VTW
Vehicle Cleaners
Vehicle & For Use On:
Transportation
Trucks Trailers
Buses
Automobiles Boats
Trains
Travel Trailers
Wash DESCRIPTION
This unique product removes dirt, grime, and traffic film in one
application. Instantly removes that tough layer of road soil and residue
that seems to bond to vehicle surfaces. Can be applied with a pressure
washer, steam cleaner, automatic car wash, or other available
methods. Cleans right down to the paint without manual brushing. If
using automatic brushes, this product will clean effectively and often
faster than currently available products without brush damage.
DIRECTIONS
Completely effective in hard or soft, hot or cold water. This product must
be diluted with water before use. Not to be used for hand-washing of
vehicles. Do not allow product to dry on surface. For best results on
vertical surfaces, apply product from bottom up. Pressure rinse from
bottom up also. Final rinse from top down.
LIGHT SOIL: Use 1 to 2 ounces per gallon of water.
AVERAGE SOIL: Use 2 to 4 ounces per gallon of water.
HEAVY SOIL: Use 4 to 6 ounces per gallon of water.
More or less cleaner can be used as required by soiling conditions.
After cleaning, rinse thoroughly with water to wash away the loosened
soils and leave the vehicle surface beautifully clean and bright.
PRODUCT SPECIFICATIONS
Base: Sequestering agents Emulsification: Excellent
Color: Blue Detergency: Excellent
Odor: Mild Rinsability: Excellent
pH: 12.5 - 13.0 Flash Point: None
Viscosity: Slightly viscous Biodegradability: Complete
Foam: Low to moderate Storage/Stability: 2 years
Abrasives: None Weight per Gallon: 8.85 lbs./gal.
Phosphate Content: None Freeze / Thaw Stability: Keep from freezing
Solubility: Complete with water
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
VTW MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 5/99 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Product Name: VTW
Manufacturer's Name:
Misco Products Corporation Generic Name: Vehicle & Transportation Wash
Manufacturer's Address: Chemical Family: Detergent Blend
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer's Phone #: (610) 926-4106
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
Tetrasodium EDTA 64-02-8 5 to 10
Nonionic Surfactant 9016-45-9 20 to 25
Anionic Surfactant 1300-72-7 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): N/A
Boiling Point (掳F): 210 F. Specific Gravity: 1.095
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: N/A
% Volatile: 65+ pH: 12.5-13.0
Special Firefighting Procedures: Non Flammable
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Unusual Fire and Explosion Hazards: N/A
Physical Description: Thin clear liquid with characteristic odor.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Will not occur. Incompatibility (Materials to Avoid): Strong acids and oxidizers.
SECTION 6-STORAGE AND HANDLING INFORMATION
Keep out of reach of children. For use by trained personnel only. Keep unauthorized personnel away when applying by sprayer. Keep container closed during storage.
For institutional and industrial use only. Avoid contact with eyes, skin and clothing. Avoid breathing of mists. Use in well-ventilated area. Wear protective eyewear
where danger of mist contact may occur. Wear rubber gloves when handling concentrate. Wear protective clothing where danger of mist contact may occur.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: NIOSH/MSHA Approved HEPA cartridge for mists
Skin: Skin Irritant. Prolonged or repeated contact will cause dermatitis. Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-
Eyes: Eye irritant. May cause redness or swelling, possible damage. gredients below acceptable limit.
Inhalation: Breathing of mists may cause irritation to nose, throat and lungs. Protective Gloves: Chemical resistant rubber or viton.
Ingestion: May be irritating to the mouth, throat, and gastrointestinal system. Eye Protection: Chemical splash goggles or full-face shield recommended.
Vomiting and diarrhea expected with large doses. Other Protective Equipment: Eyewash station should be provided nearby.
Protective outerwear should be worn where danger of mist contact may occur.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists. Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
attention.
Waste Disposal Method: Any method in accordance with local, state and federal
Inhalation: Remove victim to fresh air. Seek medical attention if symptoms
laws. Best method is to recycle or reuse for intended purpose. Consult local
persist.
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
Ingestion: Dilute with 2 glasses of water. Seek medical attention if symptoms
river or to ground. Rinse container thoroughly before discarding in trash.
persist.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
No - Fire Hazard FOR CONTAINERS > 1 Gallon : Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS :Cleaning Compound Flammability 0
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the
improper handling and use of this product
|