All ingredients are listed on the TSCA Inventory. n.a.= not applicable / n.e.=not established
SECTION II -Physical and Chemical Characteristics
BOILING POINT: > 200掳C
VOC #/gal. : 1.126
VAPOR DENSITY: Heavier than air air = 1
DENSITY OF COATING:
VAPOR PRESSURE: n.e.
MELTING POINT: n.a.
SPECIFIC GRAVITY: > 1.0 water = 1
EVAPORATION RATE: n.a.
WATER REACTIVE: No
SOLUBILITY IN WATER: Insoluble
APPEARANCE AND ODOR: Green translucent liquid with cumene odor.
SECTION III - Fire and Explosion Hazard Data
FLASH POINT: > 200掳F PMCC
AUTOIGNITION TEMPERATURE: not determined
UEL: not determined
FLAMMABILITY LIMITS % IN AIR: LEL: not determined
EXTINGUISHER MEDIA: Use carbon dioxide, foam, dry chemical and/or water spray.
Wear a NIOSH approved self-contained breathing apparatus operated in pressure-demand or other positive
SPECIAL
pressure when fighting fires. Sealed containers may rupture explosively if exposed to heat.
FIREFIGHTING
PROCEDURES:
UNUSUAL FIRE Combustion of product may produce oxides of carbon.
HAZARDS AND
CONDITIONS TO
AVOID:
PRODUCT: ND150012 (150) Green Wicking Grade
SECTION IV - Reactivity Hazard Data
STABILITY: stable: X unstable:
HAZARDOUS POLYMERIZATION: may occur: will not occur: X
CONDITIONS As supplied; avoid unintentional mixing of material with other and storage temperatures exceeding 120掳F and strong
TO AVOID: oxidizing agents.
INCOMPATIBILITY: Avoid strong oxidizing agents and storage temperatures exceeding 120掳F. Avoid exposure to steel or rust.
HAZARDOUS Combustion yields oxides of carbon and possible toxic fumes.
DECOMPOSITION
PRODUCTS:
SECTION V - Health Hazard Data
X X
PRIMARY ROUTES OF ENTRY: X
INHALATION: INGESTION: SKIN ABSORPTION:
EYE CONTACT: A primary route of exposure that will cause eye irritation characterized by excessive tearing, redness and blinking.
May cause corneal damage.
FIRST AID: Flush eyes with generous amounts of water for 20-30 minutes, lifting both upper and lower eyelids occasionally.
Get medical attention.
A primary route of exposure that may cause moderate skin irritation and allergic skin reaction. May cause rash,
SKIN
redness, swelling and blistering (symptoms may be delayed)
CONTACT:
Thoroughly wash exposed area with soap and water. If irritation develops, seek medical attention. Launder
clothing before reuse.
FIRST AID:
Vapors generated at elevated temperatures, may cause respiratory tract irritation. Symptoms may include
INHALATION:
coughing, mucous production and shortness of breath.
If overcome by exposure, victim should be removed to fresh air immediately. Give artificial respiration as needed.
FIRST AID:
Get immediate medical attention.
INGESTION: Ingestion may cause irritation of the gastrointestinal tract and depression of the central nervous system leading to
loss of consciousness.
FIRST AID: Do no induce vomiting. Immediately seek medical attention.
Material or its emissions may defat skin, cause contact dermatitis and thereby aggravate existing skin or systemic
CHRONIC
diseases.
EFFECTS:
Carcinogenic: Contains saccharin which has been determined to cause cancer in laboratory animals.
PRODUCT: ND150012 (150) Green Wicking Grade
Component Oral LD50 Dermal LD50 Inhalation LC50
not determined
not determined
Methacrylate monomer not determined
not determined
not determined
not determined
Saccharin
700 ppm (Rat)
Severe irritation (delayed)
Cumene hydroperoxide 800-1600 mg/Kg (Rat)
not determined
not determined
not determined
Alkyl toluidine
not determined
not determined
not determined
Aromatic amine
SECTION VI - Control and Protective Measures
RESPIRATORY Wear NIOSH/MSHA approved respirator. Work in a well ventilated area.
PROTECTION:
PROTECTIVE Use rubber or vinyl.
GLOVES:
EYE PROTECTION: Wear NIOSH approved safety glasses.
VENTILATION LOCAL EXHAUST: X MECHANICAL: SPECIFIC:
TO BE USED: OTHER (specify):
PROTECTIVE CLOTHING Wear impervious clothing to prevent repeated, prolonged skin contact.
AND EQUIPMENT:
Practice good personal hygiene and wash hands after handling product.
HYGIENIC WORK
PRACTICES:
SECTION VII - Precautions for Safe Handling and Spill/Leak Procedures
STEPS TO BE TAKEN IF MATERIAL IS SPILLED OR RELEASED:
Absorb loose material on inert filler and place in suitable container for proper disposal.
Dispose of material in accordance with local, state and federal regulations.
WASTE DISPOSAL
METHODS:
Avoid prolonged skin contact. Store product in a cool dry place, away from light.
SAFE HANDLING
AND STORAGE:
OTHER PRECAUTIONS AND SPECIAL HAZARDOUS INFORMATION:
This material contains inhibitors which upon depletion can result in an excessive thermal reaction.
RECOMMENDED 2 1 1 C
HEALTH FLAMMABILITY REACTIVITY PERSONAL
NFPA/HMIS PROTECTION
note: ratings may differ according to application, environment, and physical state.
RATING
PRODUCT: ND150012 (150) Green Wicking Grade
NOTES:
DOT Proper Shipping Name:
Not Regulated
SECTION 313 SUPPLIER NOTIFICATION
Detaching this notification from the Material Safety Data Sheet is prohibited by law and any copying or
distribution of same requires this attachment be included.
This product contains the following toxic chemicals subject to the reporting requirements of section 313
of the Emergency Planning and Community Right-To-Know Act of 1986 and 40 CFR 372:
CAS # CHEMICAL NAME % BY WEIGHT
80-15-9 Cumene hydroperoxide 5.6
107-21-1 Ethylene Glycol
This product contains the following materials that under California Proposition 65 of the Safe Drinking Water and Toxic
Enforcement Act of 1986 are recognized to cause cancer or reproductive toxicity.
Cancer Reproductive cancer Reproductive
Concentration &
Material CAS # agent Toxin
Agent Toxin
%
Stud Grade is a trademark of ND Industries庐, Inc. Vibra-TITE is a trademark of ND Industries, Inc.
The information contained herein is based on the data available to us and is believed to be correct. However, ND Industries庐,
Inc. makes no warranty, expressed or implied regarding the accuracy of these data or the results to be obtained from the use
thereof. Information is supplied upon the condition that the persons receiving same will make their own determination as to its
suitability for their properties prior to use. Since conditions of use are beyond our control, all risks are assumed by the user.
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP