EMS CAT AL OG # : 50376-05
EMS PR ODUCT : FOR MUL A C
DAT E: OCT 19, 2001
PAGE NUMB ER : ONE OF 5
MAT ER I AL S AFET Y DAT A S HEET
T he information contained herein is based on data considered accurate.
However, no warranty is expressed or implied regarding the accuracy of these
data or the results to be obtained from the use thereof.
Electron Microscopy Sciences assumes no responsibility for personal injury or
property damage to vendees, users or third parties caused by the material. Such
vendees or users assume all risks associated with the use of the material.
Elect r on Micr oscopy S ciences
321 Morris Road * P.O. Box 251 web: http://www.emsdiasum.com
Fort Washington, PA 19034 email: sgkcck@aol.com
(215) 646-1566 Fax: 215-646-8931
24 HOUR EMER GENCY PHONE NUMB ER : CHEMT R EC (800) 424-9300
CHEMI CAL PR ODUCT AND COMPANY I DENT I F I CAT I ON
MANUFAC URER/SUPPLI ER:
T
Electron Microscopy Sciences
321 Morris Road
Fort Washington, PA 19034
PRODUC NAME: FORMULA C
T
DESC PT I ON:
RI Lapping Vehicle
COMPOS I T I ON/ I NFOR MAT I ON ON I NGR EDI ENT S
NAME: C#
AS PERCENT OSHA PEL AC I H T LV
G
Straight Run
Middle distillatel 64741-44-2 > 90 5mg/m3(mist) 5mg/m3(mist)
Ethylene glycol
monobutyl ether 111-76-2 < 10 25ppm 25 ppm (skin)
HAZ AR DS I DENT I FI CAT I ON
EMERG ENC OVERVI EW: Product has been determined to be mildly
Y
carcinogenic..
POT ENT I AL HEALT H EFFEC S: T
EYE: I rritation and pain; excess tearing, redness and swelling of the
conjunctiva.
SKI N: I rritation. Prolonged contact may cause dermatitis, defatting,
and drying of the skin. A weak to moderate carcinogen.
Moderately toxic.
I NG I ON: Headache, dizziness, incoodination, vomiting, aspiration and
EST
diarrhea. Moderately toxic.
I NHALAT I ON: I rritation of the respiratory tract, central nervous system
depression, and chemical pneumonitis.
CHRONI C HEALT H EFFEC S/C T ARC NOG C T Y
I ENI I
NT P: Not listed.
OSHA: Not listed.
I ARC : Not listed.
Medical Restrictions: Preexisting dermal or respiratory disorders or allergies may
be aggravated by exposure to this product..
FI R S T AI D MEAS UR ES
EYES: Flush eyes with water for 15 minutes. I f irritation persists, get
medical attention.
SKI N: Remove contaminated clothing and wash before reuse. I tems
that cannot be decontaminated should be discarded. Wash skin
with soap and water promptly. G medical attention if irritation
et
persists.
I NG I ON:
EST Do not induce vomiting; if it occurs spontaneously, keep head
below hips to prevent aspiration of liquid into the lungs. G et
medical attention.
I NHALAT I ON: Remove to fresh airand administer oxygen if breathing is
difficult.
FI R E FI GHT I NG MEAS UR ES
FI RE FI G I NG C
HT : aution. Do not enter fire space without full bunker gear
(helmet with face shield, bunker coats, and rubber boots),
including a positive-pressure NI OSH-approved self-contained
breathing apparatus. C fire exposed containers with water.
ool
Catalog # 50376-05 Page 2 of 2
Formula C
I n the case of large fires, also cool surrounding equipment and
structures with water.
EXT I NG SHI NG MEDI A: Use water for, foam, dry chemical or carbon dioxide.
UI
HAZARDOUS C OMBUST I ON PRODUC S: C T arbon monoxide, carbon dioxide, and
other unidentified organic compounds.
FLASH POI NT : 178oF., Pensky-Martens closed cup.
LOWER FLAMMABLE LI MI T : 0.7
UPPER FLAMMABLE LI MI T : 6.0
AUT OI G T I ON: Not available.
NI
CONDI T I ONS OF FLAMMABI LI T Y: Product will float and may be ignited on
surface of water. C lassified as a combustible liquid.
EXPLOSI ON DAT A
I MPAC SENSI T I VI T Y: Not known.
T
ST AT I C DI SCHARG E: Not known.
ACCI DENT AL R EL EAS E MEAS UR ES
GENERAL: Eliminate sources of ignition. Wear appropriate protection.
SMALL SPI LLS: Wipe up with absorbent material and place in non-leaking
container for proper disposal.
LARG SPI LLS: Shut off source of leak if safe to do so. Dike and contain spill;
E
soak up material with clay, sand or other suitable absorbent; do
not use sawdust which may create an explosion hazard.
Dispose of in non-leaking container and seal tightly for disposal.
Flush area with water to remove trace residue. Dispose of flush
solution in same manner as above.
HANDL I NG AND S T OR AGE
HANDLI NG: Wear appropriate protection. Wash with soap and water before
eating, drinking, smoking, or using toilet facilities. Launder
contaminated clothing before reuse; clothing or shoes that
cannot be decontaminated should be discarded.
ST ORAGE: Keep container closed when not in use. Keep liquid away from
heat, sparks or flame. Surfaces that are sufficiently hot may
cause liquid to ignite even in the absence of spark or flame.
EXPOS UR E CONT R OL S / PER S ONAL PR OT ECT I ON
EXPOSURE LI MI T S: See Section Labeled Composition / I nformation on
I ngredients.
Catalog # 50376-05 Page 3 of 3
Formula C
VENT I LAT I ON: G eneral recommended; local as needed to keep exposure
below stated limits.
RESPI RAT ORY PROT EC I ON: Use NI OSH-approved air supplying or air-purifying
T
respirator for organic vapors-purifying respirator for
organic vapors
EYE PROT EC I ON: OSHA-approved safety glasses.
T
SKI N PROT EC I ON: C
T hemical resistant or nitrile gloves.
OT HER: Eye bath and safety shower should be available.
PHYS I CAL AND CHEMI CAL PR OPER T I ES
PHYSI C ST AT E: Liquid.
AL
COLOR: Yellow.
ODOR: Mild hydrocarbon odor.
SPEC FI C G
I RAVI T Y: 0.88, water= 1
VAPOR PRESSURE: Not available.
VAPOR DENSI T Y: > 1, air= 1
EVAPORAT I ON RAT E: Not available.
VOLAT I LE FRAC I ON
T
BY WEI G :
HT 100
340oF
BOI LI NG POI NT :
MELT I NG POI NT : 15oF
DYNAMI C VI SC T Y: 18.5 centipoise.
OSI
KI NEMAT I C VI SC T Y: Not available.
OSI
SOLUBI LI T Y I N WAT ER: I nsoluble
Ph: Not applicable.
S T AB I L I T Y AND R EACT I VI T Y
ST ABI LI T Y: Stable.
REAC I VI T Y:
T Avoid extreme heat and open flame.
I NCOMPAT I BI LI T Y: Alkalis and oxidizing materials.
HAZARDOUS POLYMERI ZAT I ON: Will not occur.
DEC OMPOSI T I ON: C arbon monoxide and other unidentified organic compounds.
T OXI L OGI CAL I NFOR MAT I ON
Repeated dermal application of high levels of middle distillate fuels in
experimental animals has produced extremely severe irritation to corrosive action
on the skin. Varying degrees of liver and kidney damage were noted in these
studies, including congestion, enlargement, mottling, and multifocal necrosis.
Catalog # 50376-05 Page 4 of 4
Formula C
Middle distillate fuels have been demonstrated to cause chromosome damge in
the vivo rat bone marrow cytogenics assay, and mutagenic in the L5178Y mouse
lymphoma assay.
ECOL OGI CAL I NFOR MAT I ON
No information available.
DI S POS AL I NFOR MAT I ON
RC HAZARDOUS WAST E: Hazardous solid waste under RC
RA RA.
WAST E DI SPOSAL: Place in an appropriate disposal facility in accordance with
Federal, State and Local regulations.
T R ANS FOR MAT I ON I NFOR MAT I ON
DOT HAZARD C LASS: Not regulated.
PROPER SHI PPI NG NAME: Not Listed.
I DENT I FI C I ON # :
AT Not Listed.
R EGUL AT OR Y I NFOR MAT I ON
FEDERAL EPA
SARA T I T LE I I I : G lycol ethers, section 313. Straight run middle distillate
listed in categories H-1 and H-2 under section 311/312:
Acute health hazard, C hronic health hazard.
T SC ST AT US: All ingredients of this product are on the T SC inventory.
A A
WHMI S C LASSI FI C I ON: Not known.
AT
ST AT E RI G T O KNOW
HT
C FORNI A-65:
ALI Not listed.
FLORI DA: Not listed.
MASSAC HUSET T S: Ethylene glycol monobutyl ether.
NEW JERSEY: Ethylene glycol monobutyl ether. G oil
as
PENNSYLVANI A: Ethylene glycol monobutyl ether.
OT HER
HMI S CODE: Health 2, Flammability 2, Reactivity 0
(0= minimal hazard, 1-slight hazard, 2= moderate hazard, 3= serious hazard, 4= extreme hazard)
Catalog # 50376-05 Page 5 of 5
Formula C
|