MATERIAL SAFETY DATA SHEET
1 CHEMICAL PRODUCT & COMPANY IDENTIFICATION
Trade Name INK TYPE PE
368
MSDS Number
ITW TRANS TECH
Supplier
475 N. GARY AVENUE
CAROL STREAM, IL 60188 USA
Telephone Numbers - 24 Hour Emergency Assistance
Emergency (352)323-3500
Telephone Numbers - General Assistance
Information (630)752-4000
2 COMPOSITION / INFORMATION ON INGREDIENTS
Concentration
Ingredient Name CAS Number Exposure Limits / Health Hazards
CYCLOHEXANONE 108-94-1 10 - 20 % ACGIH TLV: 25ppm -OSHA TWA-
50ppm (MAK)
DIACETONE ALCOHOL 123-42-2 15 - 20 % OSHA PEL: 50ppm ACGIH TLV:
50ppm
SOLVENT NAPHTHA 100 64742-95-6 10 - 20 % OSHA PEL: 100ppm ACGIH TLV:
125ppm
2-METHOXY PROPYLACETATE-1 70657-70-4 0.5 - 0.7 % ND
1-METHOXYPROPYLACETATE-2 108-65-6 10 - 15 % ND
3 HAZARDS IDENTIFICATION
Signs & Symptoms of Short-Term (Acute) Exposure
Excessive vapor concentration in air, especially in confined spaces, may cause asphyxiation. Excessive inhalation of
vapors can cause nasal, throat and respiratory irritation, dizziness, weakness, fatigue, nausea, headache and possible
unconsciousness. Eye contact causes irritation, redness, tearing, blurred vision. Eye contact with liquid or vapor causes
severe irritation, redness, tearing, blurred vision. Vapors may cause severe eye irritation, redness, tearing and blurred
vision. Prolonged skin contact may lead to extraction of natural oils with resultant dry skin, cracking, irritation and dermititis.
Swallowing may cause gastrointestinal irritation, nausea, vomiting and diarrhea. Notice: intentional misuse by deliberately
concentrating and inhaling the contents maybe harmful or fatal. Reports have associated repeated and prolonged
occupational overexposure to solvents with permanent brain and nervous system damage.
Effects of Long-Term (Chronic) Exposure
Health studies have shown that many solvents pose potential human health risks which may vary from person to person.
As a precaution, exposure to liquids and vapors should be minimized. -Prolonged or continuous inhalation of vapors may
result in delayed lung damage. -Repeated or prolonged inhalation of vapor may cause liver and kidney damage. Repeated
inhalation of vapor in high concentration can change the blood picture.
4 FIRST AID MEASURES
Skin
Wash with soap and water.
Printed On 23-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
368 INK TYPE PE
Material Id Trade Name 1/ 4
Eye
Flush with water for at least 15 minutes, consult a physician.
Inhalation
Move to fresh air. Give artificial respiration if necessary.
Ingestion
Do not induce vomiting. Do not drink water, milk or oil. Consult physician or poison control center immediately. Treat
symptomatically.
Medical Conditions Aggravated by Exposure
ND
5 FIRE FIGHTING MEASURES
Extinguishing Media
Foam, carbon dioxide, dry chemical powder
Basic Fire Fighting Procedures
Water may be ineffective. Water should be used to cool containers exposed to fire. Fire fighting personnel should wear
self-contained breathing apparatus.
Unusual Fire & Explosion Hazards
Keep container tightly closed, isolate from heat, sparks, electrical equipment and open flame. Closed containers may
explode when exposed to extreme heat. During emergency conditions over exposure to decomposition products may cause
a health hazard. Symptoms may not be immediately apparent. Obtain medical attention.
43 C
Flash Point
0.8
Flammability Limits in Air, Lower, % by Volume
6 ACCIDENTAL RELEASE MEASURES
Spill or Leak Procedure
Refer to protective measures listed in section 4, 5, 6, 8 and 9. Remove all sources of ignition, avoid breathing vapors,
ventilate area, remove with liquid binding material.
7 HANDLING & STORAGE
Handling
Do not take internally, use approved printing procedures, observe label precautions. Keep closures tight and container
upright to prevent leakage. Do not weld or flame cut an empty drum, do not handle until the manufacturers safety
precautions have been read and understood.
Storage
Store containers out of sun and away from heat, sparks and open flames, close containers after each use. Consult N.F.P.A.
Code for additional storage requirements.
Ventilation
Adequate ventilation is required. See your safety equipment supplier for evaluation and recommendation. Provide
ventilation to keep vapor concentration below the given tlv.
8 EXPOSURE CONTROLS / PERSONAL PROTECTION
Eye Protection: Personal Protection Equipments (PPE)
Use safety glasses designed to protect against splash of liquids.
General
Eye bath and shower should be available. Use chemical resistant clothing. Liquid may penetrate shoes and leather causing
delayed irritation.
Printed On 23-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
368 INK TYPE PE
Material Id Trade Name 2/ 4
9 PHYSICAL & CHEMICAL PROPERTIES
Odor and Appearance
Clear liquid with odor of organic solvents
155 C
Boiling Point
1
Specific Gravity
NI
Melting Point
40 - 65
Percent Volatile
NI
Vapor Pressure
Slower
Evaporation Rate
Heavier
Vapor Density
NI
Solubility In Water
10 STABILITY & REACTIVITY
Stability/Incompatibility
Stable Avoid peroxides and other strong oxidizing materials.
Hazardous Reactions/Decomposition Products
Carbon monoxide, carbon dioxide, smoke, oxides of nitrogen.
Hazardous Polymerization
Will not occur.
11 TOXICOLOGICAL INFORMATION
Routes of Exposure
Inhalation, skin, eyes and ingestion.
12 ECOLOGICAL INFORMATION
13 DISPOSAL CONSIDERATIONS
Waste Disposal
Incinerate in an approved facility, do not incinerate closed containers. Dispose of in accordance with federal, state, and
local pollution control requirements.
14 TRANSPORT INFORMATION
Hazard Class Combustible liquid - Class II UN/NA Code 1210
Labels Required Combustible liquid
15 REGULATORY INFORMATION
NFPA Ratings
Health Flammability Reactivity Special Hazards
HMIS Ratings
Health 1 Flammability 2 Reactivity 1 Personal Prot. Equip. B
16 OTHER INFORMATION
Disclaimer
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of ITW
Trans Tech. The data on this sheet applies only to the specific material designated herein. ITW Trans Tech. assumes no
legal responsibility for use of reliance upon this data.
Printed On 23-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
368 INK TYPE PE
Material Id Trade Name 3/ 4
6/23/2008 9/25/2007
Replaces Sheet Dated
Completed On
Completed By
Printed On 23-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
368 INK TYPE PE
Material Id Trade Name 4/ 4
|