MATERIAL SAFETY DATA SHEET PROSOCO, Inc.
I PRODUCT IDENTIFICATION
MANUFACTURER鈥橲 NAME EMERGENCY TELEPHONE NUMBERS:
PROSOCO, Inc.
AND ADDRESS: 8:00 AM 鈥? 5:00 PM CST Monday-Friday:
3741 Greenway Circle 785/865-4200
NON-BUSINESS HOURS (INFOTRAC):
Lawrence, KS 66046 800/535-5053
庐
PRODUCT TRADE NAME: Consolideck LS
II HAZARDOUS INGREDIENTS
ACGIH
CHEMICAL NAME (COMMON NAME) CAS NO. NFPA CODE OSHA PEL/TWA
TLV/TWA
3
Proprietary Ingredient A(a,*) -- N/A -- 1 mg/m * *
3
Proprietary Ingredient B(a,*) -- N/A -- 1 mg/m * *
Proprietary Ingredient C(a,*) -- N/A Not established
(a) The specific product is not identified due to 鈥淭rade Secret鈥? status. In emergency situations further information may be obtained by
the on-duty physician calling the emergency information number listed above. Reference 29 CFR 1910-1200 and/or 40 CFR 350.
* The ACGIH Threshold Limit Value (TLV) has not been established nor has OSHA established the Permissible Exposure Limit (PEL)
for this product, therefore the limits described have been established as guidelines by the manufacturer.
III PHYSICAL DATA
VAPOR
BOILING POINT FREEZING POINT VAPOR DENSITY
PRESSURE
(掳F) (掳F) (Air = 1)
(mm Hg)
庐
212掳F (100掳C) 32掳F (0掳C) 17 (@20掳C) <1
Consolideck LS
SPECIFIC SOLUBILITY APPEARANCE AND
pH
GRAVITY IN WATER ODOR
Light green, water-like
庐
Consolideck LS* 1.10 11.0 Appreciable (>99%) liquid, practically
*Typical odorless
IV FIRE AND EXPLOSION HAZARD DATA
EMERGENCY OVERVIEW
庐
Consolideck LS is a light green, water-like alkaline liquid that is practically odorless. Prolonged contact may cause skin and eye
irritation. Inhalation may cause irritation. Ingestion may cause gastric distress.
FLASH POINT (METHOD): Non-flammable
FLAMMABLE LIMITS: LEL: not applicable UEL: not applicable
EXTINGUISHING MEDIA: Carbon dioxide, water, water fog, dry chemical, chemical foam
FIRE FIGHTING PROCEDURES: Keep containers cool with water spray to prevent container rupture due to steam buildup; floor will
become slippery if material is released. Material is alkaline and will irritate the eyes if product is allowed to directly contact the
eyes.
SPECIAL FIRE FIGHTING PROCEDURES: None.
UNUSUAL FIRE AND EXPLOSION HAZARDS: None.
V HEALTH HAZARD DATA
PRIMARY ROUTES OF EXPOSURE: Skin, eyes, inhalation, ingestion.
CARCINOGEN INFORMATION: Not listed (OSHA, IARC, NTP).
MEDICAL CONDITIONS AGGRAVATED BY OVEREXPOSURE:
EFFECTS OF OVEREXPOSURE:
EYE CONTACT: Contact with eyes may cause pain and irritation.
SKIN CONTACT: Contact with skin may cause irritation, dermatitis.
INHALATION: Inhalation of mists or vapors may cause irritation to upper respiratory tract and mucous membranes.
INGESTION: Irritating to digestive tract; may cause gastric distress, stomach pains.
EMERGENCY AND FIRST AID PROCEDURES:
EYE CONTACT: Remove contact lenses. Immediately flush eyes for 15 minutes in clear running water while holding eyelids open;
seek medical attention immediately.
SKIN CONTACT: Wash contacted area with soap and water; DO NOT attempt to neutralize with chemical agents; if irritation persists,
seek medical attention.
INHALATION: Remove affected person to fresh air; wash mouth and nasal passages with water repeatedly; if breathing difficulties
persist seek medical attention.
INGESTION: Drink large quantities of water or milk; DO NOT induce vomiting; seek medical attention immediately.
VI REACTIVITY DATA
STABILITY: Stable.
CONDITIONS TO AVOID: Extreme temperatures, keep from freezing.
INCOMPATIBILITY (MATERIALS TO AVOID): strong oxidizers, strong acids
HAZARDOUS COMBUSTION OR DECOMPOSITION PRODUCTS: Smoke, fumes, oxides of carbon. Decomposition will not occur if
handled and stored properly. In case of fire, oxides of carbon and lithium, hydrocarbons, fumes, and smoke may be produced.
VII SPILL OR LEAK PROCEDURES
SPILL, LEAK, WASTE DISPOSAL PROCEDURES: STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OF SPILLED:
Material is alkaline and will irritate the eyes if product is allowed to directly contact the eyes. Wash small spills to sanitary
sewer. Large spills 鈥? confine spill, soak up with approved absorbent, shovel product into approved container for disposal.
WASTE DISPOSAL METHODS: Dispose of in accordance with Local, State, and Federal Regulations. Refer to 鈥?40 CFR Protection of
Environment Parts 260-299鈥? for complete waste disposal regulations for alkaline materials. Consult your local, state, and
Federal Environmental Protection Agency before disposing of any chemicals.
VIII SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION: None required while threshold limits are kept below maximum allowable concentrations, if TWA
exceeds limits, NIOSH approved respirator must be worn. Refer to 29 CFR 1910.134 or European Standard EN 149 for
complete regulations. If mists are present, wear a NIOSH approved dust/mist respirator.
VENTILATION: The use of local exhaust ventilation is recommended. Use corrosion-resistant ventilation equipment.
PROTECTIVE CLOTHING: Coveralls, apron, or other equipment as needed to minimize skin contact.
PROTECTIVE GLOVES: Neoprene or rubber gloves with cuffs as needed to prevent prolonged exposure.
EYE PROTECTION: Safety glasses with side shields. Depending on application condition, chemical splash goggles or a face shield
may be necessary to prevent eye contact.
OTHER PROTECTIVE EQUIPMENT: Provide eyewash and clean water for rinsing skin.
庐
Consolideck LS - Page 2 of 3
IX SPECIAL PRECAUTIONS
WORK PRACTICES: Proper work practices and planning should be utilized to avoid contact with workers, passersby, and non-
masonry surfaces. Always follow published application rates. See the Product Data sheet and label for specific precautions to
be taken during use. Smoking, eating and drinking should be prohibited during the use of this product. Wash hands before
breaks and at the end of a shift.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Keep container closed when not in use; protect containers from
abuse; protect from extreme temperatures. Keep from freezing. Keep this and other chemicals out of reach of children.
OTHER PRECAUTIONS: Avoid generating mists during application.
X REGULATORY INFORMATION
SHIPPING: Non-regulated for shipment in all modes; domestic or international.
NATIONAL MOTOR FREIGHT CLASSIFICATION:
SARA 313 REPORTABLE:
CHEMICAL NAME CAS UPPERBOUND CONCENTRATION % BY WEIGHT
-- --
None
Contains no chemicals known to the State of California to cause cancer or reproductive
CALIFORNIA PROPOSITION 65:
risk.
XI OTHER
MSDS Status: Date of Revision: July 19, 2007
For Product Manufactured After: August 1, 2007
Changes: Updated Product Item #, Section XI
Item #: 46068
Approved By: Regulatory Department
DISCLAIMER:
The information contained on the Material Safety Data Sheet has been compiled from data considered accurate. This data is
believed to be reliable, but it must be pointed out that values for certain properties are known to vary from source to source.
PROSOCO, Inc. expressly disclaims any warranty express or implied as well as any liability for any injury or loss
arising from the use of this information or the materials described. This data is not to be construed as absolutely
complete since additional data may be desirable when particular conditions or circumstances exist. It is the responsibility of
the user to determine the best precautions necessary for the safe handling and use of this product for his unique application.
This data relates only to the specific material designated and is not to be used in combination with any other material. Many
federal and state regulations pertain directly or indirectly to the product's end use and disposal of containers and unused
material. It is the purchaser's responsibility to familiarize himself with all applicable regulations.
DATE OF PREPARATION: August 1, 2007
庐
Consolideck LS - Page 3 of 3
|