TUTHILL VACUUM & BLOWER SYSTEMS
MATERIAL SAFETY DATA SHEET
1. CHEMICAL PRODUCT and COMPANY IDENTIFICATION
PRODUCT NAME: PneuLube Food Grade Synthetic Oil (TVBS Part number 16444-100- ** FG)
** Blank is placeholder for size of container:
CHEMICAL FAMILY:
P=pint; Q=quart; 2Q=2-quart; G=gallon;
CHEMICAL NAME: Mixture
5G=5-gallon pail; B=55-gallon barrel
MANUFACTURER: EMERGENCY TELEPHONE NUMBERS:
Tuthill Vacuum & Blower Systems CHEMTREC: 1-800-424-9300
4840 West Kearney Street
P. O. Box 2877 HAZARD RATING: NFPA HMIS
Springfield, MO 65801-2877 HEALTH: 0 0
(417) 865-8715 (800) 825-6937 FIRE: 1 1
Preparation Date: 04/10/2003 REACTIVITY: 0 0
2. HAZARDOUS INGREDIENTS
This product is not known to contain any chemical listed as a carcinogen or suspected carcinogen by OSHA, IARC
or the National Toxicology Program (NIP) at a concentration of greater than 0.1%
This product is a food grade synthetic aliphatic hydrocarbon mixture and contains no known hazardous
components.
3. FIRE & EXPLOSION HAZARDS
FLASH POINT, 掳 F: 430-511
UPPER FLAMMABLE LIMIT: Not determined
LOWER FLAMMABLE LIMIT: Not determined
EXTINGUISHING MEDIA: CO2; dry chemical; foam; water spray; water fog
SPECIAL FIREFIGHTING PROCEDURES: Cool containers with H2O and remove from fire exposure.
UNUSUAL FIRE & EXPLOSION HAZARDS: Empty containers could contain flammable vapors.
4. HEALTH HAZARD DATA
ORAL TOXICITY: None known.
EYE IRRITATION: May be an eye irritant.
SKIN IRRITATION: Possible redness and defatting may result from prolonged exposure.
OTHER: Unknown
TLV: 5 mg/m鲁 as oil mist.
EMERGENCY FIRST AID PROCEDURES
SKIN: Wash with soap and water.
EYES: Flush eyes with water. If irritation persists, get medical attention.
INHALATION: Remove victim to fresh air. See physician if irritation persists.
ORAL: Call physician. Do not induce vomiting.
ADDITIONAL: None.
5. SPECIAL PROTECTION INFORMATION
VENTILATION PROCEDURE: Normal shop ventilation is adequate.
GLOVE PROTECTION: Oil impervious gloves recommended.
EYE PROTECTION: Not usually required, but goggles recommended.
OTHER PROTECTION: None required.
PRODUCT TRADE NAME: PneuLube Food Grade Synthetic Oil (TVBS Part number 16444-100- ** FG)
Page 2 of 2
** Blank is placeholder for size of container:
VAPOR PRESSURE: > 1mm Hg VAPOR DENSITY: Not determined
SPECIFIC GRAVITY: < 1.0 at 60掳 F EVAPORATION RATE: Not determined
WATER SOLUBILITY: Slight ODOR: Odorless
PERCENT VOLATILE: Not determined APPEARANCE: Essentially colorless liquid
7. STABILITY
STABILITY: Stable
INCOMPATIBILITY: Oxidizing agents
POLYMERIZATION: Will not occur
THERMAL DECOMPOSITION: None
8. SPILL OR LEAK PROCEDURES
SPILL PROCEDURES: Wear chemical splash goggles.
Wear rubber boots.
Prevent entry into sewers and waterways. Pick up free liquid for recycle/disposal.
Absorb small amounts on inert material for disposal.
WASTE DISPOSAL: Disposal should be in compliance with federal, state and local laws.
Remove with vacuum trucks or pump to storage/salvage vessels. Soak up residue with an absorbent material
such as clay, sand or other suitable material; dispose of properly.
SMALL SPILLS: Take up with an absorbent material and dispose of properly.
9. SPECIAL PRECAUTIONS
SPECIAL PRECAUTIONS: Avoid prolonged contact. Practice of good industrial hygiene recommended.
10. TRANSPORTATION AND LABELING
DOT PROPER SHIPPING NAME: Not applicable.
DOT HAZARD CLASS: Not applicable.
11. OTHER REGULATORY INFORMATION
NONE
This information presented herein has been compiled from sources considered to be dependable and is accurate
to the best of the knowledge of TUTHILL VACUUM & BLOWER SYSTEMS; however, TUTHILL VACUUM &
BLOWER SYSTEMS makes no warranty whatsoever, expressed or implied, of merchantability or fitness for any
particular purpose, regarding the accuracy of such data or the results to be obtained from the use thereof.
TUTHILL VACUUM & BLOWER SYSTEMS assumes no responsibility for injury to recipient or to third persons or
for any damage to any property and recipient assumes all such risks.
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP