1 CHEMICAL PRODUCT & COMPANY IDENTIFICATION
Trade Name INK 445
ITW TRANS TECH
Supplier
475 N. GARY AVENUE
CAROL STREAM, IL 60188 USA
Telephone Numbers - 24 Hour Emergency Assistance
Emergency (352)323-3500
Telephone Numbers - General Assistance
Information (630)752-4000
2 COMPOSITION / INFORMATION ON INGREDIENTS
Concentration
Ingredient Name CAS Number Exposure Limits / Health Hazards
PROPYLENE GLYCOL METHYL ETHER 107-98-2 10 - 30 % OSHA STEL 553 mg/m3 150 ppm
ACGIH TWA 100 ppm
ACGIH-STEL: 150 ppm
ETHANOL, 2-BUTOXY 111-76-2 40 - 70 % OSHA PELs: 240 mg/m3 50ppm
ACGIH TWA 20 ppm
ETHYL ACETATE 141-78-6 0.2 - 0.9 % OSHA PELs: 1400 mg/m3 400 ppm
ACGIH TWA 400 ppm
ALUMINUM 7429-90-5 5 - 10 % OSHA PELs: 15 mg/m3
ACGIH TWA 10 mg/m3
Composition Comments
DANGER!! This material is classified as hazardous under OSHA regulations.
3 HAZARDS IDENTIFICATION
Special Toxic Effects
Harmful if ingested, inhaled or absorbed through the skin. May cause blood effects. Affects central nervous system, liver
and kidneys. This product can cause respiratory irritation, headache and dizziness if inhaled. Repeated overexposure to
1-methoxy-2-propanol may cause liver and kidney damage and delayed skeletal development of the fetus, based on animal
studies. May cause eye and skin irritation.
Target Organs
Target Organ Effects: Lymph nodes ,Liver ,Blood ,Kidney
4 FIRST AID MEASURES
Skin
Wash immediately with soap and water. Consult a physician if irritation persists.
Inhalation
Remove to fresh air and keep warm. If breathing is difficult: artificial respiration. Give oxygen if breathing is difficult. Seek
immediate medical aid.
Printed On 24-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
649 INK 445
Material Id Trade Name 1/ 4
Ingestion
Do not induce vomiting. If vomiting occurs naturally, have casualty lean forward to reduce the risk of aspiration. Seek
medical attention immediately.
5 FIRE FIGHTING MEASURES
Extinguishing Media
Cool fired-exposed containers with water.
Suitable Extinguishing Media: Carbon dioxide, foam, dry chemical.
Basic Fire Fighting Procedures
Wear self-contained breathing apparatus and full protective clothing.
Unusual Fire & Explosion Hazards
Burning may produce toxic combustion products.
89.6 潞F
Flash Point
not determined
AutoIgnition Temperature
not determined
Flammability Limits in Air, Lower, % by Volume
not determined
Flammability Limits in Air, Upper, % by Volume
6 ACCIDENTAL RELEASE MEASURES
Spill or Leak Procedure
Absorb spill with inert material (e. g. dry sand or earth) then place in a chemical waste container. Wear suitable protective
equipment listed under exposure personal protection. Remove sources of ignition. Ventilate area. Use spark-proof tool and
explosion-proof equipment Should not be released into the environment.
7 HANDLING & STORAGE
Handling
As with all industrial chemicals, use good industrial practices when handling. Do not get in eyes, on skin, on clothing. Do
not inhale. Do not taste or swallow. Use only with adequate ventilation. Keep away from heat, sparks and flame. Ground
and bond containers for transfer to prevent static sparks. Use non-sparking tools.
Storage
Keep containers tightly closed in a cool, well-ventilated place. Store in area with appropriate fire protection.
8 EXPOSURE CONTROLS / PERSONAL PROTECTION
Eye Protection: Personal Protection Equipments (PPE)
Use safety eyewear designed to protect against splash ot liquids.
Skin Protection: Personal Protection Equipments (PPE)
Wear chemical resistant gloves and protective clothing.
Respiratory Protection: Personal Protection Equipments (PPE)
Use NIOSH approved respirator as needed to mitigate exposure.
General
Eye wash station and safety shower should be available in immediate work area. Select additional protective equipment
based upon potential for exposure.
9 PHYSICAL & CHEMICAL PROPERTIES
Odor and Appearance
Liquid
Characteristic odor.
Printed On 24-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
649 INK 445
Material Id Trade Name 2/ 4
not determined
Boiling Point
not determined
Specific Gravity
not determined
Melting Point
not determined
Percent Volatile
not determined
Vapor Pressure
not determined
Evaporation Rate
not determined
Vapor Density
not determined
Viscosity
not determined
Solubility In Water
not determined
Octanol Water
not determined
Freezing Point
10 STABILITY & REACTIVITY
Stability/Incompatibility
Stable under recommended storage and handling conditions
Conditions to avoid: Avoid temperature extremes. Avoid excessive heat, open flames and all ignition sources
Incompatability: Strong oxidizing agents, strong acids, strong bases.
Hazardous Reactions/Decomposition Products
No decomposition expected under normal storage conditions.
11 TOXICOLOGICAL INFORMATION
Routes of Exposure
Inhalation, ingestion, skin and eye contact.
12 ECOLOGICAL INFORMATION
13 DISPOSAL CONSIDERATIONS
Waste Disposal
Dispose of in accordance with all federal, state, and local regulations.
Container Disposal Information: Do not cut or weld containers, even empty containers. Flammable vapors may exist in
containers in which residues of this product remain.
14 TRANSPORT INFORMATION
Proper Shipping Name Flammable liquids, toxic, n.o.s.
Hazard Class 3 (6.1) UN/NA Code 1992
Packaging Group III
15 REGULATORY INFORMATION
Federal Regulations
SARA Section 302 Extremely Hazardous Substances (EHS) This product does not contain any components regulated
under Section 302 (40 CFR 355) as Extremely Hazardous Substances.
SARA Section 304 CERCLA Hazardous Substances: This product contains the following components regulated under
section 304 (40 CFR 302) as hazardous chemicals for emergency release notification ("CERCLA" List).
NFPA Ratings
Health Flammability Reactivity Special Hazards
HMIS Ratings
Health 2 Flammability 3 Reactivity 1 Personal Prot. Equip. X
Printed On 24-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
649 INK 445
Material Id Trade Name 3/ 4
16 OTHER INFORMATION
Disclaimer
The details in this material safety data sheet satisfy national legislation. However, we have no knowledge or control over
the individual user's working conditions. The product may not be used for any purpose other than that specified in the
product data sheet unless written consent has been obtained. The user is responsible for the observance of all required
statutory provisions.
6/24/2008 5/27/2008
Replaces Sheet Dated
Completed On
Completed By
Printed On 24-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
649 INK 445
Material Id Trade Name 4/ 4
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP