Epoxy Systems, Inc.
20774 West Pennsylvania Ave
Dunnellon, FL 34431
Phone 352-489-1666
Material Safety Data Sheet
OSHA's Hazard Communication Standard,
29 CFR 1910.1200.
EPOXY.COM#215 LVOC鈥淎鈥? Component
IDENTITY:
SECTION I
Manufacturer: Epoxy Systems, Inc. Emergency Number: 1-800-633-8253 PERS
Address: 20774 West Pennsylvania Ave Telephone Number: 352-489-1666
Dunnellon, FL 34431
Date Prepared: 11/2007
SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
Hazardous Components CAS # OSHA PEL ACHIH TLV Hazard Limits %
Methyl Isobutyl Ketone 108-10-1 100 ppm
Petroleum Solvent 64742-94-5 100 ppm
Xylene 1330-20-7 100 ppm
Green Ion Oxide 1308-38-9 N/E
Epoxy Resin 25036-25-6 N/E
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: 240 潞 F Specific Gravity (H20 =1): 1.2
Vapor Pressure (mm Hg.): 40 mmHg Melting Point: N/A
Vapor Density (AIR = 1): 3.45 Evaporation Rate: <1
Solubility in Water: Insoluble (Butyl Acetate = 1)
Appearance and Odor: Green liquid, solvent odor
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): 80潞F PM Closed Cup Flammable Limits: LEL N/D UEL N/D
Extinguishing Media: Dry chemical, CO2, foam, water spray
Special Fire Fighting Procedures: Self-contained breathing apparatus should be worn in confined areas.
Unusual Fire and Explosion Hazards: Flammable vapors form explosive mixtures with air
SECTION V - REACTIVITY DATA
Stability: Stable Conditions to Avoid: Heat or open flame
Incompatibility: Acids, alkalies
Hazardous Decomposition or Byproducts: Carbon monoxide
Hazardous Polymerization: Will not occur Conditions to Avoid:
(OVER)
EPOXY.COM #215 LVOC鈥淎鈥? Comp. cont
SECTION VI - HEALTH HAZARD DATA
Route(s) of Entry: Inhalation: Yes Skin: No Ingestion: No
Health Hazards (Acute and Chronic): Solvent blend can be irritating to eyes and respiratory tract. Moderately
toxic when ingested.
Carcnogenicity: NTP: Not listed IARC Monographs: Not listed OSHA Regulated: Not listed
Signs and Symptoms of Exposure: Vapor may cause headaches and dizziness and nausea
Medical Conditions Generally Aggravated by Exposure: Skin irritation
Emergency and First Aid Procedures: Skin: Flush with soap and water. Eyes: Flush with water for at least 15
minutes. Seek medical attention.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps to Be Taken in Case Material Is Released or Spilled: Remove source of ignition. Soak up with absorbent
materials.
Waste Disposal Method: Burn in approved incinerator in compliance with Federal, State, and local regulations
Precautions to Be Taken in Handling and Storing: Keep containers closed. Keep in cool area
Other Precautions: Avoid breathing vapors
SECTION VIII - CONTROL MEASURES
Respiratory Protection: NIOSH approved organic respiratory in confined areas.
Ventilation: Mechanical (General): Good general ventilation
Protective Gloves: Rubber gloves Eye Protection: Safety glasses
Other Protective Clothing or Equipment: Long sleeve clothing.
Work/Hygienic Practices: Follow practice of good industrial hygiene.
N/A = Not Applicable N/D = Not Determined N/E = Not Established
Epoxy Systems, Inc.
20774 West Pennsylvania Ave
Dunnellon, FL
Phone 352-489-1666
Material Safety Data Sheet
OSHA's Hazard Communication Standard,
29 CFR 1910.1200.
EPOXY.COM#215 LVOC鈥淏鈥? Component
IDENTITY:
SECTION I
Manufacturer: Epoxy Systems, Inc. Emergency Number: 1-800-633-8253
Address: 20774 West Pennsylvania Ave Telephone Number: 352-489-1666
Dunnellon, FL 34431
Date Prepared: 5/2003
SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
Hazardous Components CAS # OSHA PEL ACHIH TLV Hazard Limits %
Xylene 1330-20-7 100 ppm
Petroleum Solvent 64742-94-5 100 ppm
Propylene Glycol Methyl Ether 107-98-2 100 ppm
Polyamid Resin 68410-23-1 N/E
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: 240潞 F Specific Gravity (H20 =1): 1.44
Vapor Pressure (mm Hg.): 40 mm Hg Melting Point: N/A
Vapor Density (AIR = 1): 3.2 Evaporation Rate: <1
Solubility in Water: Negligible (Butyl Acetate = 1)
Appearance and Odor: Amber liquid, aromatic odor
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): 80潞F PM Closed Cup Flammable Limits: LEL N/D UEL N/D
Extinguishing Media: Foam, CO2, dry chemical
Special Fire Fighting Procedures: Wear self-contained breathing apparatus in enclosed areas
Unusual Fire and Explosion Hazards: Fire hazard when exposed to open flame
SECTION V - REACTIVITY DATA
Stability: Stable Conditions to Avoid: Heat or open flame
Incompatibility: Acids, alkalines
Hazardous Decomposition or Byproducts: Carbon monoxide
Hazardous Polymerization: Will not occur Conditions to Avoid:
(OVER)
EPOXY.COM#215 LVOC鈥淏鈥? Comp. cont
SECTION VI - HEALTH HAZARD DATA
Route(s) of Entry: Inhalation: Yes Skin: No Ingestion: No
Health Hazards (Acute and Chronic): Solvent blend can be irritating to eyes and respiratory tract. Moderately toxic
when ingested.
Carcnogenicity: NTP: Not listed IARC Monographs: Not listed OSHA Regulated: Not listed
Signs and Symptoms of Exposure: Vapor may cause headaches and dizziness and nausea
Medical Conditions Generally Aggravated by Exposure: Skin irritation
Emergency and First Aid Procedures: Skin: Flush with soap and water. Eyes: Flush with water for at least 15
minutes. Seek medical attention.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps to Be Taken in Case Material Is Released or Spilled: Remove source of ignition. Soak up with absorbent
materials.
Waste Disposal Method: Burn in approved incinerator in compliance with Federal, State, and local regulations
Precautions to Be Taken in Handling and Storing: Keep containers closed. Keep in cool area
Other Precautions: Avoid breathing vapors
SECTION VIII - CONTROL MEASURES
Respiratory Protection: NIOSH approved organic respiratory in confined areas.
Ventilation: Mechanical (General): Good general ventilation
Protective Gloves: Rubber gloves Eye Protection: Safety glasses
Other Protective Clothing or Equipment: Long sleeve clothing.
Work/Hygienic Practices: Follow practice of good industrial hygiene.
N/A = Not Applicable N/D = Not Determined N/E = Not Established
|