MATERIAL SAFETY DATA SHEET
1 CHEMICAL PRODUCT & COMPANY IDENTIFICATION
Trade Name INK TYPE PK
405
MSDS Number
ITW TRANS TECH
Supplier
475 N. GARY AVENUE
CAROL STREAM, IL 60188 USA
Telephone Numbers - 24 Hour Emergency Assistance
Emergency (352)323-3500
Telephone Numbers - General Assistance
Information (630)752-4000
2 COMPOSITION / INFORMATION ON INGREDIENTS
Concentration
Ingredient Name CAS Number Exposure Limits / Health Hazards
CYCLOHEXANONE 108-94-1 10 - 15 % ACGIH TLV: 25ppm -OSHA TWA-
50ppm (MAK)
2-BUTOXYETHYLACETATE 112-07-2 1-5% Other Exposure Limits: 20ppm
(MAK)
SOLVENT NAPHTHA 100 64742-95-6 1-5% OSHA PEL: 100ppm ACGIH TLV:
125ppm
XYLENES 1330-20-7 10 - 20 % OSHA PEL: 100ppm ACGIH TLV:
100ppm
1-METHOXY PROPYL ACETATE-2 108-65-6 1-5% OSHA PELs: Not established.
ACGIH TLV: Not established.
OSHA/NIOSH IDLH TLV*: 275
mg/m3
2-METHOXY PROPYLACETATE-1 70657-70-4 <4% ND
3 HAZARDS IDENTIFICATION
Signs & Symptoms of Short-Term (Acute) Exposure
Excessive vapor concentration in air, especially in confined spaces, may cause asphyxiation. Excessive inhalation of
vapors can cause nasal, throat and respiratory irritation, dizziness, weakness, fatigue, nausea, headache and possible
unconsciousness. Eye contact causes irritation, redness, tearing, blurred vision. Vapors may cause severe eye irritation,
redness, tearing and blurred vision. Prolonged skin contact may lead to extraction of natural oils with resultant dry skin,
cracking, irritation and determatitis. Notice: intentional misuse by deliberately concentrating and inhaling the contents
maybe harmful or fatal. Reports have associated repeated and prolonged occupational overexposure to solvents with
permanent brain and nervous system damage.
Effects of Long-Term (Chronic) Exposure
Health studies have shown that many solvents pose potential human health risks which may vary from person to person.
As a precaution, exposure to liquids and vapors should be minimized. -Prolonged or continuous inhalation of vapors may
result in delayed lung damage. -Repeated or prolonged inhalation of vapor may cause liver and kidney damage. -Repeated
inhalation of vapor in high concentration can change the blood picture.
Printed On 23-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
405 INK TYPE PK
Material Id Trade Name 1/ 4
4 FIRST AID MEASURES
Skin
Wash with soap and water.
Eye
Flush with water for at least 15 minutes, consult a physician.
Inhalation
Move to fresh air, provide aid in breathing if necessary.
Ingestion
Do not induce vomiting. Do not drink water, milk or oil. Consult physician or poison control center immediately. Treat
symptomatically.
5 FIRE FIGHTING MEASURES
Extinguishing Media
Foam, carbon dioxide, dry chemical power
Basic Fire Fighting Procedures
Water may be ineffective. Water should be used to cool containers exposed to fire. Fire fighting personnel should wear
self-contained breathing apparatus.
Unusual Fire & Explosion Hazards
Keep containers tightly closed, isolate from heat, sparks, electrical equipment and open flame. Closed containers may
explode when exposed to extreme heat. During emergency conditions over exposure to decomposition products may cause
a health hazard. Symptoms may not be immediately apparent. Obtain medical attention.
30 C
Flash Point
0.8
Flammability Limits in Air, Lower, % by Volume
6 ACCIDENTAL RELEASE MEASURES
Spill or Leak Procedure
Remove all sources of ignition, avoid breathing vapors, ventilate area, remove with liquid binding material.
7 HANDLING & STORAGE
Storage
Store containers out of sun and away from heat, sparks and open flames. Close containers after each use. Consult NFPA
code for additional storage requirements.
Ventilation
Adequate ventilation is required. See your safety equipment supplier for evaluation and recommendation. Provide sufficient
ventilation to keep vapor concentration below the given TLV and LEL.
8 EXPOSURE CONTROLS / PERSONAL PROTECTION
Eye Protection: Personal Protection Equipments (PPE)
Use safety eyewear designed to protect against splash of liquids.
Skin Protection: Personal Protection Equipments (PPE)
Protective gloves recommended.
General
Eye bath and shower should be available. Use chemical resistant clothing. Liquid may penetrate shoes and leather causing
delayed irritation. Hygienic practices: wash hands before eating, smoking or using washroom.
Printed On 23-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
405 INK TYPE PK
Material Id Trade Name 2/ 4
9 PHYSICAL & CHEMICAL PROPERTIES
Odor and Appearance
Colored paste with odor of organic solvents
137 C
Boiling Point
1
Specific Gravity
40 - 45 % By volume
Percent Volatile
Slower
Evaporation Rate
Heavier
Vapor Density
10 STABILITY & REACTIVITY
Stability/Incompatibility
Stable. Avoid peroxides and other strong oxidizing materials.
Hazardous Reactions/Decomposition Products
Carbon monoxide, carbon dioxide, smoke, oxides of nitrogen.
Hazardous Polymerization
Will not occur
11 TOXICOLOGICAL INFORMATION
Routes of Exposure
Inhalation, ingestion, skin and eye contact.
12 ECOLOGICAL INFORMATION
13 DISPOSAL CONSIDERATIONS
Waste Disposal
Incinerate in an approved facility, do not incinerate closed containers. Dispose of in accordance with federal, state, and
local pollution control requirements.
14 TRANSPORT INFORMATION
Hazard Class Flammable Liquid Class IC UN/NA Code 1210
Labels Required Flammable Liquid
15 REGULATORY INFORMATION
NFPA Ratings
Health Flammability Reactivity Special Hazards
HMIS Ratings
Health 1 Flammability 3 Reactivity 1 Personal Prot. Equip. B
Following ingredients of this product are listed in SARA313
SARA Listed Ingredient Name CAS Number Maximum %
CYCLOHEXANONE 108-94-1
SOLVENT NAPHTHA 100 64742-95-6
XYLENES 1330-20-7
Listed on the following Regulatory List(s)
SARA 313
Printed On 23-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
405 INK TYPE PK
Material Id Trade Name 3/ 4
16 OTHER INFORMATION
Disclaimer
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of ITW
Trans Tech. The data on this sheet applies only to the specific material designated herein. ITW Trans Tech. assumes no
legal responsibility for use of reliance upon this data.
6/23/2008 9/25/2007
Replaces Sheet Dated
Completed On
Completed By
Printed On 23-Jun-08
ND = No Data NA = Not Applicable NI = Not Indicated
405 INK TYPE PK
Material Id Trade Name 4/ 4
|