Material Safety Data Sheet U.S Department of Labor
Occupational Safety and Health Admin.
(Non-Mandatory Form)
Form Approved
consulted for specific requirements.
IDENTITY (As used on Label and List) Note: Blank spaces are not permitted. If any item is not applicable, or no information is available, the space
8120B R1 Santoprene Adhesive
must be marked to indicate that.
Section I
Manufacturers Name Emergency Telephone Number
Akron Coating & Adhesives, Inc. (330)724-4716 Day (330)376-5418 Night
Address (Number, Street, City, State, Zip Code) Telephone Number for Information
. (330)724-4716
Date Prepared
367 Stanton Ave May 13, 2004
Signature of Preparer (optional)
Akron, OH 44301
Section II 鈥? Hazardous Ingredients/Identity Information
Product is a stable high molecular weight polymer dispersion in water.
Hazardous Components CAS # Exposure Limit Concentration
Butyl Cellosolve 111-76-2 25 ppm-TWAS(Skin) 1.9% to 2.7%
Values from OSHA 29 CFR
1910.1000
HMIS HAZARD RATING: HEALTH 2 FIRE 1 REACTIVITY 0
Section III 鈥? Physical/Chemical Characteristics
Boiling Point o
F/ o C Specific Gravity (H O = 1)
212/100 1
2
Melting Point
Vapor Pressure (mm Hg.)
Of water N/A
Vapor Density (AIR = 1) Evaporation Rate (Butyl Acetate = 1)
Of water Of water
Solubility in Water
Soluble
Appearance and Odor
Tan, slightly sweet odor
Section IV 鈥? Fire and Explosion Data
Flash Point (Method Used) Flammable Limits LEL UEL
% VOLUME IN AIR N/A N/A
NONE (Cleveland Closed Cup)
Extinguishing Media
USE METHOD NECESSARY TO FIGHT PRIMARY SOURCE OF FIRE
Special Fire Fighting Procedures
CONTAINERS EXPOSED TO INTENSE HEAT FROM FIRES SHOULD BE COOLED WITH WATER
TO PREVENT VAPOR PRESSURE BUILD UP.
Unusual Fire and Explosion Hazards
CONTAINER MAY BURST IN HEAT OF FIRE DUE TO VAPOR PRESSURE BUILD UP.
Section V 鈥? Reactivity Data
Stability Unstable Conditions to Avoid
Stable
x
Incompatibility (Materials to Avoid)
NONE
Hazardous Decomposition or Byproducts
Carbon Monoxide
Hazardous May Occur Conditions to Avoid
Strong oxidizing agents
Polymerization
Will Not Occur
x
Section VI 鈥? Health Hazard Data
Route(s) of Entry: Inhalation? Skin? Ingestion?
SLIGHT SLIGHT NOT A NORMAL ROUTE
Health Hazards (Acute and Chromic)
EXPOSURE IS MOST LIKELY TO OCCUR BY CONTACT WITH THE SKIN.
NO HARMFUL EFFECTS ARE ANTICIPATED FROM ROUTINE EXPOSURE.
Carcinogenicity: IARC Monographs? OSHA Regulated?
NTP?
Not a carcinogen NO NO NO
Signs and symptoms of Exposure:
EXPOSURE TO VAPOR MAY CAUSE EYE AND UPPER RESPIRATORY TRACT IRRITATION.
INGESTION MAY CAUSE GASTROINTESTINAL IRRITATION. PROLONGED SKIN CONTACT MAY CAUSE RASH
Medical Conditions Generally Aggravated by Exposure
MAY CAUSE SLIGHT SKIN IRRITATION. MAY PROVOKE ASTHMATIC
RESPONSE
IN PERSONS WHO ARE SENSITIVE TO AIRWAY IRRITANTS
Emergency and First Aid Procedures
EYE CONTACT: HOLDING THE LIDS APART, FLUSH CONTAMINATED EYES WITH A GENTLE STREAM OF WATER
FOR 15 MINUTES. IF IRRITATION OR REDNESS DEVELOP AND PERSIST, SEEK IMMEDIATE
MEDICAL ATTENTION.
SKIN CONTACT: REMOVE CONTAMINATED CLOTHING AND CLEANSE SKIN THOROUGHLY WITH
SOAP AND WATER. SEEK MEDICAL ATTENTION IF IRRITATION, SWELLING, BLISTERING,
OR REDNESS DEVELOP AND PERSIST
INHALATION: NO FIRST AID IS NORMALLY REQUIRED. HOWEVER, SEEK MEDICAL ADVICE IF
ANY UNUSUAL SYMPTOMS DEVELOP
INGESTION: DRINK TWO OR THREE CUPS OF MILK, FRUIT JUICE OR WATER TO DILUTE.
IF ANY SYMPTOMS DEVELOP SEEK MEDICAL ADVISE.
Section VII 鈥? Precautions for Safe Handling and Use
Steps to Be Taken in Case Material Is Released or Spilled
USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN FOR SALVAGE OR DISPOSAL
Waste Disposal Method
DISPOSAL MAY BE SUBJECT TO NATIONAL, STATE OR LOCAL LAWS.
Precautions to Be Taken in Handling and Storing
STORE IN A SECURE AREA TO PREVENT CONTAINER DAMAGE. DO NOT FREEZE
Other Precautions
DO NOT FREEZE
Section VIII 鈥? Control Measures
Respiratory Protection (Specify Type)
GENERALLY UNNECESSARY
Ventilation Local Exhaust Special
RECOMMENDED N/A
Mechanical (General) Other
N/A N/A
Protective Gloves Eye Protection
NEOPRENE, LATEX, POLYETHYLENE FACE SHIELD OR SPLASH GUARD
Other Protective Clothing or Equipment
PROTECTIVE CLOTHING IS ADVISED AS ARE GOOD HANDLING PRACTICES
Work/Hygienic Practices
THE AVAILABILITY OF EYE WASHES AND SAFETY SHOWERS IN WORK AREAS IS RECOMMENDED
|