45-55 NO NO NO 750 ppm 750 ppm
Carbon Dioxide Propellant 124-38-9 01-10 NO NO NO 10,000 ppm 5,000 ppm
SECTION III 路 PHYSICAL DATA
Data Below Based On Aerosol Concentrate Only:
Boiling Point: 131掳 F
pH: N/A Vapor Density(Air=1): N/D
Solubility In Water: Partial Specific Gravity (H2O=1)@75掳F: 0.815
Appearance/Odor: Clear Colorless Liquid, Aromatic Odor
Data Below Based On Total Contents:
Vapor Pressure of can (psig @70掳F): ND
Total VOC %: 45%
SECTION IV 路 FIRE AND EXPLOSION DATA
Flash Point (of Concentrate Only): <0掳F (T.C.C) Flammability (as per USA Flame Projection Test): Extremely Flammable Spray
Extinguishing Media: Foam, CO2, Dry Media
Special Fire Fighting Procedures: Wear self-contained breathing apparatus and protective clothing. Cool fire exposed containers to prevent rupturing.
Unusual Fire and Explosion Hazards: Exposure to temperature above 120掳 F may cause bursting.
SECTION V 路 REACTIVITY DATA
Stability: Material Stable. Hazardous Polymerization: Will not occur.
Incompatibility: Avoid contact with strong oxidizing agents, sources of ignition,
Hazardous Decomposition Products: Carbon Dioxide, Carbon Monoxide.
SECTION VI 路 STORAGE AND HANDLING
KEEP OUT OF REACH OF CHILDREN.
For Industrial and Institutional use only.
Store in a cool, dry area away from heat or open flame.
Do not store at temperatures above 120掳 F. NFPA Code 30B Rating: Level 3 Aerosol.
SECTION VII 路 HEALTH AND FIRST AID
PRIMARY ROUTES OF ENTRY & EFFECTS OF OVER EXPOSURE:
Eyes: May cause irritation.
Skin: Frequent or prolonged contact may cause irritation or dermatitis.
Inhalation: Inhalation of mist can cause irritation of nasal and respiratory passages. Abusive or excessive inhalation may cause irritation to the upper respiratory
tract, dizziness, nausea and other central nervous system effects.
Ingestion: Can cause gastrointestinal irritation, nausea, vomiting and diarrhea. Aspiration of material into the lungs can cause chemical pneumonitis.
FIRST AID PROCEDURES:
Eyes: Flush with large amounts of cool running water for at least 15 minutes while holding upper and lower lids open. If irritation persists get medical attention
immediately.
Skin: Remove contaminated clothing. Wash affected areas with soap and water. If irritation persists seek medical attention.
Inhalation: Remove to fresh air. Seek medical attention immediately. If breathing stops give artificial respiration.
Ingestion: Do not induce vomiting. Seek medical attention immediately.
SECTION VIII 路 SPECIAL PROTECTION DATA
Respiratory Protection: None needed for proper use in accordance with label directions. Use approved NIOSH Organic Vapor Respirator or self-contained
breathing apparatus if accumulation of vapors is expected.
Ventilation: Provide local exhaust to keep concentration of Section II ingredients below acceptable limits.
Protective Gloves: Use chemical resistant gloves if hand contact will be made.
Eye Protection: Wear safety glasses or chemical proof goggles.
SECTION IX 路 SPILL OR LEAK PROTECTION
STEPS TO BE TAKEN IN CASE OF SPILL OR LEAK: Allow propellant to evaporate. Maintain local exhaust and adequate ventilation. No smoking. Keep sparks, heat
sources and open flame far away from spill or leak. Cover with absorbent material and sweep up. Wash area to prevent slipping. Dispose of soaked absorbent
material in accordance with Federal, State and local laws.
WASTE DISPOSAL METHOD: Aerosol cans, when emptied and depressurized through normal use, pose no disposal hazard and should be recycled. Consult
Federal, State and local authorities for approved procedures.
N/A= NOT APPLICABLE 路 N/E=NOT ESTABLISHED 路 N/D=NOT DETERMINED 路 <=LESS THAN 路 >=MORE THAN
NOTICE: The information contained on this Material Safety Data Sheet is considered accurate as of the date of publication. It is not necessarily all inclusive nor fully adequate in every
circumstance. The suggestions should not be confused with, nor followed in violation of applicable laws, regulations, rules or insurance requirements. No warranty, express or implied, of
merchantability, fitness, accuracy of data, or the results to be obtained from the use thereof is made. The vendor assumes no responsibility for injury or damages resulting from the
inappropriate use of this product.
|