Food Service Products
Sani-512 For Use On:
Disinfectant - Sanitizer - Tables
Floors Glasses
Food Processing
Walls Refrigerators
Deodorizer - Virucide Equipment
Sinks Dishes
Silverware Countertops
FOR DISINFECTING:
USES: Floors, walls, metal surfaces, painted surfaces, exterior bowl surfaces,
empty basins, showers, athletic equipment, garbage cans, lavatory fixtures
and other hard inanimate non-porous surfaces.
APPLICATION: Remove gross filth and soil deposits. Pre-clean all surfaces
prior to disinfection. Thoroughly wet surfaces. Use 1 ounce per gallon of water
for a minimum contact time of 10 minutes in a single application. Can be applied
with a mop, sponge, or cloth as well as spraying or soaking. The recommended
use solution is prepared fresh for each use and then discarded. Rinsing is not
necessary unless floors are to be waxed or polished.
FOR SANITIZING: For use on hard non-porous surfaces such as counter tops,
eating utensils, and drinking glasses. Remove gross filth and soil deposits.
Pre-clean all surfaces prior to sanitizing. Thoroughly wet surfaces. Use 1 ounce
per 4 gallons of water for a minimum contact time of 1 minute in a single
application. Can be applied with mop, sponge or cloth as well as spraying or
soaking The recommended use solution is prepared fresh for each use then
discarded. Drain thoroughly. Do not rinse.
Before use as a sanitizer in federally inspected meat and poultry plants and
dairies, food products and packaging materials must be removed from the room
or carefully protected. A potable water rinse is not required following use of this
compound on previously cleaned hard surfaces provided that the surfaces are
adequately drained for contact with food so that little or no residue remains.
RESTAURANT AND BAR USE: For use as a sanitizer on dishes, glassware,
DESCRIPTION silverware, cooking utensils, wash with detergent, rinse thoroughly and
An effective sanitizer, disinfectant, and deodorant for use in meatrooms, immerse in a solution (1 ounce per 4 gallons of water) for at least 1 minute.
dairies, poultry plants, bars, restaurants, cafeterias, etc. For use on BEVERAGE PLANTS: For sanitizing of bottling or pre-mix dispensing
countertops, eating utensils, drinking glasses, or any hard inanimate, equipment, after cleaning thoroughly rinse equipment with cold or luke warm
nonporous surface. Will sanitize at a use dilution of 1/4 ounce per gallon of water. Fill equipment with solution of 1 oz. per 4 gallons of water (200 ppm
water. No rinsing is required. Effective against salmonella choleraesuis, quat). Allow the solution to remain in contact with equipment for at least 1 minute
staphylococcus aureus, and pseudomonas aeruginos. or until operations resume at which time the sanitizing solution should be
drained from the system. To insure the removal of flavors, it is
DIRECTIONS
suggested that during changeover between products, the system should
It is a violation of federal law to use this product in a manner inconsistent with
be cleaned, rinsed and flushed with the sanitizing solution for at least 1
its labeling.
minute. Allow to drain completely before using.
PRODUCT SPECIFICATIONS
Active Ingredients: 10% Solubility: Complete with water
Color: Clear Rinsability: No rinsing is required
Odor: None Flash Point: None (waterbased)
Base: Quaternary ammonium Hard Water Tolerance: 750 ppm
chloride Biodegradability: Complete
pH: 7.5 - 8.0 Storage/Stability: 2 years
Viscosity: Water thin Weight per Gallon: 8.28 lbs./gal.
Foam: Low to moderate Freeze / Thaw Stability: Keep from freezing
Phosphate Content: None
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
SAN MATERIAL SAFETY DATA SHEET N/A= Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 4/01 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Product Name: Sani-512 Supplier鈥檚 Name:
Manufacturer鈥檚 Name:
Misco Products Corporation Generic Name: Sanitizer, Disinfectant, &
Deodorant
Manufacturer鈥檚 Address: Supplier鈥檚 Address:
1048 Stinson Drive Reading, PA 19605 Chemical Family: Quaternary Detergent
Manufacturer鈥檚 Phone #: (610) 926-4106 Formula: Proprietary Supplier鈥檚 Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
Dimethyl benzyl ammonium chloride 68391-01-5 5.0
Dimethyl ethyl benzyl ammonium chloride 68956-79-6 5.0
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): N/A
Boiling Point ( F): 210 F. Specific Gravity: 0.97 鈥? 0.99
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: N/A
% Volatile: 90 pH: 6.0-8.0
Special Firefighting Procedures: Non Flammable
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Unusual Fire and Explosion Hazards: N/A
Physical Description: Water thin liquid with characteristic odor.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Will not occur. Incompatibility (Materials to Avoid): Strong oxidizers or reducing agents
SECTION 6-STORAGE AND HANDLING INFORMATION
Keep out of reach of children. For use by trained personnel only. Keep container closed during storage. For institutional and industrial use only. Avoid contact with
eyes, skin and clothing. Wear protective eyewear and gloves when using product. Avoid breathing of mists. Use in well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Respiratory Protection: No special requirements.
Effects of Overexposure:
Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-
Skin: Skin irritant. Prolonged or repeated contact may cause dermatitis.
gredients below acceptable limit.
Eyes: Severe eye irritant. Liquid and mists may injure the eyes, causing corneal
Protective Gloves: Chemical resistant rubber or neoprene.
damage.
Eye Protection: Safety glasses or chemical splash goggles.
Inhalation: Inhalation of mist are irritating to nose, throat and lungs, causing
Other Protective Equipment: Eyewash station should be available.
coughing or choking sensation
Ingestion: May be irritating to the mouth, throat, and gastrointestinal system.
Burning, pain, and diarrhea expected with large doses.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Steps to be taken in Case Material is Released or Spilled: Floors will become
Skin: Remove contaminated clothing. Flush affected areas with large quantities of
slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
water. Seek medical attention if irritation persists.
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
Waste Disposal Method: Any method in accordance with local, state and federal
attention.
laws. Best method is to recycle or reuse for intended purpose. Consult local
Inhalation: Remove victim to fresh air. Seek medical attention of irritation
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
persists.
river or to ground. Rinse container thoroughly before discarding in trash.
Ingestion: Give large quantities of egg whites, gelatin solution or water. Seek
medical attention immediately. Avoid Alcohol.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Identification System
Corrosive liqu id, basic, Organic,
N.O.S. (Quaternary Ammonium Compound), 8, UN3267, PGIII
No - Sudden Release of Pressure Hazard Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Corrosive liqu id, basi c, Organic, Flammability 0
N.O.S. (Quaternary Ammo nium Co mpound), 8, UN3267, PGIII (Lt d. Qt y)
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : ORM-D Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the
improper handling and use of this product
|