Crystal Cote
Wood Floor Care
HS
For Use On:
Sealed Wood Sealed Concrete
Sealed Cork Parquet Floors
DESCRIPTION
A high solids oil modi铿乪d polyurethane 铿乶ish designed for use on sports,
VOC Compliant commercial and residential wood 铿俹ors. Produces outstanding durability
and resistance to scuffs, spills and stains. Leaves surface with an ex-
tremely rich high gloss that dirt and grime can鈥檛 possibly penetrate. High
Polyurethane solids makes this product able to meet the strict VOC (Volatile Organic
Compounds) requirements which have been established in many states
Wood Finish throughout the country. Easy to apply, it is compatible over a wide variety
of conventional solvent based and water-based coatings (provided these
coatings are cured, bonded and the 铿俹or is properly prepared).
Manufacturer鈥檚 Recommendation: This coating is to be
applied without thinning.
VOC Content = 443 grams/liter
DIRECTIONS
ON NEW OR NEWLY PREPARED FLOORS: Use a good quality poly-
urethane sealer, following the directions for that product. Allow to dry
thoroughly.
ON NEWLY SEALED FLOORS: Buff with a #120 abrasive screen. Clean
surface thoroughly with a tack rag and waterless cleaner and allow to dry.
Apply 铿乶ish using a synthetic or lamb鈥檚 wool applicator, pressure sprayer
or gravity fed applicator. If more than one coat is desired, allow 6 to 8 hours
dry time between coats. No screening is required if recoating is done within
24 hours. Allow 72 hours cure time before allowing any foot traf铿乧 on 铿俹ors
(no dances or similar events for at least one week).
NOTE: Best results are obtained with adequate ventilation and 铿俹or
temperature above 60掳F and below 95掳F. Avoid direct drafts on 铿俹or
while 铿乶ishing.
PRODUCT SPECIFICATIONS
Removability: With conventional
Non-volatile solids: 50.0卤0.5%
urethane strippers
Gardner Color: (Typical)..................4
Drying Properties: Set to touch - 1-2 hrs.
(Maximum)............12
Recoat - 6-8 hrs.
Odor: Solvent
Dry hard - 72 hrs.
Type: Oil modi铿乪d urethane
Recoatability: Excellent (follow directions)
Solvent Systems: Mineral spirits
VOC Content: 443 gm/liter
o
Flash Point: 106 F (TCC)
Storage/Stability: 2 years
Viscosity: A-C, Gardner
Freeze/Thaw Stability: Keep from freezing
Slip Resistance: Greater than 0.50
Weight per Gallon: 7.45 lbs./gal.
Sward Hardness: Greater than 30
400-500 ft2 per gal.
Coverage:
Chemical Resistance: Excellent
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
U50 MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Effective Date: 12/07 Revision: n/a
Prepared by: Regulatory Affairs Dept. (Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer鈥檚 Name: Product Name: Crystal Cote HS Supplier鈥檚 Name:
Misco Products Corporation Generic Name: Polyurethane Wood Finish
Manufacturer鈥檚 Address: Supplier鈥檚 Address:
Chemical Family: Solvent Urethane Blend
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer鈥檚 Phone #: (610) 926-4106 Supplier鈥檚 Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Petroleum Distillates 8052-41-3 45 to 50 300 ppm 100 ppm N/A
Oil Modified Urethane Resin N/A 50 to 55
98-56-6 10 to 15 Not Established Not Established 25 ppm
Oxsol庐 100
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): 106 F. (TCC)
Boiling Point (掳F): 300 F. Initial Specific Gravity: 0.966
Upper Explosion Limit: 6.0 Lower Explosion Limit: 1.0
Vapor Pressure: <10mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: Foam, CO2, dry chemical.
% Volatile: 45+ pH: N/A
Special Firefighting Procedures: Do Not Use Water.
Solubility in Water: Nil Evaporation Rate (Water=1): <1
Unusual Fire and Explosion Hazards: Drums heated by fire can explode.
Physical Description: Moderately viscous yellow liquid with characteristic odor.
VOC Content (Subpart D 搂59.406) : 443 grams/liter
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: May occur through oxidation, leading to exothermic
reaction. Heat generated by oxidation may lead to spontaneous combustion of materials
such as rags, paper towels, etc., used for clean-up
Hazards Decomposition Products: Carbon monoxide possible if burned. Incompatibility (Materials to Avoid): Strong oxidizers.
SECTION 6-STORAGE AND HANDLING INFORMATION
Combustible liquid. Avoid contact with heat, spark or open flame. Eye irritant. May cause skin irritation. Keep out of reach of children. For use by trained personnel only. Keep
unauthorized personnel away when applying to floor. Keep container closed during storage. For institutional and industrial use only. Avoid contact with eyes, skin and clothing.
Wear rubber gloves when handling. Wear protective boots when applying to floors. Avoid breathing of vapors. Use in well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: NIOSH approved hydrocarbon cartridge or self-contained
Skin: Prolonged or repeated contact may cause irritation, defatting, or dermatitis. apparatus when used in enclosed areas.
Eyes: Eye irritant. May cause redness, swelling, or blurred vision. Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-
gredients below acceptable limit. Open doors and windows when handling and during
Inhalation: May be irritating to the nose, throat, and lungs. Prolonged breathing can
drying period.
cause headache, nausea, dizziness, weakness, and fatigue. Some reports have associated
repeated and prolonged occupational overexposure to solvents with permanent brain and Protective Gloves: Solvent proof rubber recommended.
nervous system damage. Eye Protection: Safety glasses recommended.
Ingestion: Can cause irritation of the gastrointestinal tract, nausea, vomiting, and Other Protective Equipment: Eye wash station should be available nearby. Protective
diarrhea. Aspiration of material into the lungs can cause pneumonitis. clothing and footwear (rubber boots) when using on floors.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Remove contaminated clothing. Wash with soap and water. Seek medical attention Steps to be taken in Case Material is Released or Spilled: Shut off all ignition
if irritation persists. sources. Ventilate area well. Floors will become slippery. Avoid walking in product.
Keep unessential personnel away. Mop up or otherwise absorb and hold disposal.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical attention.
Avoid discharge to sewer or open waterways.
Inhalation: Get to fresh air. If breathing is difficult, give oxygen. Seek medical attention
Waste Disposal Method: Any method in accordance with local, state and federal laws.
if symptoms persist.
Best method is to recycle or reuse for intended purpose. If discarded, this material and
Ingestion: Do not induce vomiting. Seek medical attention immediately.
containers should be treated as hazardous waste based on the characteristic of ignitability
as defined under federal RCRA regulations (40 CFR 261). Materials used to absorb
product should be soaked in water-filled containers or rinsed with water prior to
discarding in trash receptacles. Do not dispose of into storm drain, stream, river or to
ground. Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Domestic Shipping Information:
Yes - Fire Hazard FOR CONTAINERS > 1 Gallon : Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Cleaning Compound Flammability 2
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and
of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
|