Material Safety Data Sheet
SECTION 1: PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME: Super Fuel Booster
MANUFACTURER: XCELPLUS INTERNATIONAL INC
.
ADDRESS: 5041 General Puller Hwy Saluda, Virginia 23149
PRODUCT INFORMATION: 804-758-9684
EMERGENCY PHONE: (888) 511-8891
FAX: 804-758-9684
CHEMICAL NAME: Not Applicable
CHEMICAL FAMILY: Hydrocarbon
CHEMICAL FORMULA: Proprietary
PRODUCT USE: Gasoline Additive used to increase octane number.
APPROVED BY: M Wright February 1, 2005
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS
INGREDIENT CAS NO. EXPOSURE LIMITES
0.2 mg/M3 PEL as Mn (OSHA)
Methylcyclopentadienyl Manganese 12108-13-3
Tricarbonyl
Proprietary Polybutene Proprietary Not Available
Kerosene 8008-20-6 Not Available
Nitromethane 75-52-5 100 ppm (OSHA PEL);
20 ppm (ACGIH TLV)
MSDS No: XCP0205G002
Material Safety Data Sheet
February 1, 2005 Super Fuel Booster
SECTION 3: HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW: Orange liquid with aromatic odor. (See Section 9). Avoid contact with eyes and
excessive contact with skin (See Section 3 below). Avoid contact with strong oxidizing agents. Protect against
decomposition products of oxides of carbon.
HMIS RATING: HEALTH: 2 FLAMMABILITY: 2 REACTIVITY: 0 PPE: B
ROUTES OF ENTRY: Inhalation, skin contact, and swallowing.
POTENTIAL HEALTH EFFECTS:
EYES: Eye irritation
SKIN: Skin irritation.
INGESTION: Vomiting may result. Pulmonary aspiration hazard if vomiting occurs
INHALATION: Irritation of the respiratory tract; headache, nausea dizziness, weakness and fatigue.
ACUTE HEALTH HAZARDS: Breathing - Irritation of the respiratory tract; headache, nausea dizziness, weakness
and fatigue. Extreme exposure can result in unconsciousness and even respiratory arrest. Eye Contact - Eye irritant.
Skin Contact - Prolonged and repeated skin contact may cause defatting and dermatitis. Swallowing -Vomiting may
result. Pulmonary aspiration hazard if vomiting occurs.
CHRONIC HEALTH HAZARDS: Reports have associated repeated and prolonged occupational overexposure to
hydrocarbon solvents with permanent brain and nervous system damage.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: None when used in accordance
with the Special Protection Information (Section VIII).
SECTION 4: FIRST AID MEASURES
EYES: Flush immediately with large amounts of water for at least 15 minutes. Get medical assistance if irritation
persists.
SKIN: Wash affected area with soap and water. Remove soiled clothing. Get medical assistance if irritation persists.
Wash clothing before reuse.
INGESTION: DO NOT INDUCE VOMITING. CONSULT A PHYSICIAN IMMEDIATELY. Aspiration of
vomitus can cause chemical pneumonitis that can be fatal.
INHALATION: If you experience difficulty in breathing, leave the area to obtain fresh air. If continued difficulty is
experienced, summon medical assistance immediately. If breathing ceases, restore using approved
CPR techniques and summon medical assistance immediately.
NOTES TO PHYSICIANS OR FIRST AID PROVIDERS: Treat as any exposure to any hydrocarbon based
material (See Section 3 for observable signs/symptoms).
MSDS No: XCP0205G002 -2-
Material Safety Data Sheet
February 1, 2005 Super Fuel Booster
SECTION 5: FIRE FIGHTING MEASURES
FLAMMABLE PROPERTIES: Flash Point: > 120 0F (Method: T.C.C.)
Burn Rate: Unknown
FLAMMABLE LIMITS: Lower Flammable Limit: Not Established.
Upper Flammable Limit: Not Established.
FLAMMABILITY CLASSIFICATION: Not Established.
AUTOIGNITION TEMPERATURE: Not Established.
HAZARDOUS COMBUSTION PRODUCTS: Carbon Monoxide and Carbon Dioxide.
EXTINGUISHING MEDIA: Carbon dioxide (CO2), dry chemical, foam or other National Fire Protection
Association (NFPA) approved method for treating a Class B fire.
ADDITIONAL CONSIDERATIONS: None.
SPECIAL FIRE FIGHTING INSTRUCTIONS: Summon professional firefighters. Use full protective equipment
including self-contained breathing apparatus. Water spray may be ineffective. If water is used, fog nozzles are
preferable. If exposed to fire or extreme heat, water should be used to cool closed containers and prevent pressure
build-up or possible auto-ignition.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Keep containers tightly closed. Isolate from heat and flame.
Due to pressure build-up, closed containers exposed to extreme heat may explode. Never use a welding or cutting
torch on or near container (even empty) as product or its residue may ignite. During emergency conditions,
overexposure to decomposition products may cause a health hazard. Symptoms may not be immediately apparent.
Obtain medical attention.
NFPA RATING:
HEALTH: 2 FLAMMABILITY: 2 REACTIVITY: 0 PROTECTIVE EQUIPMENT: B
SECTION 6: ACCIDENTAL RELEASE MEASURES
Remove all sources of ignition (flames, hot surfaces, and electrical, static or frictional sparks). Do not smoke. Prevent
breathing of vapors. Ventilate area. Before attempting to clean up, refer to hazard caution information in other
sections of this material safety data sheet. Dike and contain spilled material and remove with inert absorbent and non-
sparking tools. Store in closed container until product can be properly disposed of. Dispose of in accordance with
local, state and federal regulations. Incinerate only in an approved facility. Do not incinerate closed containers.
CERCLA (SUPERFUND) REPORTABLE QUANTITY (in lbs.): Refer to Section 311 of The Clean Water Act.
VOLATILE ORGANIC COMPOUNDS (VOC): Approx. 99%
MSDS No: XCP0205G002 -3-
Material Safety Data Sheet
February 1, 2005 Super Fuel Booster
SECTION 7: HANDLING AND STORAGE
HANDLING: Keep away from heat, flame and sparks. Do not smoke. Prevent build-up of vapors by maintaining
continuous flow of fresh air.
STORAGE: Do not store above 120oF or near fire of open flame. Store large quantities in buildings to comply with
OSHA 1910.106. Keep container closed when not in use. Do not transfer contents to bottles or other unlabelled
containers. Do not reuse empty containers. Keep out of reach of children.
INCOMPATIBLE MATERIALS: Strong oxidizers.
VENTILATION: Use with adequate ventilation. Use good engineering practices to establish ventilation.
SPECIAL PACKAGING MATERIALS: Not applicable
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS: Use with adequate ventilation.
EYE / FACE PROTECTION: Use chemical goggles; solvent impermeable clothing should be worn if contact is
likely; maintain ready access to eye bath and safety shower.
SKIN PROTECTION: Use Neoprene or equivalent gloves.
RESPIRATORY PROTECTION: When used in restricted ventilation areas, wear NIOSH/MDHS approved
chemical/mechanical filters designed to remove a combination of particulates and vapor. When used in confined areas,
wear NIOSH/MSHA approved air supply respirators or hoods. Follow respirator manufacturer's directions for
respirator use. If respirators are used, a program should be established to assure compliance with OSHS Standard 29
CFR 1910.134. Use product only with adequate ventilation. Use either local exhaust or mechanical means to meet
TLV requirements. Ventilation must be sufficient to limit employee exposure at, or below applicable health and safety
standards. Heavy solvent vapors should be removed from lower levels of work areas.
EXPOSURE GUIDELINES: (See Section 2).
MSDS No: XCP0205G002 -4-
Material Safety Data Sheet
February 1, 2005 Super Fuel Booster
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE: Orange Liquid
ODOR: Aromatic
PHYSICAL STATE: Liquid
pH: Not Available
> 250 0F
BOILING POINT:
MELTING POINT: Not Applicable
FREEZING POINT: Not Available
MOLECULAR WEIGHT: Not Available
VAPOR PRESSURE: Not Available
VAPOR DENSITY (AIR = 1): Not Available
% VOLATILES BY VOLUME: Not Available
EVAPORATION RATE: Less than ether
SPECIFIC GRAVITY (H2O = 1): 0.851
SOLUBILITY IN WATER: Negligible
SECTION 10: STABILITY AND REACTIVITY
CHEMICAL STABILITY: Product is stable
CONDITIONS TO AVOID: Heat, sparks, flames.
INCOMPATIBILITY (MATERIAL TO AVOID): Strong oxidizing agents.
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: Thermal decomposition may yield carbon monoxide
and dioxide.
HAZARDOUS POLYMERIZATION: Will not occur.
MSDS No: XCP0205G002 -5-
Material Safety Data Sheet
February 1, 2005 Super Fuel Booster
SECTION 11: TOXICOLOGICAL INFORMATION
EYE EFFECTS: Eye irritation
SKIN EFFECTS: Skin irritation; Prolonged and repeated skin contact may cause defatting and dermatitis.
INGESTION EFFECTS: No data
INHALATION EFFECTS: No data
SUBCHRONIC EFFECTS: No data
CHRONIC EFFECTS/CARCINOGENICITY: No data
EPIDEMIOLOGY: No data
TERATOLOGY: No data
REPRODUCTIVE EFFECTS: No data
NEUROTOXICITY: No data
MUTAGENICITY: No data
SYNERGISTIC PRODUCTS: No data
SECTION 12: ECOLOGICAL INFORMATION
ECOTOXICITY: No data
ENVIRONMENTAL FATE: No data
PHYSICAL/CHEMICAL: (See Sections 9 and 10)
SECTION 13: DISPOSAL CONSIDERATIONS
Dispose of in accordance with local, state and federal regulations. Incinerate only in an approved facility. Do not
incinerate closed containers.
MSDS No: XCP0205G002 -6-
Material Safety Data Sheet
February 1, 2005 Super Fuel Booster
SECTION 14: TRANSPORT INFORMATION
DOT SHIPPING NAME: Flammable Liquid, n.o.s. (contains Kerosene,
Methylcyclopentadienyl Manganese Tricarbonyl)
DOT HAZARD CLASS/DESCRIPTION: 3
DOT LABEL: Flammable Liquid
DOT PLACARD: Flammable Liquid
DOT UN/NA NUMBER: UN1993
DOT PACKING GROUP III
DOT PRODUCT RQ: Not Available
IMO CLASSIFICATION: Not Available
EEC CLASSIFICATION: Not Available
EEC LABEL: Not Available
EEC R: Not Available
EEC S: Not Available
TRANSPORT CANADA PIN: Not Available
SECTION 15: REGULATORY INFORMATION
U.S. FEDERAL REGULATIONS:
TSCA: All components appears in TSCA Inventory
OSHA: None
CERCLA SARA HAZARD CATEGORY:
SECTION 311 AND 312: This product has been reviewed according to the EPA "Hazard
Categories" promulgated under Sections 311 and 312 of the
Superfund Amendment and Reauthorization Act of 1986 (SARA
Title III) and is considered, under applicable definitions, to meet the
following categories: None
SECTION 313: This product contains following substances subject to the reporting requirements
of Section 313 of Title III of the Superfund Amendments and Reauthorization
Act of 1986 and 40 CFR Part 372: 1,2,4-Trimethyl benzene (0.5-1.0%); Xylene
(0.1-0.5%); Manganese Compounds (6-10%)
INTERNATIONAL REGULATIONS:
CANADIAN WHMIS: None
CANADIAN ENVIRONMENTAL PROTECTION ACT (CEPA): Additional information available
upon request.
EINECS: Additional information available upon request.
MSDS No: XCP0205G002 -7-
Material Safety Data Sheet
February 1, 2005 Super Fuel Booster
STATE REGULATIONS: No specific listing in California or New Jersey. Additional information available upon
request.
SECTION 16: OTHER INFORMATION
The information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge
of Xcelplus International INC. The Data on this sheet related only to the specific material designed herin. Xcelplus
International INC. assumes no legal responsibility for the use or reliance on this data.
End of Document
MSDS No: XCP0205G002 -8-
|