12-25-KEY10 Fast Acrylic Lacquer Thinner
MATERIAL SAFETY DATA SHEET
THIS MSDS COMPLIES WITH 29 CFR 1910.1200 (HAZARD COMMUNICATION STANDARD)
IMPORTANT: Read this MSDS before handling and disposing of this product.
Pass this information on to employees, customers, & users of this product.
SECTION 1. CHEMICAL PRODUCTS & COMPANY IDENTIFICATION / HAZARD RATINGS
PRODUCT IDENTITY: Blend #9511 KEY10 Fast Acrylic Lacquer Thinner HEALTH RATINGS:
COMPANY IDENTITY: Keystone Automotive Industries HEALTH (NFPA) = 2
COMPANY ADDRESS: 700 East Bonita Avenue HEALTH (HMIS) = 3
Pomona, CA 91767 FLAMMABILITY = 3
COMPANY PHONE: 1-800-772-5557 REACTIVITY = 0
CHEMTREC PHONE: 1-800-424-9300
SECTION 2. INGREDIENT & REGULATORY INFORMATION
All components of this product are on the TSCA list.
SARA Title III Section 313 Supplier Notification
This product contains the indicated <*> toxic chemicals subject to the reporting requirements of Section 313 of
the Emergency Planning & Community Right-To-Know Act of 1986 & of 40 CFR 372. This information must be
included in all MSDSs that are copied and distributed for this material.
SARA TITLE III INGREDIENTS CAS# WT. % (REG.SECTION) RQ (LBS)
*Toluene 108-88-3 50 (311, 312, 313, RCRA) 1000
*Methanol 67-56-1 19 (311, 312, 313, RCRA) 5000
Light Aliphatic Solvent Naphtha *64742-89-8 Not Appl. (311, 312) None
Acetone 67-64-1 Not Appl. (311, 312) 5000
SARA SECTION 311/312 HAZARDS: Acute Health, Chronic Health, Fire
MATERIAL CAS# TWA (OSHA) TLV (ACGIH) HAP
Toluene 108-88-3 200 ppm 50 ppm Yes
Methanol 67-56-1 200 ppm (s) 200 ppm (s) Yes
Light Aliphatic Solvent Naphtha *64742-89-8 500 ppm (s) 300 ppm (s) No
Acetone 67-64-1 1000 ppm (s) 750 ppm (s) No
In addition to EPA Hazardous Air pollutants showing 鈥榊es鈥? under 鈥淗AP鈥? above, using manufacturers鈥? data, based on
EPA Method 311, the following EPA Hazardous Air Pollutants may be present in trace amounts (less than 0.1%) =
Benzene, Mixed Xylenes, Ethylbenzene
REV. 03/2005 1
MATERIAL CAS# CEILING STEL (OSHA/ACGIH)
Methanol 67-56-1 None Known 250 ppm
Acetone 67-64-1 None Known 1000 ppm
CALIFORNIA PROPOSITION 65: This product contains the following chemicals known to the state of California to
cause cancer & reproductive toxicity: Benzene, Toluene
DOT SHIPPING NAME: Paint Related Material, 3, UN1263, PG II
DRUM LABEL: (FLAMMABLE LIQUID)
SECTION 3. HAZARDS IDENTIFICATION
MATERIAL CAS# LOWEST KNOW LETHAL DOSE DATA
LOWEST KNOWN LD50 (ORAL)
Methanol 67-56-1 1000.0 mg/kg (Man)
LOWEST KNOWN LC50 (VAPORS)
Toluene 108-88-3 5300 ppm (Mice)
LOWEST KNOWN LD50 (SKIN)
Toluene 108-88-3 4000.0 mg/kg (Rabbits)
THRESHOLD LIMIT VALUE: 100 ppm (Evaporated Blend)
CONTAINS: TOLUENE, METHANOL, LIGHT ALIPHATIC SOLVENT NAPHTHA, ACETONE
DANGER!!
EXTREMELY FLAMMABLE!! VAPORS CAN CAUSE FLASH FIRE
POISON!!
ACUTE HAZARDS
EYE & SKIN CONTACT:
Primary irritation to skin, defatting, dermatitis.
Absorption thru skin increases exposure.
Primary irritation to eyes, redness, tearing, blurred vision.
Liquid can cause eye irritation. Wash thoroughly after handling.
INHALATION:
Anesthetic. Irritates respiratory tract. Acute overexposure can cause serious nervous system depression.
Vapor harmful.
Breathing vapor can cause irritation.
Acute overexposure can cause damage to kidneys, blood, nerves, liver & lungs.
Repeated exposure over TLV can cause blindness.
SWALLOWING:
Can be fatal or cause blindness if swallowed. Cannot be made non-poisonous.
POISON! Can cause irreversible nervous system damage & death.
Harmful or fatal if swallowed.
Swallowing can cause abdominal irritation, nausea, vomiting & diarrhea.
SUBCHRONIC HAZARDS / CONDITIONS AGGRAVATED
CONDITIONS AGGRAVATED
REV. 03/2005 2
Chronic overexposure can cause damage to kidneys, blood, nerves, liver, & lungs.
Persons with severe skin, liver or kidney problems should avoid use.
CHRONIC HAZARDS
CANCER, REPRODUCTIVE & OTHER CHRONIC HAZARDS:
This product has no carcinogens listed by IARC, NTP, NIOSH, OSHA, or ACGIH, as of this date, greater or
equal to 0.1%.
This product may contain less than 1 ppm of Benzene.
Not considered hazardous in such low concentrations.
Absorption through skin may be harmful. Studies with laboratory animals indicate this product can cause
damage to fetus.
SECTION 4. FIRST AID MEASURES PROCEDURES
EYE CONTACT:
For eyes, flush with plenty of water for 15 minutes & get medical attention.
SKIN CONTACT:
In case of contact with skin immediately remove contaminated clothing.
Wash thoroughly with soap & water. Wash contaminated clothing before reuse.
(Discard contaminated shoes)
INHALATION:
After high vapor exposure, remove to fresh air. If breathing is difficult, give oxygen. If breathing has stopped
give artificial respiration. CALL A PHYSICIAN IMMEDIATELY!
SWALLOWING:
Induce vomiting promptly using physician's instructions or by having patients stick finger down throat. After
vomiting has been induced, give two teaspoonful of baking soda in a glass of water. CALL A PHYSICIAN.
Never give anything by mouth to an unconscious person. Have patient lie down & keep warm. Cover eyes to
exclude light. Have patient lie down & keep warm. Cover eyes to exclude light.
SECTION 5. FIRE FIGHTING MEASURES
AUTO IGNITION TEMPERATURE: 290 C / 555 F (Lowest Component)
LOWER FLAMMABLE LIMIT IN AIR (% by vol): 2.7
FLASH POINT (TEST METHOD): -16 C / 2 F (TCC) (Lowest Component)
FLAMMABILITY CLASSIFICATION: Class I B
EXTINGUISHING MEDIA
NFPA Class B extinguishers (Carbon Dioxide or foam) for Class I B liquid fires.
SPECIAL FIRE FIGHTING PROCEDURES
Water spray may be ineffective on fire but can protect fire fighters & cool closed containers. Use fog nozzles if
water is used.
Do not enter confined fire-space without full bunker gear. (Helmet with face shield, bunker coats, gloves &
rubber boots).
Use NIOSH approved positive-pressure self-contained breathing apparatus.
UNUSUAL EXPLOSION AND FIRE PROCEDURES
EXTREMELY FLAMMABLE!! VAPORS CAN CAUSE FLASH FIRE
Keep container tightly closed.
Isolate from oxidizers, heat, sparks, electric equipment & open flame.
REV. 03/2005 3
Closed containers may explode if exposed to extreme heat.
Applying to hot surfaces requires special precautions.
Empty container very hazardous! Continue all label precautions
SECTION 6. ACCIDENTAL RELEASE MEASURES
SPILL OR LEAK PROCEDURES
Stop spill at source. Dike area & contain. Clean up remainder with absorbent materials. Mop up & dispose of.
Persons without proper protection should be kept from area until cleaned up.
WASTE DISPOSAL METHOD
Recycle or dispose of observing local, state & Federal health, safety & pollution laws. If questions exist, contact
the appropriate agencies.
OTHER PRECAUTIONS
Vapors may ignite explosively & spread long distances. Prevent vapor buildup. Put out pilot lights & turn off
heaters, electric equipment & other ignition sources during use & until all vapors are gone.
SECTION 7. HANDLING AND STORAGE
HANDLING
Isolate from oxidizers, heat, sparks, electric equipment & open flame.
Use only with adequate ventilation. Avoid breathing of vapor or spray mist.
Avoid contact with skin & eyes.
Wear OSHA Standard goggles or face shield. Consult Safety Equipment Supplier.
Wear gloves, apron & footwear impervious to this material. Wash clothing before reuse.
Avoid free fall of liquid. Ground containers when transferring. Do not flame cut, saw, drill, braze, or weld. Empty
container very hazardous! Continue all label precautions!
STORAGE
Vapors may ignite explosively & spread long distances. Prevent vapor buildup.
Put out pilot lights & turn off heaters, electric equipment & other ignition sources during use & until all vapors are
gone.
Do not store above 49 C / 120 F. Store large amounts in structures made for OSHA Class I B liquids.
Keep container tightly closed & upright when not in use to prevent leakage.
SECTION 8. EXPOSURE CONTROLS / PERSONAL PROTECTION
EXPOSURE CONTROLS
Ventilate to keep vapors of this material below 50 ppm. If over TLV, in accordance with 29 CFR 1910.134, use
NIOSH approved positive-pressure self-contained breathing apparatus. Consult Safety Equipment Supplier. Use
explosion-proof equipment.
VENTILATION
LOCAL EXHAUST = Necessary
MECHANICAL (GENERAL) = Acceptable
SPECIAL = None
OTHER = None
PERSONAL PROTECTIONS:
Wear OSHA Standard goggles or face shield. Consult Safety Equipment Supplier.
Wear gloves, apron & footwear impervious to this material. Wash clothing before reuse.
REV. 03/2005 4
SECTION 9. PHYSICAL DATA
APPEARANCE: Liquid, Water-White
ODOR: Ketone
BOILING RANGE: 56 93 122 C / 133 201 252 F
GRAVITY @ 60 F:
API: 41.1
SPECIFIC GRAVITY (Water = 1): .820
POUNDS / GALLON: 6.830
VOC鈥橲 (>0.44 LBS / SQ IN): 100.0 Vol. % / 819.9 g/L / 6.829 Lbs/Gal
TOTAL VOC鈥橲 (TVOC): 100.0 Vol. % / 819.9 g/L / 6.829 Lbs/Gal
NONEXEMPT VOC鈥橲 (CVOC): 85.0 Vol. % / 701.1 g/L / 5.840 Lbs/Gal
HAZARDOUS AIR POLLUTANTS (HAPS): 52.8 Wt. % / 428.3 g/L / 3.567 Lbs/Gal
VAPOR PRESSURE (mm of Hg) @ 20 C: 78.8
NONEXEMPT VOC PARTIAL PRESSURE (mm of Hg) @ 20 C: 49.0
VAPOR DENSITY (air = 1): 2.2
WATER ABSORPTION: Appreciable
SOLVENCY PARAMETERS:
HKB (Hydrogen Bonding): 26.9
PKB (Polarity): 37.1
DKB (Dispersion): 35.9
REFRACTIVE INDEX: 1.427
MIXED ANILINE POINT (Acid Insol): 22 C / 72 F
SECTION 10. REACTIVITY DATA
STABILITY
Stable
CONDITIONS TO AVOID
Isolate from oxidizers, heat, sparks, electric equipment, & open flame.
MATERIALS TO AVOID
Isolate from strong oxidizers such as permanganates, chromates, & peroxides.
HAZARDOUS DECOMPOSITION PRODUCTS
Carbon Monoxide, Carbon Dioxide from burning.
HAZARDOUS POLYMERIZATION
Will not occur.
NOTICE
The supplier disclaims all expressed or implied warranties of merchantability or fitness for a specific use, with respect to
the product or the information provided herein, except for conformation to contracted specifications. All information
appearing herein is based upon data obtained from manufacturers and / or recognized technical sources. While the
information is believed to be accurate, we make no representations as to its accuracy or sufficiency. Conditions of use
are beyond our control, and therefore users are responsible for verifying the data under their own operating conditions
to determine whether the product is suitable for their particular purposes and they assume all risks of their use,
handling, and disposal of the product. Users also assume all risks in regards to the publication or use of, or reliance
upon, information contained herein. This information relates only to the product designated herein, and does not relate
REV. 03/2005 5
to its use in combination with any other material or process.
REV. 03/2005 6
|