MATERIAL SAFETY DATA SHEET
MSDS DATE:07/27/07
SECTION 1: PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME: DETERGENT 8
SYNONYMS: N/A
PRODUCT CODES: 60538-01
MANUFACTURER: ELECTRON MICROSCOPY SCIENCES
DIVISION: 1560 INDUSTRY ROAD/P.O. BOX 550
ADDRESS: HATFIELD, PA 19440
EMERGENCY PHONE: 215-412-8400
CHEMTREC PHONE: 800-424 -4300
FAX PHONE: 215-412-8450
CHEMICAL NAME: DETERGENT 8
CHEMICAL FAMILY: N/A
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS
INGREDIENT:
BUTOXY ETHANOL
DIPROPYLENE GLYCOL MONOMETHYL ETHER
ISOPROPANOLAMINE
CAS NO. % WT % VOL SARA 313 REPORTABLE
111-76-2 N/A 5-10
34590-94-8 N/A 10-30
78-96-6 N/A 35-50
ppm mg/m3
OSHA PEL-TWA: N/A N/A
OSHA PEL STEL : N/A N/A
OSHA PEL CEILING: N/A N/A
ACGIH TLV-TWA: 20 N/A
ACGIH TLV STEL: 100 N/A
ACGIH TLV CEILING:
SECTION 3: HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW:
ROUTES OF ENTRY: SKIN CONTACT, EYE CONTACT, INHALATION AND INGESTION
POTENTIAL HEALTH EFFECTS
EYES: CAUSES IRRITATION, REDNESS AND PAIN. MAY CAUSE SWELLING. CAUSES CHEMICAL BURNS
SKIN: MAY CAUSE CHEMICAL BURNS. MAY CAUSE REDNESS, SWELLING. IRRITANT
INGESTION: MAY CAUSE VOMITING. CAUSES IRRITATION OF THE DIGESTIVE TRACT. MAY CAUSE ABDOMINAL PAIN. MAY
CAUSE GASTRIC DISTRESS. LARGE AMOUNTS MAY CAUSE RED BLOOD CELL DAMAGE.
INHALATION: MAY CAUSE HEADACHE. POSSIBLE IRRITATION OF THE UPPER RESPIRATORY TRACT. MAY CAUSE
IRRITATION OF THE MUCOUS MEMBRANES. MAY CAUSE DISCOMFORT.
ACUTE HEALTH HAZARDS: N/A
CHRONIC HEALTH HAZARDS: N/A
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:N/A
PAGE 1 OF 5
MATERIAL SAFETY DATA SHEET
MSDS DATE:07/27/07
CARCINOGENICITY
OSHA: N/A ACGIH: N/A NTP: N/A IARC: N/A
OTHER: N/A
SECTION 4: FIRST AID MEASURES
EYES: FLUSH WITH WATER FOR 15 MINUTES. HOLD EYELIDS OPEN DURING FLUSHING. SEEK MEDICAL
ATTENTION IMMEDIATLEY. CHECK FOR AND REMOVE CONTACT LENSES
SKIN: REMOVE CONTAMINATED CLOTHING. WASH THOROUGHLY WITH SOAP AND WATER. SEEK MEDICAL ATTENTION IF
IRRITATION PERSISTS. DO NOT ATTEMPT TO NEUTRALIZE WITH CHEMICAL AGENTS
INGESTION: DILUTE WITH LARGE QUANTITIES OF WATER OR MILK. DO NOT INDUCE VOMITING, SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHIGN BY MOUTH TO AN UNCONSCIOUS PERSON
INHALATION: REMOVE VICTIM TO FRESH AIR. IF IRRITATION PERSISTS, SEEK MEDICAL ATTENTION
NOTES TO PHYSICIANS OR FIRST AID PROVIDERS:
SECTION 5: FIRE-FIGHTING MEASURES
FLAMMABLE LIMITS IN AIR, UPPER: NOT FLAMMABLE
(% BY VOLUME) LOWER: NOT FLAMMABLE
FLASH POINT:
F: 200
C: 93.3
METHOD USED: N/A
AUTOIGNITION TEMPERATURE: N/A
F: N/A
C: N/A
NFPA HAZARD CLASSIFICATION
HEALTH: N/A FLAMMABILITY: N/A REACTIVITY: N/A
OTHER: N/A
HMIS HAZARD CLASSIFICATION
HEALTH: N/A FLAMMABILITY: N/A REACTIVITY: N/A
PROTECTION: N/A
EXTINGUISHING MEDIA: CARBON DIOXIE, DRY CHEMICAL, FOAM, WATER FOG.
SPECIAL FIRE FIGHTING PROCEDURES: SELF CONTAINED BREATHING APPARATUS REQUIRED. FIREFIGHTERS SHOULD WEAR
THE USUAL PROTECTIVE GEAR. USE WATER TO COOL EXPOSED CONTAINERS
UNUSUAL FIRE AND EXPLOSION HAZARDS:
HAZARDOUS DECOMPOSITION PRODUCTS: OXIDES OF CARBON (COx). AMMONIA (NH3). HYDRACARBONS
SECTION 6: ACCIDENTAL RELEASE MEASURES
ACCIDENTAL RELEASE MEASURES: CONTAIN THE SPILL. PREVENT ENTRY INTO DRAINS, SEWERS, AND OTHER WATERWAYS.
WEAR APPROPRIATE PROTECTIVE EQUIPMENT. SOAK UP WITH AN ABSORBENT MATERIAL. SMALL AMOUNTS MAY BE
FLUSHED INTO SANITARY SEWER. PLACE IN AN APPROPRIATE CONTAINER FOR DISPOSAL.
PAGE 2 OF 5
MATERIAL SAFETY DATA SHEET
MSDS DATE:07/27/07
SECTION 7: HANDLING AND STORAGE
HANDLING AND STORAGE: PROTECT AGAINST PHYSICAL DAMAGE. AVOID BREATHING VAPORS/MISTS. WEAR PERSONAL
PROTECTIVE EQUPIMENT APPROPRIATE TO TASK. WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF REACH OF
CHILDREN. AVOID CONTACT WITH SKIN, EYES, AND CLOTHING. AVOID EXTREME TEMPERATURES. LAUNDER CONTAMINATED
CLOTHING PRIOR TO REUSE.
STORE AWAY FROM INCOMPATIBLE MATERIALS. KEEP CONTAINERS CLOSED WHEN NOT IN USE.
OTHER PRECAUTIONS: N/A
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS:
VENTILATION: LOCAL EXHAUST AT POINTS OF EMISSION
RESPIRATORY PROTECTION: IF TLV IS EXCEEDED, WEAR AN APPROVED RESPIRATOR.
EYE PROTECTION: CHEMICAL SAFEY GOGGLES WITH SIDE-SHIELDS.
SKIN PROTECTION: NEOPRENE OR RUBBER GLOVES
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: SAFETY SHOES PER LOCAL REGULATION. CLOTHING AS REQUIRED TO
PREVENT SKIN CONTACT. EYE WASH FACILITY SHOULD BE IN CLOSE PROXIMITY.
WORK HYGIENIC PRACTICES: WASH THOROUGHLY AFTER HANDLING. WASH CLOTHING BEFORE REUSE.
EXPOSURE GUIDELINES: N/A
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE: COLOURLESS
ODOR: CHARACTERISTIC ODOR OF SOLVENT
PHYSICAL STATE: LIQUID
pH AS SUPPLIED: 11.2
pH (Other): N/A
BOILING POINT:
F: 212
C: 100
MELTING POINT: N/A
F: N/A
C: N/A
FREEZING POINT: N/A
F: N/A
C: N/A
VAPOR PRESSURE (mmHg): 17
@
F: 68 DEG
C: 20 DEG
VAPOR DENSITY (AIR = 1): >1
@
F: N/A
C: N/A
@
F: N/A
C: N/A
PAGE 3 OF 5
MATERIAL SAFETY DATA SHEET
MSDS DATE:07/27/07
EVAPORATION RATE: N/A
BASIS (=1): N/A
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES (con鈥檛)
SOLUBILITY IN WATER: COMPLETE
PERCENT SOLIDS BY WEIGHT: N/A
PERCENT VOLATILE: N/A
BY WT/ BY VOL @
F: N/A
C: N/A
VOLATILE ORGANIC COMPOUNDS (VOC):
WITH WATER: LBS/GAL
WITHOUT WATER: LBS/GAL
MOLECULAR WEIGHT: N/A
VISCOSITY: N/A
@
F: N/A
C: N/A
SECTION 10: STABILITY AND REACTIVITY
STABILITY: PRODUCT IS STABLE UNDER NORMAL HANDLING AND STORAGE CONDITIONS
CONDITIONS TO AVOID (STABILITY): EXTREME TEMPERATURES
INCOMPATIBILITY (MATERIAL TO AVOID): STRONG ACIDS, STRONG ALKALIES, STRONG OXIDIZING AGENTS
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: N/A
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
CONDITIONS TO AVOID (POLYMERIZATION): NONE
SECTION 11: TOXICOLOGICAL INFORMATION
TOXICOLOGICAL INFORMATION: N/A
SECTION 12: ECOLOGICAL INFORMATION
ECOLOGICAL INFORMATION: N/A
SECTION 13: DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHOD: COMPLY WITH FEDERAL, STATE, LOCAL REGULATIONS.
RCRA HAZARD CLASS: N/A
SECTION 13: DISPOSAL CONSIDERATIONS (con鈥檛)
PAGE 4 OF 5
MATERIAL SAFETY DATA SHEET
MSDS DATE:07/27/07
SECTION 14: TRANSPORT INFORMATION
U.S. DEPARTMENT OF TRANSPORTATION
PROPER SHIPPING NAME: CORROSIVE LIQUID, N.O.S.
HAZARD CLASS: 8
ID NUMBER: UN 1760
PACKING GROUP: II
LABEL STATEMENT:CONTAINS MONOISOPROPANOLAMINE
WATER TRANSPORTATION
PROPER SHIPPING NAME:
HAZARD CLASS: SAME
ID NUMBER:
PACKING GROUP:
LABEL STATEMENTS:
AIR TRANSPORTATION
PROPER SHIPPING NAME:
HAZARD CLASS: SAME
ID NUMBER:
PACKING GROUP:
LABEL STATEMENTS:
OTHER AGENCIES: N/A
SECTION 15: REGULATORY INFORMATION
U.S. FEDERAL REGULATIONS
TSCA (TOXIC SUBSTANCE CONTROL ACT): N/A
CERCLA (COMPREHENSIVE RESPONSE COMPENSATION, AND LIABILITY ACT): N/A
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT): N/A
311/312 HAZARD CATEGORIES: N/A
313 REPORTABLE INGREDIENTS: N/A
STATE REGULATIONS: N/A
INTERNATIONAL REGULATIONS: N/A
SECTION 16: OTHER INFORMATION
OTHER INFORMATION: N/A
PREPARATION INFORMATION: N/A
DISCLAIMER: IN COMPLIANCE WITH THE OSHA HAZARD COMMUNICATION STANDARD, 2.9 C.F.R
1910. 1200, WE ARE PROVIDING YOU WITH A MSDS FOR THE HAZARDOUS MATERIAL YOU ARE
PURCHASING.
IT IS YOUR RESPONSIBILITY TO EDUCATE YOUR EMPLOYEES ON THE SAFE USE OF THE HAZARDOUS
MATERIAL.
ELECTRON MICROSCOPY SCIENCES MAKES NO PRESENTATION AS TO THE ACCURACY OF THE
INFORMATION IN THE MSDS. THE INFORMATION IS BELIEVED TO BE CORRECT; HOWEVER, YOU
(THE CUSTOMER), SHOULD PERFORM YOUR OWN INVESTIGATION AND INDEPENDENT
VERIFICATION. IF YOU RESELL THE PRODUCT, YOU ARE RESPONSIBLE TO FORWARD THE
INFORMATION IN THE MSDS TO YOUR CUSTOMER.
PAGE 5 OF 5
|