Prime Time
Wood Floor Care
WC For Use On:
Wood Quarry Tile Flagstone
Concrete Brick Terrazzo
Waterbased Wood DESCRIPTION
Totally volatile cleaner designed to thoroughly clean and prepare wood
Floor Cleaner
floors, without leaving any residue. Excellent for use prior to applying
waterborne coatings. Conventional floor cleaners leave a detergent
residue that can cause adhesion and wear problems. This product is
an ideal tack rag cleaner for removing soils and excess mop treatment.
DIRECTIONS
FOR DAILY MAINTENANCE BY TACKING: Add 12 to 16 ounces of
concentrate, depending on soil conditions, to a mop bucket and fill with
water. Soak 3 to 4 towels in solution until they are thoroughly wet.
Wring towels out thoroughly and place one towel flat on floor. Place
push broom in middle of towel, pulling front half of towel over top of the
broom, and tack rag the floor. Repeat procedure as towel gets dirty.
FOR DAILY MAINTENANCE BY DAMP MOPPING: Add 12 ounces of
concentrate to mop bucket and fill with water. Wring out and damp mop
floor in usual manner. Do not overwet or flood floor with product.
FOR CLEANING NEWLY SCREENED FLOORS PRIOR TO
FINISHING: Add 12 to 16 ounces of concentrate, depending on soil
conditions, to a mop bucket and fill with water. Soak 3 to 4 towels in
solution until they are thoroughly wet. Follow directions above and
tack the floor. This procedure must be repeated after each screening.
After the final screening, the floor should be tack ragged a second time
with fresh solution and clean towels prior to application of the finish.
PRODUCT SPECIFICATIONS
Color: Light blue Emulsification: Excellent
110oF (TCC)
Odor: Not objectionable Flash Point:
pH: 9.5 - 10.0 Biodegradability: Complete
Viscosity: Water thin Storage/Stability: 2 years
Foam: Low Weight per Gallon: 8.25 lbs./gal.
Abrasives: None Freeze / Thaw Stability: Keep from freezing
Solubility: Complete with water
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
PTC MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 5/99 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Product Name: Prime Time WC
Manufacturer鈥檚 Name:
Misco Products Corporation Generic Name: Waterbased Wood Floor Cleaner
Manufacturer鈥檚 Address: Chemical Family: Solvent Alcohol Blend
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer鈥檚 Phone #: (610) 926-4106
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
Isopropyl Alcohol 67-63-0 5 to 10 400 ppm 400 ppm 500 ppm
2-Butoxyethanol 111-76-2 5 to 10 25 ppm 25 ppm N/A
Ammonium Hydroxide 1336-21-6 < 0.1 25 ppm 25 ppm 35 ppm
Anionic Surfactant N/A 0 to 5
Dye N/A 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): 120 F. (TCC)
Boiling Point (掳F): 180-350 F. Specific Gravity: .989
Upper Explosion Limit: 12.0 Lower Explosion Limit: 2.0
Vapor Pressure: 30mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: CO2, Dry Foam, or Dry Chemical
% Volatile: 99+ pH: 9.5-10.0
Special Firefighting Procedures: Water is very effective.
Solubility in Water: Complete Evaporation Rate (Water=1): >1
Unusual Fire and Explosion Hazards: Drums heated by fire can explode.
Physical Description: Thin blue liquid with solvent odor.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Carbon monoxide possible if burned. Incompatibility (Materials to Avoid): Strong oxidizers.
SECTION 6-STORAGE AND HANDLING INFORMATION
Combustible liquid. Avoid contact with heat, spark or open flame. Keep out of reach of children. For use by trained personnel only. Keep container closed during
storage. For institutional and industrial use only. Avoid contact with eyes, skin and clothing. Avoid breathing of vapors. Use in well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: Use in well-ventilated area.
Skin: Prolonged or repeated contact may cause dermatitis. Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-
Eyes: Eye irritant. Liquid and mist may irritate the eyes, causing redness, tearing, gredients below acceptable limit.
and burning sensation. Protective Gloves: Chemical resistant rubber or neoprene
Inhalation: Vapors may be irritating to the mucous membranes of the nose, throat, Eye Protection: Safety glasses or chemical splash goggles
and lungs. Other Protective Equipment: N/A
Ingestion: May be irritating to the mouth, throat, and gastrointestinal system.
Vomiting and diarrhea expected with large doses.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists. Steps to be taken in Case Material is Released or Spilled: Extinguish all
ignition sources. Open window or doors, ventilate area well. Avoid walking in
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
product. Keep unessential personnel away. Mop up or otherwise absorb and hold
attention.
disposal. Avoid discharge to sewer or open waterways.
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
Waste Disposal Method: Any method in accordance with local, state and federal
Ingestion: Dilute with 2 glasses of water. Seek medical attention if symptoms
laws. Best method is to recycle or reuse for intended purpose. Consult local
persist.
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
river or to ground. Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
Yes - Fire Hazard FOR CONTAINERS > 1 Gallon : Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Health 1
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Cleaning Compound Flammability 2
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound Personal Protection A
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
Exempt None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the
improper handling and use of this product
|