Cleaner/Degreasers
For Use On:
Tables
Tools
Floors
Porcelain
Machinery
Walls
Stainless SteelPlastic
Desks
Concrete
Vinyl
Engines
DESCRIPTION
A ready to use cleaner and degreaser formulated to remove
grease, oil, carbon, or any other industrial soil from concrete,
machinery, engines, floors, walls, etc. Non-toxic, non-
corrosive, non-flammable. Can be used on all surfaces not
harmed by water.
DIRECTIONS
Simply spray on to surface to be cleaned, wait several
minutes and wipe off with a clean absorbent cloth, towel
or sponge. For heavy soils, allow to soak several minutes,
then agitate with brush, then rinse clean. Avoid contact with
windows or other glass surfaces.
This product meets the maximum content requirements for
Volatile Organic Compounds (VOCs) as established by State
and Federal regulations.
PRODUCT SPECIFICATIONS
Color: Detergency:
Green Excellent
Odor: Biodegradability:
Characteristic odor Complete
pH: Solubility:
12.0 鈥? 13.0 Complete with water
Viscosity: Flash Point:
Water thin None
Foam: Storage/Stability:
Moderate 2 years
Emulsification: Weight Per Gallon:
Excellent 8.74 lbs. per gallon
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
X05 MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 01/06 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer聮s Name: Product Name: Formula X05 Supplier聮s Name:
Misco Products Corporation Generic Name: Ready-to-Use Heavy Duty Spray
Manufacturer聮s Address: Supplier聮s Address:
Cleaner
1048 Stinson Drive Reading, PA 19605 Chemical Family: Alkaline Detergent
Manufacturer聮s Phone #: (610) 926-4106 Supplier聮s Phone #:
Formula: Proprietary
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
2-Butoxyethanol 111-76-2 0 to 5 25 ppm 25 ppm N/A
Potassium Alkyl Aryl Sulfonate 27177-77-1 0 to 5
Potassium Tall Oil Soap 61790-44-1 0 to 5
Nonionic Surfactant 9016-45-9 0 to 5
Monoethanolamine 141-43-5 0 to 5
Sodium Metasilicate 6834-92-0 0 to 5
Fragrance N/A <1
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): None (waterbased)
Boiling Point (锟紽): 212 F. Specific Gravity: 1.047
Upper Explosion Limit: N/A Lower Explosion Limit: N/A
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: N/A
% Volatile: 85+ pH: 12.0 聳 13.0
Special Firefighting Procedures: Non Flammable
Solubility in Water: Complete Evaporation Rate (Water=1): <1
Unusual Fire and Explosion Hazards: N/A
Physical Description: Thin green liquid with characteristic odor.
VOC Content: 3.0% (wt/wt), 0.26 lbs/gal., 15.5 grams/liter
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Incompatibility (Materials to Avoid): Strong acids.
SECTION 6-STORAGE AND HANDLING INFORMATION
WARNING: Eye Irritant. May cause skin irritation with prolong or repeated contact. Avoid contact with eyes, skin and clothing. Wear rubber gloves, chemical splash
goggles and protective outerwear when handling. Avoid breathing of vapors or mists. Use in well-ventilated area. Keep out of reach of children. For use by trained
personnel only. Keep container closed during storage. For institutional and industrial use only.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: Use in well ventilated area.
Skin: Moderate skin irritant. Prolonged or repeated contact may cause redness, Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-
dermatitis. gredients below acceptable limit.
Eyes: Eye irritant. Liquid and mists will cause tearing, redness, burning sensation. Protective Gloves: Chemical resistant rubber or neoprene.
Inhalation: Vapors and mists may be irritating to mucous membranes in the nose, Eye Protection: Safety glasses or chemical splash goggles.
throat, and lungs. Other Protective Equipment: Wear protective rubber footwear when using on
Ingestion: Irritating to the mouth and throat. May cause headache, nausea, abdominal
floor. Wear protective outerwear when danger of mist contact may occur.
pain, vomiting, and diarrhea. Excessive amounts may cause collapse.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists. Steps to be taken in Case Material is Released or Spilled: Floors will become
slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
Eyes: Immediately flush with large quantities of water, holding eyelids open. Seek
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
medical attention if irritation persists.
Waste Disposal Method: Any method in accordance with local, state and federal
Inhalation: Get to fresh air. Seek medical attention if irritation persists.
laws. Best method is to recycle or reuse for intended purpose. Consult local
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical
authorities for disposal in public sewer. Do not dispose of into storm drain, stream,
attention immediately.
river or to ground. Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information: HMIS Hazardous Materials
No - Fire Hazard FOR CONTAINERS > Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS: Cleaning Compound Flammability 0
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON: Cleaning Compound Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
111-76-2 Glycol Ether 3% max.
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this information,
or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the health and safety
information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
|