MATERIAL SAFETY DATA SHEET
1. IDENTIFICATION OF THE MATERIAL AND SUPPLIER
PRODUCT NAME: ENVIROSAN
OTHER NAMES: NONE
RECOMMENDED USE: ALL-PURPOSE ENVIRONMENT SANITISER.
SUPPLIER NAME: CAMPBELL CLEANTEC (ABN 92 009 657 489)
AUSTRALIA: NEW ZEALAND:
ADDRESS: 32 PERIVALE STREET, LEVEL 3, 52 SWANSON
STREET, AUCKLAND, 1001
DARRA, QLD, 4076
TELEPHONE: GENERAL ENQUIRIES: + 61 7 3710 3200 NZ: (09) 379 8745
CUSTOMER SERVICE: 1800 077 240 NZ: (09) 379 8745
FAX: GENERAL ENQUIRIES: + 61 7 3710 3210 NZ: (09) 336 1354
CUSTOMER SERVICE: + 61 7 3710 3207 NZ: (09) 336 1354
EMERGENCY TELEPHONE NUMBER: AUSTRALIA: 1800 628 724 (ALL HOURS)
NEW ZEALAND: 0800 734 607 (ALL HOURS)
ALL OTHER + 61 7 3710 3184 (ALL HOURS)
INTERNATIONAL:
2. HAZARDS IDENTIFICATION
Classified as hazardous according to the criteria of ASCC.
HAZARD CLASSIFICATION:
Not classified as a dangerous good according to the criteria of ADG Code (see section 14).
Not classified as a schedule poison according to the criteria of SUSDP (see section 15).
HAZARD CATEGORY: Xi 鈥? Irritant
RISK PHRASES: R38 鈥? Irritating to skin.
R41 鈥? Risk of serious damage to eyes.
SAFETY PHRASES: S1/2 鈥? Keep locked up and out of reach of children.
S24/25 鈥? Avoid contact with eyes and skin.
S26 鈥? In case of contact with eyes, rinse immediately with plenty of water and seek medical
advice.
S37/39 鈥? Wear suitable gloves and eye/face protection.
S45 鈥? In case of accident or if you feel unwell, seek medical advice immediately (show the label
whenever possible).
The information contained in this MSDS is specific to the product when handled and used neat. This product when diluted may not require the
same control measures as the neat product. Check with your technical representative if in doubt.
3. COMPOSITION / INFORMATION ON INGREDIENTS
INGREDIENT CAS No. PROPORTION (% w/w)
The ingredients below are considered either hazardous, dangerous goods or poison scheduled according to the criteria of ASCC, ADG
Code and SUSDP (respectively) at the levels used in the product.
alkylsulphonic acid 68584-22-5 10 - < 30%
2-hydroxyproponic acid 79-33-4 <10%
The ingredients below are not considered either hazardous , dangerous goods or poison scheduled according to the criteria of ASCC, ADG
Code and SUSDP (respectively) at the levels used in the product.
anionic surfactant <10%
Water >60%
Product Name: Page:
ENVIROSAN 1 of 5
MATERIAL SAFETY DATA SHEET
4. FIRST AID MEASURES
Immediately remove product from the mouth and rinse mouth out with water. Contact a Doctor or the
INGESTION:
Poisons Information Centre in your capital city for further advice.
Irrigate with copious quantities of water for at least 15 minutes and seek medical attention if effects
EYE CONTACT:
persist.
Remove contaminated clothing and wash skin thoroughly with water. Seek medical attention if the
SKIN CONTACT:
effects persist.
Remove from source of exposure to fresh air. Remove contaminated clothing and loosen remaining
INHALATION:
clothing. Allow patient to assume most comfortable position. Seek medical assistance if effects persist.
Potable water should be available to rinse eyes or skin. Provide eye baths and safety showers.
FIRST AID FACILITIES:
Treat symptomatically.
NOTES TO PHYSICIAN:
5. FIRE FIGHTING METHODS
Water spray, foam, carbon dioxide or dry chemical powder.
SUITABLE EXTINGUISHING MEDIA:
The product is non-combustible; however, the packaging material may burn to emit
HAZARDS FROM COMBUSTION:
noxious fumes.
Fire fighters should wear self-contained breathing apparatus to minimise risk of
PRECAUTIONS FOR FIRE FIGHTERS AND
exposure to vapour or products of combustion.
SPECIAL PROTECTIVE EQUIPMENT:
NONE
HAZCHEM CODE:
6. ACCIDENTAL RELEASE MEASURES
Spillages are slippery. Ensure adequate ventilation. Keep spectators away 鈥? rope off the area.
EMERGENCY PROCEDURES:
Avoid accidents, clean up immediately. Wear protective equipment to prevent skin and eye
contamination.
Contain the spill and prevent run off into drains and waterways.
METHODS AND MATERIALS FOR
Large spills: absorb with dry earth, sand or other similar material. Collect and seal in properly
CONTAINMENT AND CLEAN UP:
labelled drums for disposal in an area approved by local authority by-laws. Wash area down
with excess water to remove residual material.
Small spills: may be safely mopped up and area washed with excess water.
Incineration of disposed material is not recommended, as it is unlikely to adequately burn.
7. HANDLING AND STORAGE
Keep containers closed at all times - check regularly for leaks or spills. Transport and
PRECAUTIONS FOR SAFE HANDLING:
store upright. Avoid eye contact and repeated or prolonged skin contact. Do not eat, drink
or smoke in contaminated areas. Always remove contaminated clothing and wash hands
before eating, drinking, smoking or using the toilet. Wash contaminated clothing and
other protective equipment before storage or re-use.
Store in the original container, in a cool dry well-ventilated area out of sunlight and away
CONDITIONS FOR SAFE STORAGE:
from other chemicals and foodstuffs.
Keep containers closed when not in use to ensure contamination does not occur. Do not
combine part drums of the same product, as this may be a source of contamination. Do
not mix with other chemicals.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
No value assigned for this specific material by ASCC.
NATIONAL EXPOSURE STANDARDS:
No biological limit allocated.
BIOLOGICAL LIMIT VALUES:
Ensure ventilation is adequate to maintain air concentrations below Exposure
ENGINEERING CONTROLS:
Standards.
If inhalation risk exists then use with local exhaust ventilation or while wearing an acid
mist respirator. Keep containers closed when not in use.
Product Name: Page:
ENVIROSAN 2 of 5
MATERIAL SAFETY DATA SHEET
Protective equipment must be worn at all times. Risk assessments should always be conducted to identify the
PERSONAL
hazards and in turn determine the appropriate personal protective equipment for the hazard.
PROTECTIVE
Protective gloves: elbow-length laminate film, nitrile, natural rubber, neoprene, neoprene/natural rubber blend
EQUIPMENT:
or PVC impervious gloves. Always check with the glove manufacturer or your personal protective equipment
supplier regarding the correct type of glove to use. Consult AS/NZS 2161 for further information.
Eye protection: safety glasses/goggles with side shield protection and/or full-face shield. Consult AS/NZS 1336
and AS/NZS 1337 for further information.
Clothing and footwear: waterproof apron, coveralls, trousers, long sleeved shirt, closed in shoes and/or safety
footwear. Consult AS/NZS 2210 and AS/NZS 2919 for further information.
Respiratory Protection: Avoid breathing mist, sprays or vapours. Where ventilation is not adequate, respiratory
protection may be required. Any air-purifying respirator with an acid gases and vapour filter or any chemical
cartridge respirator with an acid gas cartridge(s) providing protection against the compound of concerns
meeting the requirements of AS/NZS 1715 and AS/NZS 1716.
9. PHYSICAL AND CHEMICAL PROPERTIES:
Clear, straw yellow mobile liquid.
APPEARANCE:
No information available.
ODOUR:
<3
PH (0.3% SOLUTION):
S.G. 1.03
SPECIFIC GRAVITY OR DENSITY:
No information available.
VAPOUR PRESSURE:
Approx 80% w/w
PERCENT VOLATILES:
No information available.
BOILING POINT / RANGE:
No information available.
FREEZING / MELTING POINT:
The product is water based and is fully dispersible in water.
SOLUBILITY:
Not relevant.
FLASH POINT:
Not relevant.
FLAMMABILITY LIMITS:
Not relevant.
IGNITION TEMPERATURE:
2 years from manufacturing date (when stored as directed).
SHELF LIFE:
None.
OTHER:
10. STABILITY AND REACTIVITY
Stable under normal conditions of use. The shelf life is 2 years.
CHEMICAL STABILITY:
Do not combine part drums of the same product, as this may be a source of
CONDITIONS TO AVOID:
contamination.
Strong alkalis and chlorinated products. Do not mix with detergents or other
INCOMPATIBLE MATERIALS:
chemicals.
The packaging material may burn to emit noxious fumes.
HAZARDOUS DECOMPOSITION PRODUCTS:
Reacts exothermically with alkalis. Reacts with chlorinated products to produce
HAZARDOUS REACTIONS:
toxic chlorine gas.
11. TOXICOLOGICAL INFORMATION
No adverse health effects expected if the product is handled in accordance with this Safety Data Sheet and the product label.
Symptoms or effects that may arise if the product is mishandled and overexposure occurs are:
ACUTE EFFECTS
Can be irritating if swallowed.
INGESTION:
Risk of serious damage to eyes. Severe eye irritant and if left untreated may cause severe damage.
EYE CONTACT:
Severe skin irritant and may defat the skin with continual use. If left untreated may cause severe
SKIN CONTACT:
irritation and burning.
High mist and vapour concentrations may irritate the mucous membranes and respiratory irritation.
INHALATION:
No information available.
LONG TERM EFFECTS:
Product Name: Page:
ENVIROSAN 3 of 5
MATERIAL SAFETY DATA SHEET
No toxicity data for this specific product, however toxicity data for the hazardous
ACUTE TOXICITY / CHRONIC TOXICITY:
ingredient is listed below.
TOXICITY DATA FOR ALKYLSULFONIC ACID: Oral LD50 (rat) 1407 mg/kg
TOXICITY DATA FOR 2-HYDROXYPROPONIC ACID: Oral LD50 (rat) 3730 mg/kg
Oral LD50 (mouse) 4875 mg/kg Dermal LD50 (rabbit) > 2000 mg/kg
12. ECOLOGICAL INFORMATION
Avoid contaminating waterways. The product is acidic. If large spills occurred a water
ECOTOXICITY:
pH drop could be responsible for an environmental effect on aquatic organisms.
ECOTOXICITY DATA FOR 2-HYDROXYPROPONIC ACID: LC50 Fish 320 mg/L/48h
EC50 Daphnia 240 mg/L/48h EC50 Algae 3500 mg/L (neutral)
Considered readily biodegradable according to AS4351.
PERSISTENCE AND DEGRADABILITY:
No information available.
MOBILITY:
None.
OTHER:
13. DISPOSAL CONSIDERATIONS
Empty containers should be forwarded to an approved agent for recycling. Avoid
DISPOSAL METHODS:
unauthorised discharge to sewer.
The product is suitable for disposal by landfill through an approved agent. Incineration of
SPECIAL PRECAUTIONS FOR
the product is not recommended, as it is unlikely to adequately burn.
LANDFILL OR INCINERATION:
14. TRANSPORT INFORMATION
Not classified as Dangerous Goods by the criteria of the Australian Dangerous Goods
ROAD AND RAIL TRANSPORT:
Code (ADG Code) for transport by Road and Rail.
NONE
UN NUMBER:
NONE
UN PROPER SHIPPING NAME:
NONE
CLASS AND SUBSIDIARY RISK(S):
NONE
PACKAGING GROUP:
NONE
HAZCHEM CODE:
NONE
SEGREGATION DANGEROUS GOODS:
Not classified as Dangerous Goods by the criteria of the International Maritime
MARINE TRANSPORT:
Dangerous Goods Code (IMDG Code) for transport by sea.
NONE
UN NUMBER:
NONE
UN PROPER SHIPPING NAME:
NONE
CLASS AND SUBSIDIARY RISK(S):
NONE
PACKAGING GROUP:
Not classified as Dangerous Goods by the criteria of the International Air Transport
AIR TRANSPORT:
Association (IATA) for transport by air.
NONE
UN NUMBER:
NONE
UN PROPER SHIPPING NAME:
NONE
CLASS AND SUBSIDIARY RISK(S):
NONE
PACKAGING GROUP:
15. REGULATORY INFORMATION
POISONS SCHEDULE (AUST.): Not scheduled.
Not relevant.
APVMA STATUS:
Not relevant.
TGA STATUS:
All the constituents of this product are listed.
AICS STATUS:
IOA is available upon request.
AQIS STATUS:
MAF Approval (New Zealand). Category C41.
OTHER:
Product Name: Page:
ENVIROSAN 4 of 5
MATERIAL SAFETY DATA SHEET
16. OTHER INFORMATION
None.
GENERAL INFORMATION:
008
MSDS ISSUE NUMBER:
30 JULY 2008
MSDS ISSUE DATE:
In any event, the review and, if necessary, the re-issue of a MSDS shall be no longer than 5 years after the last date of issue.
Electronic versions of the MSDS鈥檚 in a PDF format are also available on our Website at www.cleantec.com.au/product.asp
REASON(S) FOR ISSUE: 005: Update to conform to requirements of NOHSC:2011(2003); 16-header format, and added
AQIS and MAF information.
006: Addition of New Zealand contact details. No new regulatory information.
007: Formulation change.
008: Update to New Zealand Address details. No new regulatory information.
THIS ISSUE NUMBER REPLACES ALL PREVIOUS ISSUES.
LITERARY REFERENCE:
SOURCES FOR DATA:
LEGEND:
AICS Australian Inventory of Chemical Substances
APVMA Australian Pesticides and Veterinary Medicines Authority
AQIS Australian Quarantine and Inspection Service
AS Australian Standard (as issued by Standards Australia)
ASCC Australian Safety and Compensation Council (formerly NOHSC)
ERG Code Emergency Response Drill Code as found in the ICAO (International Civil Aviation Organisation) Doc 9481
MSDS Material Safety Data Sheet
NOHSC National Occupational Health and Safety Commission
STEL Short Term Exposure Limit - A 15 minute TWA exposure which should not be exceeded at any time during a
working day even if the eight-hour TWA average is within the TWA exposure standard. Exposures at the STEL
should not be longer than 15 minutes and should not be repeated more than four times per day. There should be
at least 60 minutes between successive exposures at the STEL.
TGA Therapeutic Goods Administration
TLV Threshold Limit Value - TLV is a proprietary name registered by the American Conference of Governmental
Industrial Hygienists (ACGIH) and refers to airborne concentrations of substances or levels of physical agents to
which it is believed that nearly all workers may be repeatedly exposed day after day without adverse effect.
TWA Time Weighted Average - The average airborne concentration of a particular substance when calculated over a
normal eight-hour working day, for a five-day working week.
This MSDS has been prepared from current technical data and summarises at the date of issue our best knowledge of the health and safety
information of the product, and in particular how to safely handle and use the product in the workplace.
If clarification or further information is needed to ensure that an appropriate assessment can be made, the user should contact this company.
Our responsibility for products sold is subject to our standard terms and conditions, a copy of which is sent to our customers and is also
available upon request.
This MSDS may only be reproduced in full. Summaries or excerpts from this MSDS may not contain all the relevant information and thus are
not permitted.
End of MSDS
Product Name: Page:
ENVIROSAN 5 of 5
|