MATERIAL SAFETY DATA SHEET
SHIELD INSECT REPELLENT
I. PRODUCT AND MANUFACTURER INFORMATION
Product name SHIELD INSECT REPELLENT, AEROSOL
Chemical name
Synonyms
CAS number
Manufacturer Ashburn Chemical Technologies
2911 Rusk
Houston, TX 77003
Emergency phone number 713-425-3000
MSDS prepared by
Date of last revision 7/22/04
II. HAZARDOUS INGREDIENTS
HAZARDOUS CAS % OSHA ACGIH CHEMICAL AND/OR
Optional
COMPONENT NUMBER PEL TLV COMMON NAME(S)
DIETHYL-M-TOLUAMIDE 134-62-3 NE NE
ISOPROPYL ALCOHOL 67-63-0 400 PPM 400 PPM
PROPANE/n-BUTANE 68476-86-8 1000 PPM 600 PPM
REPELLENT 326 136-45-8 NE NE
(All of the ingredients contained in this product are listed on the TSCA inventory.)
III. PHYSICAL AND CHEMICAL CHARACTERISTICS
Boiling point 206 F
Vapor pressure (mm Hg at 20 掳C) 1
Vapor density (air = 1) 1
Solubility in water 58%
Appearance and Odor Clear Spray, Mild Musk Odor
Specific gravity (H2O = 1.0) 0.87
Melting point N/A
Evaporation rate (butyl acetate = 1) 1
IV. FIRE AND EXPLOSION HAZARD DATA
Combustible/Not combustible Combustible
Flammable/Not flammable Flammable
Pyrophoric/Not pyrophoric Not pyrophoric
Explosive/Not explosive Not explosive
Flash point (test method) 130 F (TCC)
Flammable limits (in Air % by volume) LFL: 1 UFL: 6
Extinguishing media Standard chemical fire extinguishers, CO2, Water
Special fire-fighting procedures or equipment Wear self contained breathing apparatus when indicated
Unusual fire and explosion hazards Extremely Flammable. Contents under pressure. Exposure
to temperatures above 120 F may cause bursting
V. REACTIVITY DATA
Material is stable/unstable Stable
Conditions to avoid Temperatures above 120 F
Incompatibility (materials to avoid) Strong Acids, alkalies, oxidizers
Hazardous decomposition or by-products Incomplete combustion may result in carbon monoxide gas
Hazardous polymerization will/will not occur Will not occur
Page 1 of 3
VI. HEALTH HAZARD DATA
Primary route(s) of entry Inhalation, Ingestion
Known Hazards Under 29 CFR 1910.1200
Mutagenic (genetic defects) Not a Hazard
Reproductive Not a Hazard
Systemic Not a Hazard
Teratogenic (birth defects) Not a Hazard
Carcinogen listed in:
NTP (National Toxicology Program) Not a Carcinogen
IARC Monographs Not a Carcinogen
OSHA Not a Carcinogen
Signs and symptoms of exposure
Inhalation Prolonged exposure may cause headache/dizziness, suffocation.
Skin contact Not a primary skin irritant
Eye contact May cause mild to strong irritation if in eyes.
Ingestion May cause nausea. Swallowing may be harmful or fatal
Emergency first aid procedures
Inhalation Remove to fresh air and consult physician.
Skin contact Wash affected area with soap and water.
Eye contact Flush with water for 15 minutes and consult physician.
Do not induce vomiting. Give water and contact physician immediately.
Ingestion
Medical conditions generally aggravated by None known
exposure
Notes to physician
VII. PRECAUTIONS FOR SAFE HANDLING AND USE
Steps to take if released or spilled Wipe up with rag or use an absorbent clay material or towel.
Waste disposal method Dispose of in accordance with federal, state and local guidelines. Do not
puncture or incinerate container. Do not reuse empty container. Wrap
container and place in trash collection.
Precautions for handling and storing Do not use or store near heat or open flame.
Other precautions None
Hazard ratings HMIS
Health 1
Flammability 2
Reactivity 1
Personal protection A
VIII. CONTROL MEASURES
Protective gloves (type and material) NA
Eye protection Safety glasses are recommended whenever chemicals are used.
Other protective clothing or equipment NA
Respiratory protection (specify type) NA
Ventilation and conditions
Local Recommended
Mechanical NA
Other NA
Special NA
Work/hygienic practices Wash hands after use.
Page 2 of 3
IX. ADDITIONAL REGULATORY INFORMATION
SARA hazard category (Section 311 and NONE
312 of the Superfund Amendment and
Reauthorization Act of 1986 (SARA Title
III)
Toxic chemical(s) subject to the supplier NONE
notification requirements of section 313 of
the Superfund Amendment and
Reauthorization Act of 1986 (SARA) and
the requirements of 40 CFR part 372
Ingredient(s) regulated under the Clean Air NONE
Act Section 112 hazardous air pollutants
and subject to all reporting requirements of
CERCLA (Superfund)
NA 鈥? not applicable NR 鈥? not reported ND 鈥? not determined NE 鈥? not established UN 鈥? unknown
The information presented in this MSDS has been compiled from sources deemed reliable. This MSDS is presented in good
faith and believed to be accurate as of the effective date shown above. No warranty, expressed or implied, is given.
Regulatory requirements are subject to change and may differ from one location to another. It is the responsibility of the
buyer to insure compliance with federal, state, provincial and local laws and regulations.
Page 3 of 3
|