KC Chemical Terminator Cleaner MSDS Date: 25 March 2007
Supersedes:
MATERIAL SAFETY DATA SHEET
(Complies with 29 CFR 1910.1200)
SECTION I
KC Chemicals
5500 State Park Road, Travelers Rest, SC 29690
(864) 834-2562
PRODUCT NAME: Terminator Cleaner
PRODUCT CODE:
CHEMICAL NAME: N/A
CAS #: N/A
MIXTURE (X)
SINGLE SUBSTANCE ( )
SECTION II
HAZARDOUS INGREDIENTS
MATERIAL OR COMPONENT % HAZARD DATA
3
Potassium Hydroxide <20% 2 mg/m NIOSH
(CAS 1310-58-3)
Corrosive Liquid, NOS, 8, UN 1760, III
ERG #154
Sodium Metasilicate Pentahydrate <10%
(CAS 6834-92-0)
SECTION III
PHYSICAL DATA
o
BOILING POINT: 212 F
SPECIFIC GRAVITY: 1.090
VAPOR PRESSURE: N/A
PERCENT VOLATILE BY VOLUME: >60%
VAPOR DENSITY: N/A
EVAPORATION RATE (H2O = 1): 1
SOLUBILITY IN WATER: Complete
APPEARANCE AND ODOR: Water thin yellow liquid with pina colada odor.
pH AS RECEIVED: 12.0 鈥? 13.5 卤 0.5
SECTION IV
FIRE AND EXPLOSION HAZARD DATA
o
FLASH POINT (METHOD USED): >200 F estimated
FLAMMABILITY LIMITS: LEL UEL
EXTINGUISHING MEDIA: Water Fog, Dry Chemical or Alcohol Foam
SPECIAL FIRE FIGHTING PROCEDURES: None
UNUSUAL FIRE AND EXPLOSION HAZARDS: None
SECTION V
HEALTH HAZARDS DATA
3
THRESHOLD LIMIT VALUE: 2 mg/m NIOSH as 100% KOH
EFFECTS OF OVEREXPOSURE: Skin, eye and mucous membrane irritation.
EMERGENCY FIRST AID PROCEDURES: Flush immediately with water. Call a physician. If ingested, induce vomiting and immediately call a
physician.
SECTION VI
REACTIVITY DATA
STABILITY: STABLE: X UNSTABLE:
CONDITIONS TO AVOID: None
INCOMPATIBILITY (MATERIALS TO AVOID): Acids, especially strong mineral or organic acids
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon dioxide
HAZARDOUS POLYMERIZATION MAY OCCUR: WILL NOT OCCUR: X
1
KC Chemical Terminator Cleaner MSDS Date: 25 March 2007
Supersedes:
SECTION VII
SPILL OR LEAK PROCEDURES
SPILL RESPONSE PROCEDURES: Small spills may be neutralized and flushed into the sewer. Large spills should be contained by dikes and
absorbed on appropriate media and/or collected in suitable containers.
WASTE DISPOSAL METHOD: All chemical spills should be disposed as per federal, state and local laws and regulations. In most cases, spills of this
material collected or absorbed should be acceptable for ordinary sanitary land filling.
SECTION VIII
SPECIAL PROTECTION INFORMATION
EYE PROTECTION: Glasses and Goggles
RESPIRATORY PROTECTION: None required
SKIN PROTECTION: Rubber or vinyl gloves and ordinary clothing for exposed skin.
OTHER PROTECTION: None
VENTILATION RECOMMENDATION: Avoid use in confined spaces. Under normal conditions, typical mechanical ventilation in commercial buildings
should be adequate.
SECTION IX
SPECIAL PRECAUTIONS
HYGIENE PRACTICES IN HANDLING AND STORAGE: Store in a cool, dry, well ventilated area.
OTHER PRECAUTIONS: None
SECTION X
PREPARER AND DISCLAIMER
The information and recommendations contained herein are to the best of KC CHEMICALS Inc.鈥檚 knowledge and belief, accurate and
reliable as of the date issued. However, it is the user's responsibility to determine the safety, toxicity, and suitability for their own use of the
product described herein. Since the actual use of this product is beyond the control of KC CHEMICALS Inc., no guarantee, expressed or
implied, is made by KC CHEMICALS Inc.
PREPARED BY: Ken Carter DATE: 25 March 2007
KC Chemicals
5500 State Park Road
Travelers Rest, SC 29690
(864) 834-2562
WWW.KCCHEMICALS.COM
2
|