1 CHEMICAL PRODUCT & COMPANY IDENTIFICATION
Trade Name INK TYPE PO NT
387
MSDS Number
TRANS TECH AMERICA, INC.
Supplier
475 N. GARY AVENUE
CAROL STREAM, IL 60188 USA
Telephone Numbers - 24 Hour Emergency Assistance
Emergency (352)323-3500
Telephone Numbers - General Assistance
Information (630)752-4000
2 COMPOSITION / INFORMATION ON INGREDIENTS
Concentration
Ingredient Name CAS Number Exposure Limits / Health Hazards
CYCLOHEXANONE 108-94-1 1-5% OSHA PEL: 50ppm; ACGIH TLV:
25ppm OSHA/NIOSH IDLH TLV*:
100 mg/m3
XYLENES 1330-20-7 5 - 10 % OSHA TWA: 100ppm; OSHA STEL:
150ppm
ETHOXYPROPYLACETATE 54839-24-6 10 - 20 % OSHA PEL: 100ppm
BUTYL GLYCOL ACETATE 112-07-2 15 - 25 % N/A
3 HAZARDS IDENTIFICATION
Signs & Symptoms of Short-Term (Acute) Exposure
Irritation of the respiratory tract, dizzy feeling, headache.
4 FIRST AID MEASURES
Skin
Wash immediately with soap and water.
Eye
Rinse immediately with plenty of water. See a physician for medical treatment.
Inhalation
Move to fresh air at once.
Ingestion
Call for medical assistance.
Medical Conditions Aggravated by Exposure
Asthma, other respiratory disorders, skin allergies.
5 FIRE FIGHTING MEASURES
Printed On 31-Mar-03
ND = No Data NA = Not Applicable NI = Not Indicated
387 INK TYPE PO NT
Material Id Trade Name 1/ 3
Extinguishing Media
Carbon dioxide, dry chemical, do not use water-jet.
Basic Fire Fighting Procedures
Cool down endangered containers.
Unusual Fire & Explosion Hazards
Do not inhale fumes or decomposition products. Use self contained breathing apparatus.
77 F
Flash Point
1
Flammability Limits in Air, Lower, % by Volume
9.8
Flammability Limits in Air, Upper, % by Volume
6 ACCIDENTAL RELEASE MEASURES
Spill or Leak Procedure
Look for good ventilation or respiratory (tested for solvent vapors). Cover with absorbent material like sand, vermiculite, etc.
Remove material and then wash the area with water. Prevent inhalation of vapor and contact with the product in general.
7 HANDLING & STORAGE
Handling
Use only with adequate ventilation.
Storage
Storage temperature 32F - 85F. Avoid overheating with danger of rupture of the closed container. Keep containers tightly
closed while not in use. Keep away from sources of ignition. Do not eat, drink or smoke in the work area. Do not empty into
drains.
Ventilation
General ventilation should be sufficient. Local exhaust: Recommended to keep exposure below TLV levels.
8 EXPOSURE CONTROLS / PERSONAL PROTECTION
9 PHYSICAL & CHEMICAL PROPERTIES
268 F
Boiling Point
1
Specific Gravity
10
Vapor Pressure
3-4
Vapor Density
Neglectible
Solubility In Water
10 STABILITY & REACTIVITY
Stability/Incompatibility
Stable. Combustion may occur when reacting with oxidants. Avoid overheating.
Printed On 31-Mar-03
ND = No Data NA = Not Applicable NI = Not Indicated
387 INK TYPE PO NT
Material Id Trade Name 2/ 3
11 TOXICOLOGICAL INFORMATION
Routes of Exposure
Inhalation, ingestion, skin and eye contact.
12 ECOLOGICAL INFORMATION
13 DISPOSAL CONSIDERATIONS
Waste Disposal
Follow federal, state and local regulations to dispose of or incinerate waste material.
14 TRANSPORT INFORMATION
15 REGULATORY INFORMATION
NFPA Ratings
Health Flammability Reactivity Special Hazards
HMIS Ratings
Health 1 Flammability 2 Reactivity 0 Personal Prot. Equip. B
Following ingredients of this product are listed in SARA313
SARA Listed Ingredient Name CAS Number Maximum %
XYLENES 1330-20-7
Listed on the following Regulatory List(s)
SARA 313
16 OTHER INFORMATION
Disclaimer
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of
Trans Tech America, Inc. The data on this sheet applies only to the specific material designated herein. Trans Tech
America, Inc. assumes no legal responsibility for use of reliance upon this data.
2/27/1998 1/7/1998
Replaces Sheet Dated
Completed On
TRANS TECH AMERICA, INC.
Completed By
Printed On 31-Mar-03
ND = No Data NA = Not Applicable NI = Not Indicated
387 INK TYPE PO NT
Material Id Trade Name 3/ 3
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP